Golf IV / Jetta IV :: P0422 Code - Main Catalyst Below Efficiency
I have been trowing a P0422 code which is main catalyst below efficiency.
I recently changed the rear o2 sensor and about 60 miles later the same code came back.
Logic dictates that the Cat is bad or there is an air fuel issue. No other codes have been thrown.
The car is a 1999 Jetta 2.0L AEG engine but it only has 51k miles on it. Would the cat go bad in 51k miles?
What else could I be looking at?
Golf IV / Jetta IV :: 1999 / 2.0 - Code P0422 Main Catalyst Efficiency Below Threshold
Has around 173,000 miles, with a fresh cat installed a couple hundred miles ago. I was getting this code before, that is why I had a new cat installed. The code finally came back, and just recently I had to replace the crankshaft position sensor. After the sensor change, it was running great. The CEL came back on during a rainy day, I cleared it and was good for a few days. Then it rained again, and it came back. I couldn't afford a new OEM cat, I grabbed the best rated one I could from Amazon and had a shop install it. I know non OEM can be an issue, but I hope it is just an O2 sensor going bad.
View 2 RepliesGolf IV / Jetta IV :: Error Code P0420 - Catalyst System Efficiency Below Threshold
On my 2002 (AVH) 2.0L 4cyl Jetta I have a persistent P0420 error code: "Catalyst System Efficiency Below Threshold"
I changed the oil, cleaned the Mass Airflow Sensor, replaced the coolant, thermostat, and coolant temperature sensor. But it's still showing up.
OBDII says it could still be:
A damaged or failed oxygen sensor (HO2S)
Downstream oxygen sensor (HO2S) wiring damaged or connected improperly
Damaged or leaking exhaust manifold / catalytic converter / muffler / exhaust pipe
Retarded spark timing
The oxygen sensors in front and behind the converter are reporting too similar of readings
Leaking fuel injector or high fuel pressure
Cylinder misfire Oil contamination
Elantra XD (2001-06) :: P0420 Code - Catalyst Efficiency Below Normal
P0420 code. Catalyst Efficiency Below Normal (Bank 1)
This was the explanation I got from autozone. First question is how serious is this? The car seems to drive fine and normal, but I just purchased this car about a month ago. The light turned off after the guy at autozone plugged in the scanner. I am sure it will come back on again after some driving. Is it ok to drive with it on?
Maintenance / Repairs :: Code PO430 / Catalyst Efficiency Below Threshold
I was app. 10 miles from home & engine started missing & went into limp mode & yes the light flashed . I limped it home anyway & now have a PO430 code . # 2 spark plug died & caused this , danged plug didn't have a hundred miles on it since new . Replaced that plug & everything's fine except that code . Vehicle runs great . I've also read an 02 sensor could cause this code .
View 4 RepliesHonda - Accord - Code :: P0420 - Catalyst System Below Efficiency / Bank 1
P0420 Catalyst System below efficiency -- bank 1
I've had this code for a couple months trying to trouble shoot it. My gas mileage has been affected, as I'm getting about 23/24 MPG city/highway. I replaced the upstream 02 sensor with am aftermarket Bosch variety( I'm not sure why a non-OEM one would make a difference, as long it's working correctly).
My car has 253k miles, the cat doesn't rattle and I don't smell any rotten eggs or anything, but it has to be clogged or the 02 sensor I got was defective. My engine runs fine and I don't have any problems accelerating or decelerating. It may still be the 02 sensor since the gas mileage decrease is so significant, or it could be my converter is really clogged up.
Dodge - Dakota :: Intermittent CEL / Code P0420 (Catalyst Efficiency) That Turns Itself Off
My 2005 Dodge Dokota 4.7L V8 152,000 miles has an intermitent check engine light (CEL) code P0420 ('catalylst efficiency') that turns itself off.
1) 151,000 CEL on, code P0420, checked, cleared at dealer.
2) 151,948 CEL on, code P0420, checked, cleared at dealer (Cat Conv).
3) 152,200 CEL on, code P0420, checked, cleared at local auto parts store.
4) 152,597 CEL on. No checks.
5) 152,815 CEL turned off on its own
6) 152,849 CEL on. No checks.
7) 153,137 CEL turned off on its own.
Twice in this time CEL has came on soon after a fill up from near empty.
Engine runs fine, 18-19 mpg highway.
Have seen numerous on-line reports of other possible causes:
a) base engine problems (coolant or oil) -- coolant temp sensor
b) Air in leakage -- air systems or manifold
c) Lazy front O2 sensor
d) fuel pumps
e) timing or misfire
f) what else? - (gas cap, other...)
What to check first or categories to eliminate?
Accent LC (2000-05) :: Check Engine Light / Code P0422 Catalyst Efficiency
Got this engine code error, how to proceed?
I have a '00 accent, just purchased a few days ago from a private party, when I bought it, I had a mechanic look it over, gave me the OK and said it passed inspection, no mechanical or obvious running problems with the car.
So I was driving around yesterday and the check engine light came on, took it to get the oil changed because I wasn't sure last time it was done, had the oil changed, light stayed on.
So I took it to auto zone to read the error code, was given this information. How to proceed?
Subaru - Forester :: 2006 - Catalyst Efficiency Below Threshold Bank Code P0420
I have a 2006 Subaru Forester with 95,000 miles on it. Earlier today the CEL (solid) and cruise (flashing) came on while I was driving. I believe it may have occurred as I was accelerating up hill. I filled up yesterday, so I tightened the gas cap when I stopped. On my way home, I stopped by my mechanic and they read the code; P0420 Catalyst Efficiency Below Threshold Bank was the code that was read. They reset the code for me but told me that the catalytic converter is what needs to be replaced.
My question: Could the light coming on be incidental (i.e., is it possible that it was a "blip" and my catalytic converter is okay?)? My mechanic said he thinks it is, and that my car should last me quite a bit longer. I am asking because I've put in a bit of money into the car of late and I'm wondering if I should just jump ship. I should say that the majority of the repairs are maintenance (e.g., brakes, tires).
Accent LC (2000-05) :: Code P0422 Keeps Popping Up - Main Catalyst Efficiency Below Threshold Bank 1
I have a 99 Tiburon 2.0 DOHC that I cant seem to get through emissions. The code, p0422 main catalyst efficiency below threshold bank 1 keeps popping up even after replacing the cat converter (twice) and replacing both 02 sensors. What else could be triggering this code and how to fix it?
View 2 RepliesSubaru - Outback :: Intermittent Check Engine / Code PO420 - Catalyst System Efficiency
My 2004 Outback now has 120K, has always been maintained and repaired at the dealership (except tires and battery), and has always run great! I've had the plastick-y parts replaced over the last few years including head gaskets when one cracked and made smoke. In July I got a jump from a AAA tow truck, who said my battery tested as needing replacement.
In September my check engine light went on, and the dealer found the code PO420-catalyst system efficiency. They didn't seem to look any further into causes. The cat converter replacement was to cost $2521. They reportedly tested the battery as OK as part of their routine checkup. I declined the new cat converter till learning more. Meanwhile, my check engine light seemed to cycle on, then off, then on, then off . . . every several days.
In December I had the battery checked at Sears, who replaced it under warranty. So I guess it wasn't okay after all. After that my check engine light stayed off for somewhat longer than usual, then back on for most of January. I was just about to give in and get the repair done when it cycled off briefly a few days ago.
I've lost trust in the dealership because of their battery check which differed from others before and after theirs; and for their lack of specific diagnostics. The light is back on and I don't know what to do next.
Toyota - Camry :: Check Engine Light Code - Catalyst System Efficiency Below Threshold
My 1999 Camry with 169700 miles has this 'check engine light' code: "Catalyst system efficiency below threshold". We have a mechanic we trust so we'll bring it to him this week. We spent a couple thousand fixing this car about two years ago and I'm not sure it is worth doing that again. Carmax offered us 1200 for it around this time 2012.
View 17 RepliesFord - Explorer :: Check Engine Code P0420 - Catalyst System Efficiency Below Threshold
Book says "catalyst system efficiency below threshold (Bank 1)".. Is it just based on mileage or an actual bad O2 sensor or other bad system component?
View 14 RepliesFord - Ranger :: 1999 - Check Engine Light / Catalyst Efficiency Below Threshold Fault Code
99 Ford Ranger 4-cyl. Check engine light is on; pulled fault code: "catalyst efficiency below threshold, bank 1." Cat converter is new as is rest of exhaust, o2 sensors are new, and its been recently tuned up.
View 6 RepliesGolf IV / Jetta IV :: 2001 - Intermittent P0420 Cat Below Efficiency Code Appears
2001 Jetta 2.0, manual trans
I've been having problems with intermittent P0420 cat below efficiency code. Everything else is fine, no codes, runs great. I tried spacing the post cat sensor back w/ extender bung (after replacing post cat sensor..) and still get the code. I don't hear any rattling or anything to make me think cat is bad physically. I was told by dealer that a code update might resolve for $200 - which got me thinking that that if that was so, it should should be a problem which Feds should be aware.
I searched safercar.gov and found this NHTSA ID Number: 10054864
It's a service bulletin saying that VW made the limits too sensitive and it seems there was a customer satisfaction campaign to update code - pdf on site CSC-10054864-8736
It says:
May 2007
Subject: Emissions Service Action N7
1999-2002 Jetta, Golf and GTI with VR6 Engine
Update Electronic Control Module (ECM) Software for Catalytic Converter Monitoring System Dear Volkswagen Owner: We are writing to inform you of an emissions service action on some 1999-2002 Jetta, Golf and GTI VR6 engine vehicles. Our records show that you are the owner of one of these vehicles.
What Is The Problem? The electronic control module (ECM) software for the catalytic converter monitoring system is too sensitive. This can cause the MIL to come on, and some vehicles may exceed Federal and/or California emissions standards. Also, in some cases this leads to unnecessary catalytic converter replacement. What Will Volkswagen Do? Dealers will update the ECM software.
Golf IV / Jetta IV :: Engine Misfired Twice And CEL Came On For Code P0420 / Inefficient Catalyst
I bought my Jetta almost a year ago, and I've been constantly replacing parts. Unfortunately, my engine misfired twice and the CEL has come on for P0420 which is inefficient catalyst. This is the only code being thrown. I've cleared it like 10 times, but it keeps popping up.
View 9 RepliesGolf IV / Jetta IV :: CEL Recently Came On Throwing PO420 Code
I own a 2003 VW Jetta GLS 2.0L 4 Cylinder and my CEL recently came on throwing the PO420 code (Catalyst System Efficiency Below Threshold (Bank 1)). So I replaced both the upstream and downstream O2 sensors. Well just one day after replacing the sensors the CEL came back on with the same code. I was wondering weather or not I should replace the whole catalytic converter or if there was anything else I should try. The car runs fine, exactly how it did when I bought it.
View 22 RepliesGolf IV / Jetta IV :: 2003 - Throwing P0113 Code?
I have a 03 GLI 24v VR6 thats throwing a P0113 code, which is for the intake air temperature sensor. The sensor is part of the MAF sensor, ive tried 2 brand new BOSCH MAF sensors yet the same check engine continues to reoccur. Is there anything else that oculd be triggering it to come on? Is there anyway to bypass/disable it through vagcom?
View 8 RepliesPrius (Gen 2) :: Engine Misfiring - Catalyst System Efficiency Below Threshold Bank 1
I've got a 2004 Prius with about 140,000 miles. Overall, the car has worked great, and I've kept up with regular service.
Several months ago, I started having bad misfiring of the engine. When I got it into the shop, it turned out to be two faulty ignition coils. The shop advised me to replace them all, which I did. Soon afterwards, however, the CEL came on, indicating a P0420 - "Catalyst System Efficiency Below Threshold Bank 1".