Golf IV R32 :: When Put Into 1st Gear It Shifts Into 3rd
Got my shifter in yesterday installed it today, had a few throwbacks but Jim was able to iron them out, except for one. I can go through all my gears, even reverse, but when I put it into "1st" it puts me in 3rd and it's sluggish taking off. I'm going to take it all apart tomorrow and try it again.
View 1 RepliesGolf IV / Jetta IV :: CEL Came On Along With Hard Shifts
My brother has a 2005 MKIV Jetta 1.8T with the auto transmission. He called me this morning saying that his check engine light came on this morning (a regular occurrence; it's not flashing) and the car is 'shifting funny.' He said that the car is not shifting out of first gear until about 3000 rpm, and when it does it's a 'hard shift' with an audible clunk/thump, then it shifts fine after that. He's has a number of small issues with this car lately, but nothing strange with the transmission.
View 1 RepliesGolf IV / Jetta IV :: 2003 1.8t - Hesitation In Boost ( 3rd / 4th And 5th Gear)
2003, Jetta 1.8t, 5 speed, 76,500 miles ... The other day I was driving and all of a sudden I had a hesitation in 3rd gear. I have relized since that this hesitation occurs in 3rd 4th and 5th gear, but not 1st or 2nd. I am going to change the spark plugs tomorrow in hope to fix this problem. The hesitation occurs whenever you get into the gas and begin to accelerate(typically around 3000RPM and up). There are no dash lights on at all and the cars is running fine besides the hesitation.
View 2 RepliesGolf IV / Jetta IV :: 2003 - Transmission Stuck In 3rd Gear
I've had my 03 VR6 6-speed for 12 years. It's been a second car for the last 5 or so, but regularly used. Friday morning the car got stuck in 3rd gear. The stick will only move from neutral position and down towards 4th gear. I've inspected the short shifter under the hood and the bushings under the shift boot. I did not find anything that diesel geek (the short shifter company) had me check for.
I brought the car into a local shop I have never used before (my usual shop closed), and today they called me saying its a transmission issue. I have not given them permission to open anything up. I am going to take the car home for now.
I have had to repair a broken 1-2 gear fork before. And at that time I had the 3-4 gear for replaced as well.
I should also mention, I similar issues on a quick drive i took the car on the night before. I thought it was just me acclimating to the shifter/lower power of the car as I hadn't driven it for a while. The point is, it drove fine afterwards and it drove fine for a 40 minute city drive to work the next morning.
Golf IV / Jetta IV :: 2003 - CEL / EPC Light Came On - Won't Shift Out Of 1st Gear?
Just bought this car yesterday. test drive went fine with no issues. Started driving it home and the check engine light came on ( no big deal i thought car runs great). I go to advance auto and their scanner won't hook up to it. So i start looking at the fuses and everything was good except it was missing the the number 7 fuse ( reverse lights/speedometer sensor), so i replaced the fuse. i get home and i decide to take it down the road one more time and it all went down hill quick. EPC light came on, the car wont shift out of first gear (automatic). so i let it sit over night with the number 7 fuse out and the battery disconnected. CEL never disappeared this morning and its do the same thing. It looks like the MAF was just replaced and the brake light switch looks like the newer green version. Im going to replace the brake light switch this afternoon and i already cleaned the MAF. Another thing that i noticed that is very strange is now the Foot symbol by the shifter has gone out. The one on the dash still is working properly but the one at the shifter does not light up at all now.
View 1 RepliesGolf IV / Jetta IV :: 2003 - Hit 7k RPMs In First Gear - Rev Limiter?
I was driving earlier and some dickhead wouldn't stop tailgating me. I brake checked him and he wouldn't back off so I got pissed and floored it. Didn't watch my rpms and I felt it give like I hit a rev limiter maybe? I'm hoping that's what it was, it was like an instant loss of power for a brief second. Just was curious that I didn't brake anything. Driving a 2003 Jetta 1.8t. Manual.
View 13 RepliesSaturn - Vue :: 2003 - Transmission Jerks And Shifts To A Higher Gear
Only during the summer, my 2003 Vue transmission jerks and shifts to (I believe) to a higher gear. Mechanic replaced the computer "harness" but it did not solve the problem. The car has little power to accelerate from a stop. I usually pull over, turn off the motor, and restart the vehicle.
View 3 RepliesGolf IV / Jetta IV :: 2005 - Won't Go In Reverse At Cold / Shifts Roughly From 1st To 2nd?
Just bought a 2005 Jetta 2.0 4 speed automatic (non tiptronic) with 92,000 miles. This is the old 1999-2005 style, not the New Jetta that was introduced that year.
I've done research and have found that the transmissions on these bodied Jettas seem to be acting up.
This one shifts fine with a few weird things. When I start the car cold (this is in LA, so even over night the temps don't go below 60), and I put it in reverse, the car does not go into reverse for a good 3-5 seconds. This does not happen after the car has been driven for a while. After that it shifts fine, no delay.
The other symptom is sometimes the shifts from 1st to 2nd gear are a bit rough, with a thump sound, but nothing too out of the ordinary...if it wasn't for the other mentioned problem above, I wouldn't think twice about the 1st to 2nd shift as many automatic cars have some rough shifts. All the other gears shift fine.
I've done the basic research to know there could be a couple things causing this such as clutch piston seals and excessive drainback. I want some more info since I know there are my experienced people on this forum. Should I be worried and are there any things I should do immediately?
I have also found that these transmissions are sealed and can not be checked for oil levels with out taking to expert shop. I've also seen that they are very sensitive to overfill and any service needs to be performed by experts. Should I just continue and come back to this if symptoms get worse?
Golf IV / Jetta IV :: Revs High Between Shifts And Randomly Doesn't Start
I bought this car and I've changed out the Clutch Position Sensor, the black one on the clutch mount. Started to work and start but now it's doing the same symptoms as before. So here is what is going on.
1. Randomly doesn't start, full power comes on, and fuel system turns on, immobilizer works just fine as far as I can tell (key light turns off)
2. Cruise control doesn't work (which lead me to the CPS)
3. High revs between shift, once I push the clutch to shift it revs up high, I noticed that if I stay under 3k it doesn't do it as much, but if I go HAM on it it revs up about 1k rpm more than at shift point. But if I shift nice it revs about 2-400 rpm.
It's been tuned by C2 Motorsports, done by a certified mechanic, that's the only mod on the car, besides suspension. I bought the car and dropped 1100 to fix it to drive right, newish throttle body, and a major vacuum hose, and the tune within a month of getting the car and the tune was to mainly flash the ecu so it wouldn't pull two codes for a leak that wasn't there anymore.
Ford - F250 :: 2003 - Shifts Into Higher Gear / Slips A Bit Then Downshifts And Runs Fine?
I have a 2003 F250 with a 5.4L V8 automatic transmission with 64,000 miles. The truck runs and drives well, but occasionally while driving, it acts like it shifts into a higher gear, slips a bit, then downshifts and runs fine. The duration of this "acting up" is about 1-2sec. It seems to do it when going up a slight grade at cruising speed about 40-50mph. (Not towing when it does it) It doesn't do it all the time. I'm planning to change the filter and fluid but am doubtful that will work. The fluid color is nice bright pink and does not smell unusual.
View 1 RepliesGolf IV / Jetta IV :: Overfilling Trans Causing Hard Shifts - Check Engine Light Came On
Will overfilling transmission fluid cause hard shifts? I used ~4.3 quarts to refill. How much should I drain out? My check engine light came on.
Basically, I am having hard shifts from 2-3 and 3-4 in tip mode and auto. more tip mode tho.
-I did a complete solenoid change b/c of cold start problem with n92 solenoid.
Fixed the cold start shifting out of first.
-Did a trans fluid change with Mercon V ATF Fluid works fine.
-Just changed oil on 4th of July last week.
Yesterday my check engine light came on. It's been about 500 miles since the solenoid change/trans fluid change, and 100 miles since the oil change.
Now my Mk4 is having this obnoxious shifting. I am thinking I possibly added too much trans fluid into my system as I do not have the VAGcom tool.
I drained out (bone dry drain till no more dripping from check/drain plug), roughly 4 quarts. I added 4.3 give or take 0.1 quarts back into the car.
Now I'm worried because everywhere I'm reading says anywhere from as little as 2.1 quarts to 3.5 quarts.
Should I drain out 0.5 quarts (because I know theres over 4 in there now) to make it 3.5 quarts?
Or should I just redrain the whole thing and start by measure one quart at a time?
Golf IV / Jetta IV :: 2010 - Key Stuck In Ignition - Shifts Out Of Park Without Pressing Shifter Button?
So I have a 2010 jetta 2.5 and my key is stuck in the ignition has been for a couple weeks also don't know if it's related but when I start the car I can pull the shifter out of park without pressing shifter button just have to press brake and after I shut the car off if I take it out of park and put it in gear it just freely rolls only stops if it's in park. NOT A DSG
View 3 RepliesGolf IV / Jetta IV :: Very Hard To Get A Smooth Shift From Gear To Gear
Background facts:
Tranny swapped from my 4 speed auto to a 1.8t o2j 5spd
13lb. Light flywheel
Powerflex dogbone mounts
Peloquin LSD
The problem: Very hard to get a smooth shift from gear to gear. Trust me, I know how to drive, but I can always feel the car shifting into a different gear if you know what I'm saying. On my friend's bone stock Jetta, I just let the clutch out without gas in between shifts and you don't feel a thing.
On my car, you feel EVERYTHING. People have told me the light flywheel will make the ride more uncomfortable in many ways, especially since the RPMs drop much quicker in between shifts than stock.
Golf IV / Jetta IV :: 6th Gear Went Out
I'm most likely picking up a 03 jetta glx vr6. Thing is the 6th gear is out. Is the entire transmission about to break or is it a common thing?
View 16 RepliesGolf IV / Jetta IV :: Car Won't Go In 1st And 2nd Gear When Off
LLast night I was driving. I got off the highway and pulling on to the main road in 2nd, I ripped on it and went into 3rd quickly. It basically kicked it out of gear, and didn't seem like I had any other gear besides 1st or 2nd. Got to a local gas station in 2nd, and I originally thought my linkage had come off. While trying to back into a spot to make life easier, there was no reverse. seems like the trans is binding up. Aligned the linkage anyway, when the car is off, it goes into every gear, but when it is on, it feels like 1st-2nd-nothing. If I roll the car backwards and then forward, I have 1st. Other than that, it will not engage. If I put the trans in reverse and then try to back up, it feels like the trans is binding. Same with 1st, unless the car is running. Traction control light will not turn off either, will have it scanned this week to determine that issue...
Ive seen most people have issues with the 1st-2nd shift fork and have this causing the reverse issues.
2005 GLI 1.8t
Golf IV / Jetta IV :: Car Will Not Go In Gear When On But Will When Off
The car was starting to have issues going into gear after a night of cruising. Then I was experiencing what I am thinking was clutch creep. The clutch would be down and in gear and the car wanted to slowly roll.
What I have done to try and fix it:
I have bled the system many times to get all the air out(i believe), and also readjusted the the linkage. NOW, the car will not go into gear when it is on but will when it is off. I have the car on stands at the moment and it will shift through all the gears when the car is on just the wheels spin since it is in the air.
The clutch/flywheel/pp/throw out bearing all have less then 2k miles on them. Tranny fluid has been replaced with Penzoil syncomesh. I have yet to ever do a hard launch.
Clutchmasters Fx400, OEM DMFW.
Car is an 02m trans w/o the black cap in the side so I cannot do the washer/gasket mod for clutch creep. Believe I have to order NLS shim kit and put behind the throw out bearing.
Golf IV / Jetta IV :: Won't Rev Above 3100 Rpm In Any Gear
Over the past couple weeks sometimes when i turn my car on it wont rev above 3100 rpm in any gear. The car is a 5-speed jetta 8v 2.0 and I'm just looking for any insight as to what is causing this problem. My check engine light is on and i had the codes read and there was a bunch, "catalyst system below threshold bank 1", " ignition coil A,B,C,D circuit primary/secondary malfunction", and "camshaft position sensor "A" circuit high input". I'm not sure if these codes are related to the problem but i had to have the whole top end of my engine rebuilt not even a year ago and all of the ignition coils and sparkplugs were replaced during that time.
This problem does not occur every time i turn the car on however, i did notice that sometimes when i go to turn the car on instead of the car starting in quickly, it will start hard after sever cranks and this is usually when i have this issue. it is very weird almost like there is a rev limiter on and i can usually fix the problem if i get up to highway speeds and downshift hard into 3rd and the car will shudder once or twice and will drive like normal again. What could be wrong i was thinking it might be a bad O2 sensor or a vacuum leak somewhere.
Just to clarify what i mean by it wont rev past 3100 rpm i mean that i can start from idle and accelerate normally and when it gets to 3100 rpm the power goes away and will just stay there even i put my foot all the way down. I can shift up and the same thing will happen i will accelerate normally but then once i reach 3100 rpm again it will stay there.
Golf IV / Jetta IV :: Won't Go Into Any Gear With Car Off Or On Except Reverse?
Have a 20th with the 02m six speed ... Car won't go into any gear, except reverse ... Tried with the car off or on, clutch in and out with no luck ...
I took off the linkage from the engine bay and can only manually get the car to go into reverse ... Feels like it can't change "levels" ... Don't think it's clutch since because the car won't engage a gear even with the car off ...
Tried searching and no luck ... Thinking shift forks but hoping not since don't want to drop the transmission and it could be something else ...
Golf IV / Jetta IV :: Car Won't Go Into Sixth Gear At All
I bought my first vw about a month ago. It's a 2003 GTI 1.8t with what I THOUGHT had a 6 speed transmission in it when I bought it. I hate to admit it, but when I test drove it, I never had a chance to put it into 6th gear.
Anyways, I replaced the shift lever, and shift cable (bad Bushings on cable and you can't just buy the Bushings) because it was hard to get it onto 1st gear without pulling the boot up, and pushing that metal part down. (I don't know the actual part name). Anyways it shifts great now that I have the cables adjusted however it will not go into sixth no matter what I do.
This leads me to think that maybe someone put a 6 speed knob on a 5 speed lever. However, the wear on the knob is exactly the same as the wear on the steering wheel. The guy at the local dealership told me he sold me parts for a 5 speed shifter box and that the 6 speed linkage is completely different and I 100% have the 5 speed trans.