Prius (2004-09) :: CEL Came On And Throwing Code P1116
Wife has a 2013 V and I bought a 2007 with 200000k on the clock. Got a good deal on the car and knew I would have some issues so here is what I am battling. CEL came on and throwing code P1116. We all know the generic code saying engine coolant temp sensor, cooling sensor clogged, etc. this is the only code on the reader. I checked the coolant level and everything is within standards. No leaks appear from the lines. I believe the carfax shows a fender bender so maybe the CHS tank sensor didn't get replaced? So, I guess what I am asking is:
Should I buy a MINi VCI to locate the problem (I plan on getting one eventually just wanted to save money isolating the problem now)? ECU problem? I have read previous post with bad ECUs throwing P1116 but these post were 2+ years. Sometimes it sounds like there might be gurgling from the dash...I say sometimes lightly because it is very faint but have also read older post stating air could throw the p1116 code so maybe a coolant flush?
Also, big question: is the engine coolant temp sensor identical to the CHS tank sensor? The local parts store couldn't find a CHS tank sensor part number just the engine so didn't know if they were the same.
Prius (Gen 2) :: Diagnosed Code P1116, Red Triangle And Headlight Icon
I got red triangle and headlight icon on the screen. I hooked OBD and It gave me error code P1116, I checked all my front, back lights are working fine.
View 19 RepliesPrius (2004-09) :: Check Engine Light Came On With Code P1116
My check engine light came on with a p1116 on my 2008 with 138k. I replaced the sensor, but the p1116 came back. How to fix. I'm going to replace the coolant today, I read somewhere there might be a clog.
View 1 RepliesGolf IV / Jetta IV :: Leaking Gas When Key Is Turned
My Jetta is leaking gas like a sieve when the fuel pump starts. Its pretty obvious where its coming from. What this part is called or if there is more to it than just replacing it. Its coming from the round looking part on the fuel rail. Let me know what you think.
2000 Jetta 2.0 GLS Manual
[URl] ....
Golf IV / Jetta IV :: Fan Automatically Quits When AC Is Turned On
I have been trying to tackle my AC problems for quite some time now...I noticed my AC was not working properly a little while back, so I ran the diagnostics on climatronic. It came back saying AC high pressure switch. I replaced that -- still nothing. I continued to run more diagnostics. My fans run when the car heats up, so its not overheating, but when I turn on the AC, no fans come on automatically. I jumpered the fans directly off the battery and they both work on both speeds. When I hook it up to the thermo switch plug, it only works on low speed. I replaced the FCM, which had a lot of corrosion on it -- I Even had to run repair wire for 2 of the pin ports. I Jumpered the compressor too, and it seems to have kicked on as well. Even if the compressor were bad, wouldn't the fans still try to run when AC was on.
View 12 RepliesGolf IV / Jetta IV :: Car Won't Shift Out Of Park When Turned On
I have a 2002 Golf GLS. About a week ago I was driving around like a raped ape and spilled some soda down the gear shifter. I cleaned it up and didn't think anything of it. Recently, now that it's been getting colder out I found that my car doesn't want to shift out of park when I turn it on. No worries, just did the ("Step on the brake pedal five times,
hold the brake pedal down, start the car, shut off the car, turn the key a quarter turn, move the shift lever between neutral & drive, start the car and then you can move it into drive.") and shifted into gear fine.
[URL]............................
Golf IV / Jetta IV :: Turned Over / Ran For About 2 Seconds And Shut Down
So I go to start up the old girl the other day and she turned right over, ran for about 2 seconds, and shut down. I tried to start it again with the same result. When I turn the ignition forward, before starting it, this image with a car and a key below it starts flashing on the gauge and the odometer starts flashing "service". I tried using a different key with the same results, what this might be?
View 5 RepliesGolf IV / Jetta IV :: Hard To Get The Car Turned Over After Filling Up
I only see this issue after I've been driving a while and I've just topped off. I don't always use the same octane, (I'll use higher octane on long drives) so I may be mixing octanes on these occurrences. But I will have a problem getting the car turned over after filling up. I hold the starter on and pump the gas to get it started (maybe 5-10 seconds).
2.slow BEV engine
2004 GL
107K miles
Golf IV / Jetta IV :: 2001 - No Spark When Engine Turned Over
2001 Jetta GL, 2.0L, 170k miles.... It won't start and it's not likely the fuel pump. After the car has sat for a while, I hear the fuel pump spin up when I open the door. It turns over just fine. I pulled a spark plug, attached it back to the wire, held it close to the head, and when the engine turned over, no spark. Is that still a valid test for spark? I haven't had to diagnose a spark issue for so many years, I don't know whether that has changed.
View 18 RepliesGolf IV / Jetta IV :: Windshield Wipers Come On When Defroster Is Turned On
Why does my front windshield wipers come on when I turn on my rear defroster?
View 2 RepliesGolf IV / Jetta IV :: Turn Signal Turned On And Staying On
Had an issue arise today where out of the blue my turn signal decided to turn on and stay on... and i do not mean it was blinking as if i was going to turn i mean solid on, no clue what caused the issue, the stalk is still in the middle position, and when i turn the other side on (passenger/right) it blinks normally, now if I turn the hazards on they both come on and stay on solid, this problem does not even stop when i pull the key out of the ignition, I have to remove the negative battery strap for it to turn off completely.
View 3 RepliesGolf IV / Jetta IV :: When Tried To Pop The Clutch To Start It Went Into Gear But Nothing Turned On
This morning my cars battery was dead and when I tried to pop the clutch to start it it went into gear but nothing turned on. When jump starting the car it turned on I drove it for a little while and was idling when it shut back off (battery was dead again). I came back to the car in a couple minutes, tried to start it and it started right up. I'm not sure what to think of this.
View 4 RepliesGolf IV / Jetta IV :: Low Oil Light Flashing And Car Turned Off Straight Away
I was driving around and I got a low oil light flashing and it turned off straight away.
So I checked my oil. When I first removed the dipstick it shows full, wiped it clean and put it back and it showed empty.
I put have a bottle (small one can't remember size) of oil in. I drove around parked waited a bit, and it does this same thing.
Golf IV / Jetta IV :: 1999 VR6 Shaking Quite A Bit On Startup And When Turned Off
So my VR6 shakes quite a bit on startup and when I turn it off. I figured it was the dogbone mount. I did the clutch trick, jacked up the front end and engaged the transmission. Of course the engine shook a lot, in a forward to back motion, signalling the dogbone was bad. Shifts into and out of 1st and 2nd were pretty rough and i could feel it in both the driver and passenger seats during idle.
Well I just installed the ECS dogbone and while I can't really feel it much in the seats anymore, it still shakes quite a bit once the transmission is engaged. Low end shifts really haven't gotten much better either.
So I am thinking its either one of the other mounts, or the polyurethane bushing needs to be worked in. I am leading toward the former.
Golf IV / Jetta IV :: 1.8t AWP Won't Start - Fuel Pump Not Priming When Key Turned On
Its a 2005 awp 1.8t gti with 180K stage 2 apr. When i tune the key to the accessories on position I used to hear the fuel pump priming but now I don't and the car wont start.
View 5 RepliesGolf IV / Jetta IV :: 2003 - Some Vents Blow Colder Than Others When AC Turned On
I have a 2003 Jetta GLI. When i turn my a/c on some of the vents blow harder and colder than the others. Why that would be?
View 10 RepliesGolf IV / Jetta IV :: 2002 - Not Starting - Engine Turned Over Very Slowly
I have 2002 2.0 Jetta that I totaled. I found a 2000 2.0 Jetta that had no engine or tran. I swapped the entire wiring harness with the engine and trans from 2002 into 2000. I even swapped the doors. The cluster, steering column and all. I am still in the process of getting a few parts to finish it up. At this point, the only thing not hooked up is the headlights and the radiator. I hooked up a battery and tried to get it to turn over today. I turned the key to the on position and the cluster did not do anything. The engine turned over very slowly in the start position.
View 21 RepliesGolf IV / Jetta IV :: 2001 - When The Car Is Turned Off The Cooling Fans Stay On
I have a 2001 jetta 1.8 turbo. when I turn the car off the cooling fans stay on and kill my battery. Ive been told it could either be a relay or temp sending unit but i dont know what one to tackle first, also my coolent temp stays way low almost as if the thermostat is stuck open.
View 2 RepliesGolf IV / Jetta IV :: Windshield Wipers Turned On And Won't Stop When Car Started
As soon as I start the car the windshield wipers start on their own and wont stop. I diagnosed the relay as my fualt and I was partly correct. I put the new relay and it worked. However I still had the rear wiper motor disconnected. Once I plugged rear motor back in, the front windshield wipers started going on their own and won't stop again. So, what should be next? Motor diagnoses? I can't see any visual water damage in the motor when the cover is off.
View 8 Replies