Golf IV / Jetta IV :: 2002 VW GTI 1.8 T Died While Driving
I was recently driving home when I made a left hand turn and the car died. I had the timing belt and water pump replaced 1,800 miles ago. It sounds like a timing issue to me. The last time I had timing issue it wouldn't run. This time it runs. Attached is a video of me starting it with the camera looking at the timing belt. The noise I heard made me shut it off. I did not want to cause more damage.
[URL] .....
Golf IV / Jetta IV :: 2002 - Coolant Goes Low After Driving Unless Relieve Pressure In Reservoir
Why my 2002 Jetta 1.8t does this?
After I drive for a while I have to [slowly] open the overflow cap and relieve pressure in order to not lose coolant while the car sits. It steams for a bit when I open the cap and then the coolant rises in the reservoir then I close it.
If I don't do this then the car loses coolant but I don't see any leaks visible under the car.
Golf IV / Jetta IV :: 2002 VW 2.0 - Loss Of Power While Driving At Normal Highway Speed
Ok, so I was driving normal highway speeds and all of a sudden, I realize a major drop in power. I pull over and restart it and it changes nothing. Now when I floor it, it takes 20-30 seconds to get to 90K.
I checked the air filter... Nothing. Used a code reader... Nothing. Then I decided to pressure test the cylinders... Nothing, except now the check engine light is on.
The Ol Dub is still drivable, but it is extremely slow and rough at idle. I am thinking it might be a MAF or fuel filter.
Golf IV / Jetta IV :: 2002 1.8t Overheating - Temperature Started To Rise After Driving Like 30 Seconds
I have a 2002 jetta 1.8t that overheated on me out of no where i have read some post and couldn't really find what i need it never overheated on me before and this was the first time and when ever i open the reservoir where you put in coolant everything spills out its my first time owning a volkswagen, it happens as soon as i start driving like 30 secs and temperature starts to rise.
View 3 RepliesFord Super Duty (1999-2016) :: 2004 - Hesitate / Loses Powers And Shuts Off When Driving Down The Road
I have a 2004 6.0 133000 miles will be driving down the road will start to hesitate and looses powers and shuts off. wont start back up but if you wait 10 to 15 minutes will start up and run just fine. wont do it again. Just had new head studs put in new head gasket and egr delete 2 new injectors put in
View 3 RepliesGolf V R32 :: 2008 - Humming Noise Stays Until Radio Completely Powers Off
Ok so this has been driving me nuts now for a couple days. When I listen to the reg radio, not noticeable. When i use xm, I switch channels and there is a very noticeable humming noise. Now the louder i turn the volume up the louder the humming gets. It makes the stations sound horrible. Not the same in FM! If i turn the car off the humming noise stays until the radio completely powers off. Everything is stock, stock NAV unit, stock speakers, no add on's. What am i missing before i go chasing gremlins. Some say its the amp, some says its the nav unit. How can i narrow down what it is?
View 3 RepliesGolf IV / Jetta IV :: 2002 GTI Won't Go Over 7 Psi
I have a 02 golf gti it has 3 inch turbo back catless exhaust k04 turbo front mount inter cooler hks blow off valve eurodyne tuning software i just did the sai/n249 valve/and pcv delete and I put a new n75 valve on it and my car still wont go over 7 psi. The tuning software is asking 18 but it just wont go over 7?
View 4 RepliesGolf IV / Jetta IV :: 2002 - Won't Start Sometimes?
Now I'm back and just picked myself up 2002 Golf GTI with fairly low kms for its year. Anyway when i test drove and checked through it all everything seemed fine. Basically she won't start 1/6 times. So for example of the amount of usage she had today:
AM - Drove to work this morning, started fine from cold (its just come into winter so probably around 12 degrees Celsius).
PM - Drove home from work, started fine from cold
Evening (3 hours approx. after driving home) - started fine from cold, drove 5 mins, stopped at gas station, started fine and drove another 5 min then stopped and parked.
After parking, i decided to move her closer to the building for security but when i cranked her she would turn over but not start. Tried this 2 or 3 times (probably flooded the engine).
After about 1 1/2, jumped backed in, started first time but took a few seconds to start with foot slightly on gas. Checked the fuel pump, i can hear it switching on so can rule that out.
I'm suspecting its a battery issue based on history (has had all the major service parts done timing belt, fuel pump etc) and for the majority of its life, its actually just sat in a garage, according to the dealer (old guy that lived and worked in the city owned it before me) and that this just needs replacing. The battery doesn't look old however under the bonnet it is stupidly clean so might not be an indication of anything.
I haven't had a flat battery for a while though but from what i remember, a flat battery just clicks or even struggles to turn over? Any simple things i can check myself? Just went downstairs to check fuel pump, thats switching on and car started fine 4 times in a row.
Golf IV / Jetta IV :: 2002 GLS Doing About 13 MPG In City
Mk4 2.0 GLS 2002. I'm guessing the title clearly introduces the problem, I think I should be getting around the 21MPG mark in city with my Golf. I have changed alot of things to try and improve the mileage but it's not getting any better.
I've changed the Air Mass Sensor, both oxygen sensors, the catalyze, spark plugs, done some work to the gear, fixed leakage in the automatic clutch, and I have done some deep cleaning to the engine.
Golf IV / Jetta IV :: Shut Off While Driving
Car shut off while driving. Saw it wasn't getting fuel. Replaced fuel pump. Got fuel. It will crank. Still won't start. Replaced crankshaft position sensor. Still no luck. No battery. No luck. Timing belt is perfectly fine. I checked the ecm relay and it seems to be working. It won't get a spark. It will try to crank but will not get a spark in any of the cylinders..
View 18 RepliesGolf IV / Jetta IV :: Won't Driving Even Though It Is In Gear
My car is a MK4 Golf 2.0L .. Standard I was stopped at a stop light and I started going everything was fine til i got to 3rd gear. I was in gear but nothing was happening I would push the gas and you could hear it turning but I wasn't moving the only thing is i could hear a little grind. Could it be my clutch has gone bad or maybe the cold weather freezing things up....
View 9 RepliesGolf IV / Jetta IV :: 2001 - Gas Cut Out While Driving
My girlfriend recently picked up a 2.0 Jetta, had her dad drive it 800 miles with no issues except a code for needing a new thermostat. A few weeks ago, we were out for a drive getting on the freeway and all of a sudden the gas just cut out on her. Then on a separate occasion, did the same thing except this time the power steering was gone and the brakes wouldn't depress. I told her to click it into neutral and then back to drive next time it happens, so she did and then it was like nothing ever happened. Weird, right? I don't really have any leads on where this could be coming from, since it's so intermittent.
View 2 RepliesGolf IV / Jetta IV :: 1.8t 2002 Shutdown At Idle
IMy golf 1.8t 2002 shutdown at idle and when you started again she started again and runs fine you stopped at light wait few seconds the engine shutoff.
View 11 RepliesGolf IV / Jetta IV :: 2002 GTI 1.8t AWP Won't Start On First Crank?
So i got a 2002 gti 1.8t awp . Wont start unless I crank it about 2-4 times. Also noticed a bit of a grinding/high pitched noise when cranking. when the car starts up it idles perfect, doesn't die , drives perfect etc...
Eventually i got the car scanned. & got 2 codes.
P0341 : Camshaft Position Sensor A Circuit Range/ Performance B1
&
P0230 : Fuel Pump Primary Circuit Malfunction
So I went and bought a Fuel pump , Camshaft position sensor & Even a new starter. Nothing fixed it. & the problem still occurs..
Heres a video of me trying to crank it ; [URL] .....
Golf IV / Jetta IV :: 2002 At Normal Speeds Car Will Cut Off On Its Own
I've been having this problem for a few weeks now and its getting real bad. When I'm driving along at normal speeds my car will cut off on its own. Also when I'm slowing down the car will jump up 5-600 rpms and at utter and shake a lot and every other time it'll cut off. I've replaced the maf and nothings changed. I'm really hoping it doesn't have to do with the transmission. The car has 241k on it .
View 3 RepliesGolf IV / Jetta IV :: 2002 GTI Won't Turn Over After ABS And ASR Lights
I have an 02 GTI w/ 1.8t and 5spd. I was in the drive through and all of the sudden the ABS, ASR, and seatbelt lights came on and the battery light is randomly blinking. I got home turned the car off and went to restart it and when I turn the key nothing happens. I should also mention I recently have 2 cels for p0171 lean condition and bank 1&3 misfires that developed after I replaced a bad injector. Where do I even start?
View 7 RepliesGolf IV / Jetta IV :: 2002 02M GTI Won't Move In Any Gear
So today I was driving my car and everything was fine. I get to a freeway off ramp. I put it in first and it goes like normal I shift from first to second and then into third when i shifted into third, I hear a grind sound like I miss shifted or something. I continue on and when I get to a red light I go to take off in first and nothing...The car wont move!! I have the clutch all the way out and its in gear and nothing... I can have the car running and the clutch out and i can shift it in any gear and nothing happens. I have a spec stage one and an 8lbs smf in the car and before i could hear clutch chatter and now when i have the clutch out I don't hear anything? What is causing this?
View 3 RepliesGolf IV / Jetta IV :: 2002 VR6 - Fuse 29 Keeps Blowing Out
02 JettaVr6 auto tranny- car was running perfect, no CEL. Now all of a sudden the fuse keeps blowing out- what exactly is running off this fuse?
View 1 RepliesGolf IV / Jetta IV :: 2002 - Cooling Fan Not Working / No AC
I recently picked up an 02 Golf with a 2.0/5-speed. It's just a plain-jane model without all the bells and whistles. My fans and A/C aren't working. I can deal with no A/C but the cooling fans are kinda important. I did all of the trouble shooting. Both fans work on low and high when jumped at the radiator temp switch so my fans aren't the problem. I replaced the temp switch with no change. My OBD-II scanner shows that my actual coolant temperature was about 10 degrees off from my temp gauge so I replaced the temp sensor too. The timing belt and water pump were both changed about 5K ago.
I borrowed a "good" FCM from a buddy's car and that didn't work either. I went through the troubleshooting diagnostics for the FCM harness and see that I do not have continuity between T14/14 & T14/5 on the harness side. This indicates that the "F38 Ambient Temp Swicth" is possibly my culprit. Everything else checks out good on the FCM harness. Where is this switch located? I've searched online and found nothing specific to my 02. For the sake of testing can I jump these 2 wires for continuity to simulate a working switch? From what I've read this ambient temp switch disables the fans and A/C when air temps are below a certain temp. My next step is going to be wiring in a variable speed fan controller if I can't figure this out .....but I'd rather not get in to that if I can get the factory setup working.