Ford 7.3L Power Stroke (1999-2003) :: 2001 Started Blowing Blue Smoke
01 7.3 247k.
Yesterday went to get on the freeway I looked back and saw a cloud of what looked like blue smoke. I'm in northern Utah and it's cold but the truck runs fine, I haven't noticed any change in performance. Turbo still builds boost. I pulled the fuel filter cap last night to check fuel color and it was clean.
I do have the CCV mod done. I also pulled to IC Pipe off the turbo and there was a little oil in there but not much, should there be any at all with the CCV mod? Where to start.
Ford Escape / Hybrid :: 2003 - After Sitting Overnight Blowing Blue Smoke Then Dies?
I have a 2003 ford escape V6 and i have notice when i start it' after setting overnight i notice some blue smoke for a little while then it's stop What could be causing this.
View 1 RepliesGolf IV / Jetta IV :: Random Blue Smoke Out Of Exhaust / Smells Like Burning Oil
Only had happened a few times in the last month. I start the car and it idles okay. drive down the road and then come to s stop and there's some blue smoke. It smells like burning oil. it only has happens 2 times in the last 2 months. only when its really cold it has happend. If I rev it when its happening I can see a big plume of bluish smoke and it smells like burning oil. after i drive after that no more smoke.
car has 95k on it
never been chipped
car has full turbo back and intake
car does not burn any oil between oil changes. oil stays at the same level.
did break an oil pan about 4 months ago. when I replaced it no signs on sludge.
turbo boosts fine
Car has had a rough idle for a long time. only when its a cold start and only last about 20 seconds. When I boost it or redline the car which is very rare no smoke at all. I have always kept the oil more on the high side of full. I usually fill it right to the high mark on the dip stick.
Golf IV / Jetta IV :: 2000 - Excessive Blue Smoke And Screeching On Start Up - Runs Rough
I got 2000 tdi with 270000km on it and have a few issues with it and am looking for some information before i start doing some work to it.
First problem excessive blue smoke on start up also runs ruff tell it warms up.
Second the is a screeching noise on start up some times. happens most of the time when the car is cold.
Third sounds like something is dragging or rattling but i have checked and there is i can see.
Fourth when the clutch is in and the brake is on the car runs ruff at idle. i think it has something to do with vacuum used for the brake booster but not sure.
Golf IV / Jetta IV :: 2002 - Turbo Fans Keep Blowing Out?
I bought a 2002 gti mk4 with about 127000 miles on it .I did not know the turbo fans were blown out , they were sitting in my down pipe next to my catalytic converter . So I replaced the turbo myself , and 2 hours later the fans fell out of the new turbo , what might be the problem ? why it keeps blowing.
View 7 RepliesPassat (B5) :: Blue Smoke Blowing When Romp On W8
I may have an issue with my engine. My car is beginning to blow some blue smoke when I romp on it. It doesn't break up at all, there isn't any loss of power. It's just blowing some smoke and I noticed a light oil build up on my exhaust tips. I don't think I need to be hugely concerned yet, but I am bringing it to the dealership tomorrow just to make sure.
View 9 RepliesFord Excursion :: Blue Smoke Blowing While Idle
I am only at 141,000 miles and I'm seeing blue smoke while I idle! It started as a small puff of blue smoke when cold starting up...now it is much more consistent. I am also getting a diag trouble code of P0674 (glow plug in cylinder 4) can that be the cause? I'm nervous since I didn't watch my tech put oil in the truck at the last oil change...I think he put four gallons in instead of 15 quarts...is that a prob?
View 1 RepliesSanta FE SM (2001-06) :: Engine Blowing Little Blue Smoke On Startup
My santa fe 125k on it engine start to blow little blue smoke when start up ...
View 1 RepliesChevrolet - Suburban :: 2007 - Foamy Stuff In Oil Lid / Huge Amount Of Blue Smoke Blowing Out
I am writing about a 2007 Chevrolet Suburban and for the last few months, have noticed that the car is losing oil. I have to put in a quart of oil about every 3 weeks. I have brought it in to the mechanics and asked them to look for a leak and they can't find anything. They have changed the oil, replaced the evap hose, but the car is still losing oil. Just did a lot of driving this last weekend and the oil went all the way down, to the point of when I started it this morning, I got a huge amount of blue smoke out the back. When I took off the cap to add oil, I noticed this mustard yellow, foamy stuff on the lid. Never saw that before.
View 6 RepliesFord A/C :: Clutch Smoked - Huge Stinky Cloud Of Blue Smoke Blowing Out From Behind The Truck
First some background. The vehicle is a 2003 Expedition with rear AC. The 5.4L engine has been replaced with a 4BT Cummins (DD since 2010), but the AC system is not altered-- other than the compressor being mounted to a different engine. The intercooler is in front of the condenser, which hurts efficiency of the AC system, but it seems to work fine in our climate.
My AC system quit cooling one day, and the problem was a hole in one of the low-side tubes from rubbing on the turbo-to-intercooler tube. I repaired this by aluminum brazing. The system held 120 psi on nitrogen for one hour. So I pumped it down overnight to 27 inches of Hg and made an appointment with the AC shop to get it recharged. I could not get an appointment for several weeks, so I continued to drive it with no AC, thinking it should be no problem since there is no pressure in the system.
I was on a road trip when all of a sudden, there was a huge stinky cloud of blue smoke billowing out from behind the truck. I pulled over and the AC clutch and pulley was smoking hot. I shut it down and cooled it off slowly with squirts from a water bottle.
So my clutch is shot but I'm not sure what caused it to fry. Is there a typical mechanical failure where the friction material can be chewed up by the pulley-hub? Or is it possible that somehow the controller commanded the clutch to engage without pressure in the system?
I think it would be prudent to replace the compressor, since there may be some bearing or housing damage from the clutch failure, so that is in the plan. I have read that when ever the system is open, the drier should be changed too. I want to do this right rather than do it again on another day.
One concern I have is that if when the clutch was failing and it managed to turn the compressor-- could there be pieces of compressor in the tube runs that I need to clean out? Other than a visual inspection of the open tube ends, is there another test or things to look for?
Golf IV / Jetta IV :: Car Blowing Big Puff Of Smoke On Acceleration From A Stop
Well its a 1.8t pretty much stock except the previous owner added a turbo-back exhaust and has an apr tune running the 91/93 octane tune and they also deleted the stock airbox.
After the car warms up sometimes I'll get a pretty big puff of smoke on acceleration from a stop. sort of bluish in color and it happens randomly, not every time. I usually have to add oil about every week. I have taken it to a mechanic but told me it wasnt the turbo ( cause thats what i thought at first) and that it might be valve seals instead. I scanned for codes since CEL went on and i got a p0136 o2 sensor code and p0411.
Ford 6.0L Power Stroke Diesel :: Cold Start Blue Smoke Blowing Until Warms Up And Accelerate
I have a 07 6.0 powerstroke, I had 2 bad injectors so I replaced all of them with reman's. I had a problem with them coming loose. the first time this happened it hydrolocked the motor, number 8 cylinder. so I pulled all the injectors and replaced all the seals and washers and torqued them down a little more than spec like 27 lbs. it runs great and starts great even at 25 degrees but I noticed this morning that when starting it up after it sits (cold) it blows blueish smoke until late it warms up and I accelerate. is this normal? should I check fuel filters? oil in fuel?
View 14 RepliesGolf IV / Jetta IV :: Check Engine Light / Blowing Black Smoke / Shut Off In Neutral
I bought a 2003 Vw Gti 1.8t ... What to do or look for when something goes wrong . About a two months after driving it, it won't idle and it shuts off while in Neutral . I've done my research and i believe he didn't install the BOV in right, only bc it is not recirculates the air. Make sense? Is there ANYTHING i can do so it will run better and idle?
View 5 RepliesGolf IV / Jetta IV :: 2003 - Expansion Joint On Downpipe From Turbo Exploded
2003 Golf GTI Turbo... New to VW, I'm a jeep guy and bought a GTI for my wife to try rally cross in. It had some problems that I knew about when I bought it, had to replace CV shafts, control arms, fix broken trans mount, etc. I'm on to the last piece of the puzzle now.
The expansion joint on the downpipe from the turbo is basically exploded. Not a big deal, just buy a new downpipe and biky everything together right? Not so much. Bought one the other day, it showed up and has 3 bolts on turbo side, mine has 4.
When I look at the other stock turbo downpipes, it looks like they have 3 bolts as well. What's going on? Did the previous owner put a different turbo on this? I just need the damn downpipe, but can't figure out which one to order.
Golf/GTI VII :: Oil Burning - Blue Smoke On Startup
My car burns oil on startup. Mostly when cold. However the attached vid was taken today when the car was warm. Does not burn oil any other time. It is definitely not water vapor - smoke is blue.
Dealership replaced pcv after inspecting the turbo and all was good. Now they aren't sure what it could be.
My research tells me valve guides/seals leaking oil into the head. I don't show any oil loss on the stick so it's not leaking a lot of oil, just enough to create a little big of smoke.
Question - is this a big deal? Do you occasionally see smoke on startup? I'm trying to figure out if I should press the issue with vw or just live with it - I really don't care about the smoke but don't want long term reliability or resale issues.
Golf VI R :: 2012 - Puffing Blue Smoke Between Shifts?
I have a 2012 r with 30k miles that's has been on apr stage 2+ for 16k miles and it has recently started puffing blue smoke in between shifts.
View 13 RepliesCamry :: 2003 Solara 4cyl - Blue Smoke On Start Up
I have a 2003 Solara 4cyl, some months ago it started to blow light blue smoke on start, but would go away after a few minutes. My mech, could be the valve guides. Then about a month ago it blew a head gasket, didn't overheat though, as I stopped, added water and went to the mech. So new gasket and a valve job, but it still blows smoke on start. THe mech said going to 20w50 might work, it didn't. I check the oil last week, thought it should a couple of qts low, so I added oil, but the blue smoke is still there, and I started to smell oil burning. I thought maybe I added too much, so I add another oil change w/20w50....still have the oil burning, blue smoke on start... The mech thinks might be leaking in the rings...ugh....probably could/ve bought a new engine by now...... The check engine light had been intermittent, the mech said it the catalytic converter....it finally went off by itself four days ago....maybe it burned out..........
View 5 RepliesFord F-150 - 1997-2003 :: Blue Smoke From Tail Pipe
After tooling around town and a complete warm up cycle for the engine I encountered a problem. The situation is this.... Had to go around a slow poke....waited until traffic had cleared and nailed it. My truck belched out a boat-load of blue smoke from the tail pipe. Could not duplicate this on the return trip to the stealer (Dealer). Needles to say, I am worried about the health of the engine....(no codes popped, or anything else as I had a code reader hooked up) My truck did the blue cloud again with a rev up in park after a cool down but wouldn't do it again, but there was a strong smell of unburned fuel at the tail pipe.
4.6L, 2WD, Sport Package....
Ford F-150 - 1997-2003 :: Blue Smoke / Burning Oil / No Low End Power
Alright so In January had head gaskets done on my truck and when I got it back it Dont have any low end power and I noticed it was using oil. If I let it idle 15 min or so and rev it up it blows out a bunch of blue smoke and smells like oil bad. Been trying to figure out whats going on. Ive only put about 800 miles on it since I got it back for the head gaskets And its burned at least 3 quarts of oil. Its going to the shop on Monday gonna start with compression check and go from there I'm Thinking Its valve seals or a bent valve. But machine shop surface and pressured checked the heads. Truck only has 146000 miles on it shouldn't be having these lined of problem. Its an 03 5.4.....
View 7 Replies