Golf IV / Jetta IV :: Rear Wheels Locked Up
I replaced the rear brakes on my 2003 Jetta 2.0. Reman. Calipers, new pads and rotors.
I bleed the rear right and then the rear left. Have full pressure in the pedal but the disc in grinding at low speeds and when I apply the brakes the rear wheels almost lock up.
Golf IV R32 :: Driver Side Door Doesn't Line Up Perfectly
My drivers side door doesn't line up perfectly, it sits a little lower the farther you go towards the rear and requires a little bit more energy to close than the other one. Is there any easy way to adjust this?
View 3 RepliesCherokee :: 2002 Fitting On Top Of Pump With Clip Bracket Is Leaking
I have a 2002 Jeep GC with the 4.7 v8 84k miles.
I noticed that the fitting on top of the pump with the clip bracket is leaking I removed the clip and tightened the nut/fitting. Moved just a bit. The hose is loose in there and I can pull it up and down like I said it's loose. It's weeping PS fluid. Is this suppose to be loose or is there an o ring inside the fitting? I'd like to get this fixed I before it gets too cold out.
Golf IV / Jetta IV :: 2001 GLS - High Pitched Squeaking When Wheels Turned Full Lock
This is kind of an odd ball problem since I have not encountered this before, but every time I turn my wheels full left or full right and start moving a really high pitched squeaking sound comes from the front of the car. Is it bad alignment or wear sensors on the brake pads rubbing? the brakes have a lot of pad left so i find that hard to believe.
View 5 RepliesGolf IV R32 :: 2003 - Fitting Supercharged Boost Gauge
I live in Scotland so have a right hand drive 2003 MKIV R32. I got a VF stage 1 kit fitted last year and now I want to fit a boost gauge. I've bought a NewSouth indigo 0-30 psi gauge and a column pod.
What I need to know is where to take the feed from, where is the best place to fit the vacuum tube to get the best readings? any photos would be good.
I plan on fitting it this weekend along with my oil pressure gauge.
Golf IV / Jetta IV :: 2002 GTI Won't Go Over 7 Psi
I have a 02 golf gti it has 3 inch turbo back catless exhaust k04 turbo front mount inter cooler hks blow off valve eurodyne tuning software i just did the sai/n249 valve/and pcv delete and I put a new n75 valve on it and my car still wont go over 7 psi. The tuning software is asking 18 but it just wont go over 7?
View 4 RepliesGolf IV / Jetta IV :: 2002 - Won't Start Sometimes?
Now I'm back and just picked myself up 2002 Golf GTI with fairly low kms for its year. Anyway when i test drove and checked through it all everything seemed fine. Basically she won't start 1/6 times. So for example of the amount of usage she had today:
AM - Drove to work this morning, started fine from cold (its just come into winter so probably around 12 degrees Celsius).
PM - Drove home from work, started fine from cold
Evening (3 hours approx. after driving home) - started fine from cold, drove 5 mins, stopped at gas station, started fine and drove another 5 min then stopped and parked.
After parking, i decided to move her closer to the building for security but when i cranked her she would turn over but not start. Tried this 2 or 3 times (probably flooded the engine).
After about 1 1/2, jumped backed in, started first time but took a few seconds to start with foot slightly on gas. Checked the fuel pump, i can hear it switching on so can rule that out.
I'm suspecting its a battery issue based on history (has had all the major service parts done timing belt, fuel pump etc) and for the majority of its life, its actually just sat in a garage, according to the dealer (old guy that lived and worked in the city owned it before me) and that this just needs replacing. The battery doesn't look old however under the bonnet it is stupidly clean so might not be an indication of anything.
I haven't had a flat battery for a while though but from what i remember, a flat battery just clicks or even struggles to turn over? Any simple things i can check myself? Just went downstairs to check fuel pump, thats switching on and car started fine 4 times in a row.
Golf IV / Jetta IV :: 2002 GLS Doing About 13 MPG In City
Mk4 2.0 GLS 2002. I'm guessing the title clearly introduces the problem, I think I should be getting around the 21MPG mark in city with my Golf. I have changed alot of things to try and improve the mileage but it's not getting any better.
I've changed the Air Mass Sensor, both oxygen sensors, the catalyze, spark plugs, done some work to the gear, fixed leakage in the automatic clutch, and I have done some deep cleaning to the engine.
Golf IV / Jetta IV :: 1.8t 2002 Shutdown At Idle
IMy golf 1.8t 2002 shutdown at idle and when you started again she started again and runs fine you stopped at light wait few seconds the engine shutoff.
View 11 RepliesGolf IV / Jetta IV :: 2002 GTI 1.8t AWP Won't Start On First Crank?
So i got a 2002 gti 1.8t awp . Wont start unless I crank it about 2-4 times. Also noticed a bit of a grinding/high pitched noise when cranking. when the car starts up it idles perfect, doesn't die , drives perfect etc...
Eventually i got the car scanned. & got 2 codes.
P0341 : Camshaft Position Sensor A Circuit Range/ Performance B1
&
P0230 : Fuel Pump Primary Circuit Malfunction
So I went and bought a Fuel pump , Camshaft position sensor & Even a new starter. Nothing fixed it. & the problem still occurs..
Heres a video of me trying to crank it ; [URL] .....
Golf IV / Jetta IV :: 2002 At Normal Speeds Car Will Cut Off On Its Own
I've been having this problem for a few weeks now and its getting real bad. When I'm driving along at normal speeds my car will cut off on its own. Also when I'm slowing down the car will jump up 5-600 rpms and at utter and shake a lot and every other time it'll cut off. I've replaced the maf and nothings changed. I'm really hoping it doesn't have to do with the transmission. The car has 241k on it .
View 3 RepliesGolf IV / Jetta IV :: 2002 GTI Won't Turn Over After ABS And ASR Lights
I have an 02 GTI w/ 1.8t and 5spd. I was in the drive through and all of the sudden the ABS, ASR, and seatbelt lights came on and the battery light is randomly blinking. I got home turned the car off and went to restart it and when I turn the key nothing happens. I should also mention I recently have 2 cels for p0171 lean condition and bank 1&3 misfires that developed after I replaced a bad injector. Where do I even start?
View 7 RepliesGolf IV / Jetta IV :: 2002 VW GTI 1.8 T Died While Driving
I was recently driving home when I made a left hand turn and the car died. I had the timing belt and water pump replaced 1,800 miles ago. It sounds like a timing issue to me. The last time I had timing issue it wouldn't run. This time it runs. Attached is a video of me starting it with the camera looking at the timing belt. The noise I heard made me shut it off. I did not want to cause more damage.
[URL] .....
Golf IV / Jetta IV :: 2002 02M GTI Won't Move In Any Gear
So today I was driving my car and everything was fine. I get to a freeway off ramp. I put it in first and it goes like normal I shift from first to second and then into third when i shifted into third, I hear a grind sound like I miss shifted or something. I continue on and when I get to a red light I go to take off in first and nothing...The car wont move!! I have the clutch all the way out and its in gear and nothing... I can have the car running and the clutch out and i can shift it in any gear and nothing happens. I have a spec stage one and an 8lbs smf in the car and before i could hear clutch chatter and now when i have the clutch out I don't hear anything? What is causing this?
View 3 RepliesGolf IV / Jetta IV :: 2002 VR6 - Fuse 29 Keeps Blowing Out
02 JettaVr6 auto tranny- car was running perfect, no CEL. Now all of a sudden the fuse keeps blowing out- what exactly is running off this fuse?
View 1 RepliesGolf IV / Jetta IV :: 2002 - Cooling Fan Not Working / No AC
I recently picked up an 02 Golf with a 2.0/5-speed. It's just a plain-jane model without all the bells and whistles. My fans and A/C aren't working. I can deal with no A/C but the cooling fans are kinda important. I did all of the trouble shooting. Both fans work on low and high when jumped at the radiator temp switch so my fans aren't the problem. I replaced the temp switch with no change. My OBD-II scanner shows that my actual coolant temperature was about 10 degrees off from my temp gauge so I replaced the temp sensor too. The timing belt and water pump were both changed about 5K ago.
I borrowed a "good" FCM from a buddy's car and that didn't work either. I went through the troubleshooting diagnostics for the FCM harness and see that I do not have continuity between T14/14 & T14/5 on the harness side. This indicates that the "F38 Ambient Temp Swicth" is possibly my culprit. Everything else checks out good on the FCM harness. Where is this switch located? I've searched online and found nothing specific to my 02. For the sake of testing can I jump these 2 wires for continuity to simulate a working switch? From what I've read this ambient temp switch disables the fans and A/C when air temps are below a certain temp. My next step is going to be wiring in a variable speed fan controller if I can't figure this out .....but I'd rather not get in to that if I can get the factory setup working.
Golf IV / Jetta IV :: 2002 - No Resistance When Turning The Key
When I turn the key in the ignition, almost nothing happens. There is no resistance when turning the key. Accessory power works (interior overhead lights, dash back lighting, door open sound) but no dash lights or headlights (just the front passenger parking light comes on). Tried to get a jump but nothing happened, not even the headlights came on. Haven't tried push start yet. I suspect an issue with the ignition switch, but I found another thread that suggested it could also be traced to certain fuses.
View 3 RepliesGolf IV / Jetta IV :: 2002 - Ebrake Don't Work?
So I picked this clean mk4 up and its my daily but what to do. It already has new coilovers and little things here and there.I recently noticed my e brake doesn't work I tried adjusting but no luck what can it be the cables seem to be intake. Also if I get a bov does it make my gas mileage crappy?
View 7 RepliesGolf IV / Jetta IV :: 2002 - Transmission Is Slipping At 20 Mph
2002 vw Jetta sportwagon automatic trans, 151k, no previous issue with the transmission like this. the new issue is that the transmission is slipping at 20mph. what I would guess is 2nd to 3rd (3rd-drive)gear, the transmission "slips" and over revs, I take my foot off the gas and it engages.
I have no more issue accelerating after that. it only happens at exactly (on the speedo) 20mph. hopefully it is only a transmission fluid issue.
As a sidenote. my car will periodically lose power when the engine is cold with no rhyme or reason. the car power drops (on a flat or an incline) for about 2sec then back to normal. its been happening for a year or so.