Golf V R32 :: Pulleys Self Destructed / Started Hearing Odd Sound
Last Friday I was driving with my GF in her R32, and we started hearing an odd sound. We pulled over, and I opened the hood for her, and there was plastic bits all over the right side of the engine bay. Apparently one of the pulleys self destructed.
We called AAA, had it brought to the stealership, and they didn't get it started until yesterday. They originally told her that it was the alternator dampener, and another part for the DSG needed to be replaced under recall. They told her the parts would be in today, and should have it done by tomorrow (Wednesday) or Thursday at the latest.
Now, they just called her, and both parts are not available at the VW warehouse and are having to come in from Germany. It may still be another week or so.
Golf IV / Jetta IV :: RPMs Dropped After Hearing A Screeching / Grinding Noise
I have an issue with the 02 1.8t (wife has an issue). We recently took our car in to get some service work done and the mechanic informed me that he thinks the tranny is starting to go and just baby it....Fast forward a month the wife is driving the car, she said at around 40mph 2k RPM and the RPMs just drop after hearing a screeching/grinding noise....
Then she tried to apply throttle and it redlined...She said it would shoot up in RPM and not go over 30mph, she used the triptonic to get home and was able to get up to 45..Sat for a bit and I drove it, everything seemed ok..Shifts good, stops fine, no weird noises, etc....
Car is a 2002 Jetta 1.8t w/ 148k miles, regularly maintained, never had tranny oil flushed..
Golf IV R32 :: Hearing Sound Like Rear Tires Dragging Over Gravel And Sticking
My car is not my daily and I only hear the sound after it's been sitting for a day or so, at low speeds right when I pull out of my driveway, I hear what sounds like the rear tires dragging over gravel and "sticking," the sound is more pronounced the sharper I turn. As I go a mile or so down the road and make turns, the sound goes away. I don't notice any vibrations or clinking sounds.
View 2 RepliesGolf IV / Jetta IV :: Growling Noise At 1900 RPMs When Car Is Under Load
I recently purchased a 2003 jetta 1.8t 5 speed manual and it wasn't making this noise when I first bought it.. It's almost like a growling/grinding noise. It's sounds like it's coming from my middle console but it could be coming from the engine bay hard to tell, but the only time this noise happens is at 1900 rpms when the car is under load like if I'm going a hill it's pretty loud when I'm going slow, the previous owner had the water pump, timing belt, and clutch done 10k miles ago. I have a feeling it's from the clutch/transmission or maybe from the timing belt?
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: 2000 - Cab Making Growling Sound At Idle?
Recently my 2000 F350 7.3 crew cab has been making a growling/vibration sound by the glove box at idle. Seems to disappear at speed/higher RPM.
Any thoughts on what might be loose at firewall passenger side area?
Golf IV / Jetta IV :: Brake Malfunction - Mushy And Non Stopping
I go my R32 calipers powder coated, I rebuilt the err m and got 20th rears while I was at it.
I did make a noob mistake and pressed the brake pedal to try to manually bleed my rear brakes (used a vacuum pump prior) then I remembered my front calipers were off.I might have pressed it 3-4 times.I re-bled all 4 corners, once all 4 calipers were on, and did so until I was sure there was no air.I read in a few places that our rear calipers bleed because the bleeder screw isnt at the high point, which makes sense. So Im wondering if this is what I'm experiencing or is there something, via VAGCOM, I have over looked?
Golf IV / Jetta IV :: Axle Makes Humming Noise When Stopping
So I just but my golf about a month ago and have hit many problems but the most annoying is the hum I get at 3500 rpms. In my searching I feel somewhat confident this is caused by a cheap right axle replacement. I also went under and found on the left axle markings that indicate its is oem VW and I was unable to find these on the right side. anyway I have found this: [URL]....
It says it is a hollow axle right there and it is 170 less than the cheapest oem one I have found. would this workout?
Golf IV / Jetta IV :: 2004 - Brake Noise When Stopping At Low Speeds
When stopping my 2004 VW GTI 1.8T at a low speed the brakes (sounds like from the front) make a strange noise from the front. The best way to describe the noise would like when you would put cardboard or the like in your bicycle tires as a child and make that whirring noise. I have checked the brake pads, rotors and the like and cannot find any evidence of grinding or anything of the sort. It only happens at low stopping speeds and not at harsher stops. There seems to be no evidence of problems stopping or anything like that, just an aggravating noise that will not go away! What it could be because I am completely lost on this topic and have checked all the basics (pads, calipers and rotors) for wear/tear and just did my brakes about 5 months ago with no noted issues at that point with everything broken down.
View 3 RepliesGolf IV / Jetta IV :: 2005 - Makes Noises While Stopping / Battery Dies?
I have an 05 GLI and it makes noises when it's off. I don't know what it is. It's a 4 second hum then kicks off.I don't know if it's a pump of some sort or what. Today when I opened my car door for the first time of the day it did it. My **new** battery dies a lot. I've always thought that I've just left stuff on because I am a ding dong.
View 5 RepliesGolf IV / Jetta IV :: 2003 - Pulsing Air Sound On Start Up
What this sound is / caused by? This is my Dad's Golf, the sound subsides after the engine warms up a little. It runs fine, power and all. I took off the top timing cover, nope that wasn't it, no rubbing as the sound persisted. Thinking maybe an injector o-ring? The car has 130,000 miles and change on it.
[URL] ....
Golf IV / Jetta IV :: 2003 1.8T Engine Knocking / Slapping Sound
I've got a 2003 Jetta with the 20v 1.8t, today I was driving along and when I slowed down coming into town, my car started making this sound that I can only describe as sounding like a tractor. It sounds like something is rattling under the valve cover.
Here's a video with the sound : [URL] ....
Golf IV / Jetta IV :: 2003 Car Shaking And Had A Ticking Sound At Startup
So I was on my to get some food and when started my car it was shaking really bad and had a ticking sound. I popped the hood and the engine was shaking violently, it drove fine one day to walmart and the next day started doing this. I am thinking it could be the coil pack because it was raining when I went to start it.
View 2 RepliesGolf IV / Jetta IV :: 2003 - Buzzing Sound When Tapping Brakes
2003 Jetta GLS 1.8T
Every time I press the brake pedal a buzzing sound can be heard. Every single time. Without fail. Moving or parked.
I just had the tranny rebuilt and it's possible something was broken or unplugged. I've done a search on google and can't find anything specific. I'm thinking something to do with ABS. Problem started a week ago when it came back from the rebuild.
I'll try to get a video and post. Was funny at first. Now it's annoying.
Golf IV / Jetta IV :: 2003 - Jerk Or Clunk Sound When Driving Down The Highway At About 65
Here is my new to me 03 Jetta 1.8T Wagon. This all started yesterday driving down the highway at about 65, I drove over a bump and there was what felt like a jerk. I lost the radio right away and when stepping on the accelerator it didn't seem to go over 3500rpm. I got a few miles into town taking it easy and it died as I pulled up to a stop sign. I was able to get a jump and get it running again.
This was the first jump of the day...When we popped the hood to jump it I noticed that the red wire coming off the positive battery terminal to the power block was frayed and corroded, so I cut the bad end off and stripped the wire to get a good connection. Left the car on a battery tender just to make sure the battery was charged and came back after a few hours and it started right up. Problem solved right?! Wrong...
Probably 10 miles down the road the same thing happens, a jerk or clunk sound, lost power and the call stalled out. Called family that was close by and tried to jump it again 'cause that worked the first time... Got a few miles down the road and it happened again!
Here's a picture of the gauge cluster and all the lights that lit up.
Long story short the car had basically no lights, power, for the windows/radio/turn signals/headlights etc... but was putting along at about 5 mph. I was out in the country and about 5 miles from home so I was just focused on getting it in my garage. It died again and a jump wouldn't even get it going the next time. I did some reading on my phone and it seems like the power block can be problematic, I took a picture of that because there is some obvious melted plastic on the large black wire.
I have a friend with a vag com, and he was able to come out and read the faults and then clear them and the car started right up just fine off a jump pack. We did get it home, but today I'm getting the same issues. I am trying to trace that black wire to its origin to see if there is corrosion or a loose connection there but I have no clue where else to start....
I start a new job on the 21st of July and this was meant to be my commuter as my truck gets terrible mileage...
Golf IV / Jetta IV :: 2003 - Slight Growl Bearing Sound At Idle?
Not sure where to even start this but ill try to keep in concise. 03 gli 24v 6 speed. 125500 miles. At about 123500, i start noticing this slightly growly bearing sound at idle, without the clutch pedal pressed. When you press the clutch pedal, it goes away. Waited a bit, and at 125k, i replaced the clutch, flywheel, and throwout bearing, thinking it was a bad throwout bearing. It wasnt that.
Next, after more research, it seemed the 02m 6 speeds have had some issue with input shaft bearings wearing out making similar noises. So, pull the trans back out, and send it to APTuning in PA. Have new input shaft bearings, upper and lower pinion shaft bearings, and diff bearings put in. Even though they said they saw no major wear to be worried about in any of them. And here we are, left with the same noise.
One of the guys at APTuning said they had a case with one car where the thrust bearings wore so bad it made for a similar condition. Where the car would make unpleasant noise without the pedal pressed, and would go away when a load was put on it with the pedal. SO, i guess what im asking is, is there validity to that? What are the chances my otherwise seemingly fine 24v has this issue and end play is so bad that is causing this noise?
The noise gets NOTICEABLY louder when the car is hot. Its almost silent on cold starts. But after 15 miles or so it can be heard almost voice level with the windows down when you're stopped and idling; it really hurts to drive it being a caring owner hearing it. The motor is still in the car with all accessories so i can't check the end play scientifically. But to be fair, if this is plausible, and is the issue, i dont think it'd take precision to tell.
I'm so deep into this, and thought I've ruled out everything yet the noise persists. Really at a loss..
Listen around :30 where I start to cycle the clutch pedal. When I press it, you hear the main shaft "spin down" and the noise go away. When I release the pedal again, you here the clunk and the noise again. Its also been sitting for 3 hours. Good bit louder when hot [URL] .....
Golf V R32 :: Wipers Stop While Stopping At Light?
So i've had the car for what, maybe 16 months now and tonight while the wipers were on s l o w speed, I came to a full stop at a light and the wipers stopped wiping, and then either went into intermittent or rain sensing mode. When I started moving again the wipers starting wiping continuously again. Never knew we had this functionality.
I have to admit I've been a fan of the rain sensing feature and just about never use the low or high speed settings except maybe when it's constantly raining on the freeway. So I guess tonight must have been the first time I've used the low setting while in town and had to make a full stop.
Passat (B5) :: Won't Start - Hearing Hard Drive Clicking Spinning Sound From Middle Of Dash
I'm a fairly new owner of a 2002 W8 Passat. A few days ago I was leaving the grocery store to come home. The car usually starts right up. This time is took 2 or 3 tries of cranking the starter til it fired on. On the drive home I noticed the A/C no longer worked and it didn't display the temperature on the A/C screen like usual. I got home just fine. The next morning I tried to start it. The starter and battery sound very strong. I was a little low on fuel so I dumped two gallons in - didn't work. I noticed a sound like a hard drive spinning or searching coming from the middle of the dash. I thought is was the cd player, but I ruled that out by taking out the stereo fuse. Is there a computer that went bad? I can't imagine there being an actual spinning hard drive in the car, but that's what it sounds like to me. I also noticed the clock and trip meter were reset as well. I didn't disconnect the battery to cause this. All fuses look good. I'm hoping it's not the fuel pump. Bad relay?
View 7 RepliesGolf V R32 :: Strange Idle When Stopping Or Sitting At A Red Light
I started noticing a strange idle when stopping or sitting at a red light. Upon stopping the car idles at around 600, then all of a sudden it jumps to around 1000-1100, and sits there as if I was giving it gas. As I drive off the car drives fine, once I stop again, the same thing repeats. This happen to me 2-3 times already within the past month, I mostly drive on the highway, so that might be a reason I don't notice it often.
View 5 RepliesGolf IV / Jetta IV :: 2003 - ASR / Engine Light Came On
I have a 2003 Jetta GLS 1.8 5Speed. With issues.
The problem that I first had (and have always had since): While driving under 30mph but at random times, my ASR / ESP light and engine light will come on and my car will lurch and lose power (I can't go above 20mp at that point this is the limp mode that traction control puts you in I think). I have to pull over and restart my car. And then the ASR / ESP light is gone and the engine light stays on for a day or so. After restarting my car everything seems to function fine.
My car would also chug a bit if I didn't let it warm up in the morning it acted as though it would die. After sitting for a minute it would be fine.
My mechanic initially thought there might be an air flow issue. He found a hose that was cracked at the end but said I didn't really need to replace it. He taped it up and used a clamp to keep in place. I have no (ok little) doubt that it is air tight.
When the problem continued he thought it might be my MAF sensor. He had a used one and replaced mine with it. It seemed to work, I didn't have the problem again for some time. But it eventually came back.
Also, I started to find that when I came to a stop light my car would idle roughly. If I put the car in park it was perfectly fine. Later, I had an even more serious problem. My car needed to warm up for about 10 minutes before it would shift out first. After plenty of internet searches on sites like this, everything pointed to the N92 solenoid. I purchased all 9 solenoids online and had someone replace them. That seems to have fixed my shifting out of first problem.
I still had the ASR / ESP issue though. So I bought a new MAF and replaced that myself (very easy). I was positive that would be then end of my problems. But nope no change.
Recently I also find that if I slow down quickly, sometimes my car just strait up dies. After restarting all is well.
So if this isn't a MAF issue, what are the other likely culprits? Vacuum leak somewhere? How much would you expect to pay to have that diagnosed (I think they have machines that can test everything and locate points of failure)? Air-flow meter? Transmission control unit? I have heard that they are relatively cheap to replace Engine control unit?