LS / MKZ :: 2003 V8 High Temperature In 8 To 10 Minutes Of Continue Engine Operation
Basically the car LS 2003 V8 had an issue with the thermostat....this was necessary be changed after 50 miles of drive the car....in the last 4 miles the temperature increased in a short period time to the high limit...with the protective system the car was turn off.....one time with the mechanical service the follow items was changed: thermostat, radiator, coolant temperature sensor, water pump, plastic joint parts (housings), head seals, coolant and the 2 caps (radiator & coolant tank), this last was damaged by the pressure during the over heating.
After all parts changed I still continue having in the car the high temperature in 8-10 minutes of continue engine operation, after this period time the car turn off automatically by the safety system.
I need information about the coolant flow in the system, the pump pulley rotation, the belt installation, the manner and values to test the old temperature sensor, auxiliary pump and the current CTS (cylinder temperature sensor).
The fan motor is working good, none coolant leak is present, and I already test without thermostat (none change in the result).
Golf IV / Jetta IV :: 2005 - Engine Temperature / Fuel Gauge Not Working
I have a 2005 mk4 gli and the other morning I went out to start my car for work and all I got was crank no start. I then realized my fuel pump wasn't priming when I opened the driver door. After work I came back and checked the fuel pump fuse and swapped the relay with another I had, still nothing. A buddy of mine decided to check the connector at the fuel pump for power, using a power probe I believe he hit all or the majority of the wires with 12v of negative and/or positive power. He then unplugged the connecter and plugged it back in and the car fired right up. But I noticed that my fuel gauge, engine temp gauge, and outside air temp readout were all not functioning. I've searched and searched without being able to narrow down a solution.
View 19 RepliesGolf IV / Jetta IV :: Engine Temperature Rises When Heat Is Turned Off / Hard Pull
I have a 1.8T with 152kmiles
Recently, both the coolant reservoir 'Y' connector and the driver side coolant flange cracked and I was shooting G12 all over the engine. I've replaced both of the parts and the coolant temp sensor with a "green top". Reservoir was refilled with the proper ratio of G12 to distilled water, ran for a bit and topped off accordingly.
This morning I started my drive to work and the engine temp was at 0 for a minute or so and started to climb slowly to 190. It stayed at 190 until I took the exit to the highway and the temp slowly started to rise while I was at 60mph. I immediately turned around and went back home with the heat cranked to high. With the heat on, the engine temp would slowly go down but then rise again if I, A. turned the heat off or B. made a hard pull up to ~55+mph.
I popped the hood and the coolant was not boiling and I couldn't see/smell/hear any leak. could this be the thermostat or is this a water pump issue? I plan on taking the thermostat off and checking the pump empellars for any shards. I'm not sure but I do believe the water pump was replaced by my parents while I was on deployment.
Golf IV / Jetta IV :: Overheating / Temp Gauge Starting Raising Pretty Quickly When Driving
I have a 2002 Volkswagen Golf 2.0, I was driving and the temperature gauge starting raising pretty quickly. I stopped, checked the coolant and oil, both were at normal levels. The car cooled down pretty quickly, and I drove a little and it raised again. The heat is coming out cold despite the hot temperature. Overheating, normal coolant levels, no heat.
View 8 RepliesGolf IV / Jetta IV :: 2005 GTI 1.8T Engine Revs Too High?
I have a 2005 GTI 1.8T with 203K miles, stock except for a MagnaFlow exhaust. My problem arose about a month ago. When I accelerate aggressively and shift from 4th gear to fifth at about 4K RPMs the engine will jump up to 5K RPMs. Happens while shifting from any gear when accelerating hard.
When I push down on the clutch and take my foot off the gas, I get a jump in RPMs. It's kind of like the boost in the turbo is not getting released. I replaced the stock diverter valve with a Forge DV with the splitter. Had no effect on my problem, but now I have that cool sound when I get off the gas.
Could this be the waste gate on the turbo not opening and releasing the boost when I get off the gas? I'm not very familiar with the intricacies of the Turbo functions and the diverter valve.
Golf IV / Jetta IV :: 2003 1.8t - High Pitched Squeak And Shifting Really Hard When Hit 2.5 Rpm
I've been having some issues with the way my car is running today. Drove to the store, and he was fine. On the way home, he hit 4rpm and then dropped extremely fast. Then I stopped at a red light.. I went to go, hit maybe 2.5 rpm and it made this high pitched squeak and shifted really hard. I made it home fine after that, and no lights are coming on. I just changed my spark plugs not even a month ago.
View 1 RepliesGolf IV / Jetta IV :: VW 1.6 SR (AKL Engine) Rough Running / High Fuel Consumption
Regarding my problem (outline below):
>> Went for a refueling stop, and thereafter proceeded onto the highway
>> Approx. 500m into the drive onto the highway the car started jerking and running rough with an initial puff of smoke (none thereafter)
>> Immediately after this initial jerking/shuddering there was a significant increase in fuel consumption i.e. from a familiar 8.2L/100km to 18L/100km in the cruise
>> We continued driving not knowing what it was (I suspected a spark plug may have stopped working)
>> Pulled up at the gas station to observe what went wrong inside the engine bay - no signs of any leaks, fuel sprays, etc. but only that the engine was shaking
>> I checked the rear of the car while the car was idling and observed a pulsating sound...some light smoke and a fuel-rich egg-like smell
>> Asked around and I was led to think the catalytic converter was ruined, so the next day I had the catalytic converter cut out
>> After removing the catalytic converter the problem persisted...although the engine operated with slightly less flow resistance
Attempt at diagnosing the problem
>> My wife called in a technician from BMW at Canal Walk to come have a look and what errors were flagged
>> The tech ran the diagnostic and no fault codes were indicated, except a few short circuit faults due to my incorrectly placing -ve on +ve when I tried to charge my cars battery with jumper cables
>> He proceeded to ask if we changed the spark plugs, I said yes. He then looked at the oil on the intake manifold and said there could be a torn valve on the intake manifold and that air that is not measured by the air mass flow sensor is entering the engine, which is causing the car to rev hunt (this problem of rev hunting has been with us for a while). The engine also shuts down uncommanded at stops and sometimes between shifting gears with the subsequent loss of power steering (very dangerous!!)
>> We also had the O2 sensor replaced a month before this occurence
The images attached (#1- #3) are marked up to indicate the component I am referring to.
[IMG] FilesImage_1.jpg[/IMG]
[IMG] FilesImage_2.jpg[/IMG]
[IMG] FilesImage_3.jpg[/IMG]
Went to Cape City VW in Cape Town and the part number for that orange thing/diaphragm is 06A 198 205A 'Repair kit for valve'. Is this significant? The car sounds as strange at idle...as if has noisy valves. I can upload (if there is an option) a sound clip of how the car sounds if this assists.
Golf IV / Jetta IV :: 03 - Engine Makes A High Pitch Noise And Not Turn Over
I have an 03 2.0 jetta manual shifter. Never had issues before this morning. Got in car and sounded like it wanted to turn but wouldnt turn over. After a few attempts the turning sound stopped and I heard an electric pop. Now engine won't even try turning when I turn key it just clicks and engine makes a high pitch noise. Took starter and battery out got both tested and they are fine...
View 3 RepliesGolf IV / Jetta IV :: 2003 GLS Steering Wheel Shakes At Moderate / High Speeds
Car: 2003 Jetta GLS 1.8T
The car is starting to produce a heavy shake in the steering wheel when above 45mph up through highway speeds. The kicker is that the shake only occurs on-center, because turning the wheel just a few degrees off creates a relatively smooth result.
Checked the wheels for balance, tire wear [which is good, no cupping], lower control arm (LCA) bushings, and complete a lock-to-lock steering test on the ground to confirm steering rack mounting bolts are tight. What's the next pieces of hardware I'm needing to verify?
Golf IV / Jetta IV :: Engine Loud On Morning Start / High Idle And Noisy
I'm not sure if this qualifies for a "cold start" but my 1.8T sounds imperfect when I start it for the first time of the day. It'll rev around 1200 RPM, instead of the normal 800RPM idle if I start it after it had recently been turned off for a short period.
It sounds almost like my old car that had an exhaust leak, but not as obnoxious. When it settles back down to 800RPM it really purrs and sounds great. Is this normal?
2003 Wolfsburg Jetta 1.8T, not sure if I wrote that in my profile yet. 41k miles and recently serviced for 40k milage. Has sounded this way before and after the service.
Golf IV R32 :: Fading Instrument Cluster At High Temperature
My instrument cluster is virtually nonreadable now when the outside temperature gets about 80 degrees. I assume the only way to correct this is to replace the whole cluster.
View 24 RepliesSC/SL/SW :: 98 SL2 1.9 DOHC Idles Really High At Startup Until Engine Gets To Normal Operating Temperature
Idles really high at startup until the engine gets to normal operating temperature and falls back to normal. Takes 10-15 minutes. I recently de-greased the engine and think I may have fouled a sensor...though the check engine light is NOT on. I'm afraid if I keep this the way it is it will cause damage to the engine.
View 2 RepliesElantra XD (2001-06) :: Engine Oil Temperature Sensor High Code P0198
2003 Hyundai Elantra, 1975cc engine, XD. P0198 Error Code.
I know this is the Engine Oil Temperature Sensor High code and I have seen indications this may mean high voltage on this sensor. My problem is I cannot locate this sensor on the engine. From what I have read this sensor is supposed to be on the driver's side of the engine on the head, rear side.
On my engine the head was replaced (unknown to me when I recently purchased the vehicle). From all indications this is not a CVVT engine. The air intake has a MAP sensor that is connected and appears to be functioning properly. The driver's side of the engine does have two coils but I can see no other wires from the wiring harness toward the rear of the head other than leads to the starter.
The cam sensor is located on the passenger side of the engine, rear side. I have found the oil pressure sensor and crankshaft sensor on the front side of the engine block toward the driver's side. I have found and engine temperature sensor on the driver,s side of the engine on a housing connected to a radiator hose.
Oddly enough there was an OCV hanging on the harness toward the front driver's side of the wiring harness. Adjacent to this plug is a second plug on a shorter lead that is not connected to anything. Both of these plugs have two leads but are shaped differently oval for the OCV and the other is rectangular. I am wondering if this rectangular plug is for the engine oil temperature sensor? What I cannot see is where the temperature sensor would screw into the head on the front driver's side (near this plug).
I went to NAPA today and they do not have an engine oil temperature sensor listed, but I was able to find one on line. I cannot find a connection point on the head that looks like the picture of the sensor on-line.
Golf IV / Jetta IV :: Temperature Fluctuates Between 120 To 130 Back And Forth
So i decided to be a man and finish my 3.6vr in my gti project. Filled the coolant system with g13 and let the car run for a good half hour but the temperature only went to 130 degrees and would go back down to 120 and back to 130 and back and forth. With the heat turned on it was only slightly warm. Top hose was slightly hot and the bottom hose was just warm. So i tried massaging the hoses some more to let any air out and saw no bubbles. So i decided to go for a drive around the block and temps still stayed the same. So i'm leaning towards a thermostat but the motor was pulled out of a running passat with no problems.
Also its a brand new oem temp sensor
GTI 337/20th Anniversary :: Getting Two Codes - Engine Temperature Too Low - Turbo Boost Pressure Too High?
Engine temperature too low. Turbo boost pressure too high. The car has the APR 93 octane program, carbonio intake, and silicone TIP.
What could be causing these codes? The car gets up to temp (190) real quick and stays there, and I don't feel a fluctuation of boost.
Golf IV / Jetta IV :: Air Intake Temperature Sensor Missing?
Looking at my circle track car when they told me my air intake temperature sensor was missing this is a picture online I found: [URL] ....
The hole is filled with a bolt and some epoxy. I don't see where the cable is for it. What will this do to my car? It is a track only car.
Golf IV / Jetta IV :: Losing Boost / Power At High RPMs In High Gear
2003 jetta gls 1.8t 5spd - gts stage 1 tune(gonzo stage 2)
tt 2-1/2" downpipe with high flow cat
turbo smart splitter valve(set to divert only)
turbo inlet pipe
homemade intake with k&n filter
stock n75 valve (f)
So in first through 3rd gear my car gets 20psi of boost then at 3,500 ish rpm smoothly starts to lower down to 15psi. but in forth and 5th gear the boost drops faster, enough so the diverter valve actually opens. then the boost will bounce up and down, around 15psi. the car still accelerates but with obvious power loss.
Is my diverter valve not "firm" enough? it is adjustable, so I've tightened it as much as it can. it doesn't seem to change anything. it came with spring spacers to make it tighter, but I haven't tried that yet.
Is it something with the tune? not enough fuel, need bigger injectors? The problem is only at about 100mph, so its not a big deal. I would like to get it straightened out if possible.
Ford - Zx2 :: Idles High (about 1000 RPM) And Rumbles Pretty Roughly
I own a 2000 Ford Escort ZX2 with an automatic transmission. I also own a 1991 Fleetwood Cadillac with an automatic transmission. Each car has its own situation.
The ZX2 idles high (about 1000 RPM) and rumbles pretty roughly while idling. I was curious as to what the cause might be.
The Cadillac has a blown head gasket and I was wondering how expensive and what would go into fixing this myself or just how much it would run going through a dealer.
Santa FE SM (2001-06) :: Code P0118 - Engine Coolant Temperature Circuit High Input
I went to my local Autozone today to have a code read and get the freeze frame data. I got a code P0118, Engine Coolant Temperature Circuit High Input. I called the dealer but they are out of stock on the sensor. Would it be a problem to use an after market sensor? I'm just concerned about the quality and accuracy of the sensor.
View 5 Replies