Golf IV / Jetta IV :: 2001 - Battery Dead - Sits For 10 Minutes Then Start Again
I have an 01' 1.8 t. We had a Pioneer touch screen Bluetooth deck installed and it was fine for months. All of a sudden it started having battery problems. If it sat for 6+ hours it was dead. We got a new battery from pep boys and once again it was fine for months. They tested my charging system and all components and everything was good. Then it started dying again. We'd charge it and after about 10-20 min it would start. Now the sit time is sporadic, sometimes it will sit all day and start right up and sometimes it sits for 10 min and won't start. Now its not taking a charge. We've once again checked the terminals, charging system, alt. Etc. And its all good. I don't know if it has anything to do with the stereo. We've checked all the wiring and its how it should be, I'm at a loss with this car. It occasionally throws a check engine light but we've hooked up the OBD and there's no codes. When I run the ac the car acts super sketchy, and starts throwing lights. (Brakes, air bag, wipers, engine, asr, doors). Fuses checked out all good, we haven't been able to find a single diagnostic explaining wtf is going on. I love my car too much to give up on her.
View 6 RepliesGolf IV / Jetta IV :: 1.8 Not Starting On First Couple Tries When Sits For More Than 24hrs
I'm driving a 03 1.8 jetta with no mods. Whenever my Jetta sits for more than 24hrs, I have a hard time starting it. It turns over just fine but sputters to a stall once it fires. I do this 3 times before it revs high and stabilizes.
I changed out the coil packs, fuel filter and spark plugs. I can hear the fuel pump prime before starting so I assume that is working fine.
I dont notice any issues while driving either. Its just the start up. It particularly acts up in cooler temps and higher humidity (raining days too).
Ford F-150 - 1997-2003 :: 2001 - Transmission Leaks Occasionally?
01 F-150 7700 ed.
I have a 4R100 Tranny with 139K miles. It has been rebuilt. Ever since the rebuild (over 10 yrs ago), if I park the truck for a week or so or more, I will end up with a decent size puddle of trans fluid underneath the truck. I took it back to the shop that did the rebuild a couple times, but they could never find anything. It leaks enough to where my fluid level drops enough to cause the transmission to slip in a U-turn because the pickup tube becomes uncovered. I have a couple theories, but am wanting to hear from the collective.
Theory #1 When I park it on my slightly sloped driveway I don't regularly use the parking brake, so it rests on the gears, which eventually forces fluid out an overflow or breather tube.
Theory #2 (a very thin one) due to pressure changes associated with the weather, fluid is somehow siphoned out a breather tube due to some blockage internally in the tranny to where it's not equalizing with the outside air and has a high pressure within... ( i kinda laugh at myself for this one, but I am at a loss over the source of this)
Golf IV / Jetta IV :: 2001 - Shifter Won't Shift The Transmission All The Way?
I have an 01 Jetta, 2.0L, 5 Speed manual transmission.
The issue seems to be that the shifter wont shift the transmission "all the way" into 1st, 3rd, and 5th gear. When I shift into the gears that are forward on the shifter, it will go into gear, but then the shifter (in the car) moves back toward neutral a little. I can drive in 1st no problem, but in 3rd and 5th some weird stuff happens...
While driving, when I shift from second to third I have to keep my hand on the shifter otherwise I get kicked out of gear. Also, when I drive on the highway, I periodically get kicked out of 5th gear if I don't keep my hand on the shifter (usually, when I let off the gas).
Anyway, being that I've fixed many problems on many cars by searching forums and google, I spent the last few days trying to figure out the problem by looking through the forums, but I have yet to find a solution. I tried adjusting the shift linkage using the method described in the dieselgeek video on youtube [URL] ...., but it didn't work. I'm pretty certain it's not the shifter bushings because i have almost no play in the shifter in neutral.
I had someone cycle through the gears while I watched under the hood, and its clear that the cable that controls the forward and back part of the shifting is not pulling back far enough on the counterweight on the transmission. (When shifting into 1st, 3rd, and 5th.) When the shifter puts the tranny into these gears I can still move the counterweight on the tranny further than the shifter will pull in in the same direction.I tried adjusting the linkage to compensate for this, but the cable is as far into the cable end as it will go...
Golf IV / Jetta IV :: Small Coolant Leaks On GLI?
Bought a MkIV for the fiancee 2 weeks ago (04.5 GLI 1.8T Automatic).. Great driving car, needs some minor love (really dirty, burnt out lights, etc)
After the first week, the coolant light came on
Had some G12 handy, topped it off (like 8-10 oz)
All good
2 days later, it came on again, added about the same amount
4 days later, it came on again, added the same amount
1 day later, it came on again, added the same amount
I am adding 50/50 mix, but haven't seen a puddle anywhere, Nothing looks wet, but then again its hard to see around the plastic cover ...
Golf IV / Jetta IV :: Oil Cooler Leaks Only At Startup
I noticed last week when I leave the house in the morning my car was leaving oil striped down my road. Jacked car up Saturday AFTER RUNNING TO STORE found a little oil on bottom of my car but not nowhere near what I was thinking there would be. Cleaned motor fired up found no leaks at all . However this morning after car had sat 20hrs or so I looked under car before I cranked her up clean.
Got it cranked her up and oil was streaming from the oil cooler. Not on the block side but towards the front of car side of cooler. It did this for a few seconds then stopped. I am gonna order new front and rear orings for oil cooler. I am just stumped why it only happens at a cold start and for a few seconds not consistently.
Golf IV / Jetta IV :: 2001 VR6 Manual Transmission Gets Stuck In 3rd Gear
I just picked up another GTi and knew the transmission was iffy when I bought it. I had to deal with the serpentine belt tensioner which is now new and also a new waterpump since it was wobbling.
I've already drained and replaced whatever oil was in there with VW G60 Gear Oil which is what my Dealer here told me to put in and it shifts smoother now but still has the same issue. I also did the Shifter Cable adjustment to see if that was the problem but that only made it easier to shift but it still got stuck.
Basically what happens is when driving I shift into 3rd gear and when I go to shift out of 3rd it comes out of gear but it's like it hits a brick wall and will not go into the home position. I was hoping the adjustment and new oil would work but it hasn't done anything.
Golf IV / Jetta IV :: 2001 - Transmission Will Occasionally Not Shift Into 4th Gear
Got a 2001 Jetta 2L automatic 200k miles with gremlins. possibly multiple unrelated problems. First problem that presented is that the transmission will occasionally not shift into 4th gear. I discovered that if I stop the engine, then restart it, it will again return to normal operation, hence the thought that it is electrical. After a year or so of this, second problem pops up: the engine will die while the car is driving, or some times idling at a light. I've also noticed that the interior lights flicker somewhat in intensity when on and the engine is operating, so there could definitely be a grounding issue somewhere. I have heard that the ECU/ECM connectors could become corroded, but haven't yet dug into it to look. Any guesses as to where to begin?
View 2 RepliesFord - Explorer :: 2001 - Small Leaks Coming From Transmission And Front Differential Gasket
I purchased my first truck 2 weeks ago private sale a 2001 Explorer Sport Trac 4v4 4.0L. I noticed it had small leaks coming from transmission and front differential gaskets (the diff is silicone) but the oil levels remain fine. Within days I heard a loud hum coming from the engine for 10 seconds then immediately after i was slowing down for a speed bump and my truck tried to stall and since that point it was riding very rough at low speed/idle and sometimes giving it gas seemed to just kill it. Next day a check engine light comes on and I get it checked It was Bank 1 running lean and B1155 (Output shaft speed signal) which concerned me from what I found it is located by the transmission oil filter which has the leak.
A few more days later I broke down on the side of the road, the alternator had died and killed the battery, I replaced the alternator and belt, replaced the 6 spark plugs, 3 of which i removed way to easily with my hands and all 6 had an incorrect gap. Initially the car was still rough but now with the new plugs it is drivable but still a little weird on startup and idle and a little bit of the shakes around 60-65mph and seems to be over actively shifting soon as i let off the gas even a little bit. Today I had the check engine light assessed again, now Bank 1 and Bank 2 are lean, still have the B1155 as well as a new C1676 (Battery pack voltage out of range) which light research said it could be ABS module or it could be a false code from being jumped days prior and that code wont clear on its own.
Golf IV / Jetta IV :: Surge / Stutter - No Boost Leaks
Replaced my coil packs/sparks, and just got around to changing my N75 valve today. The rough idle issue is gone but now when I go WOT it boosts but goes from 15psi-12-13-12-14-12...etc. I've checked and there are no boost leaks. I do have a CEL saying I need a new bank 1 sensor 1 Oxygen sensor. If it is that, why did this problem arise as soon as I changed the N75 valve and wasn't present earlier?
View 1 RepliesGolf IV / Jetta IV :: Multiple Coolant Leaks In Three Months
My 2004 1.8T GTI is having a weird issue. It's had 3 coolant leaks in the past 3 months. Every time I get one leak fixed it goes leak free for a couple weeks, but then a new leak pops up in a new place.
First leak was a cracked coolant bottle. Second was a flange near the bottle on passenger side. The newest leak is on the driver side. Car hasn't ever overheated.
Golf IV / Jetta IV :: 2001 - Transmission Shifting At High Revs At Times
My auto transmission is sticky at times. This usually happens after an hour of driving doesn't happen all the time. The gears start to change at high Rpms like 5 to 6k. It's real annoying. Otherwise the tranny is very smooth , like butter . Shifts into all gears.
View 2 RepliesGolf IV / Jetta IV :: 2001 - How To Access The Transmission Input Shaft Seal
I'm trying to get to the manual transmission input shaft seal on my 01 GTI w/12V VR6. I've removed the 3 bolts surrounding the input shaft but the metal shroud underneath the 3 bolts seems to be adhered tightly in place. You can see the 3 bolt holes and metal shroud in this photo: [URL]
Am I on the right track in trying to remove that shroud? If so, how do I loosen it?
Golf IV / Jetta IV :: 2001 - Transmission Has Hard Time Going Into 1st And Reverse / Rough Idle
2001 VW Jetta 1.8t automatic.
Transmission has a hard time going into 1st and reverse. Also some times hits hard going into third. I have a CEL for a vehicle speed sensor? Was wondering if it's not the VSS but maybe one of the other tranny sensors?
Separate question. Same car has a rough idle issue. Occasionally stalls but intermittently runs normal always has a low idle around 600 rpm. I have a code for an injector on cylinder three.
VSS code : P0725 - engine speed sensor circuit malfunction
Injector code : P0203 - injector circuit open cyl 3
Passat (B5) :: Starter Fluid To Find Vacuum Leaks
A friend of mine today told me a good way to find vaccum leaks with starter fluid. Lightly spray it over the vacuum lines on an idling engine until the idle speeds up. Where you were spraying when it sped up is where the leak is. Be careful as it is very flammable. [IMG] [URL] .....
View 2 RepliesGolf IV / Jetta IV :: Starter Won't Crank / Not Even A Click
Removed battery cables and held together to clear ECU ... Re-attached and no crank not even a click ...
View 3 RepliesGolf IV / Jetta IV :: Starter Grinding Noise
So I have the well known starter grinding noise since I bought the car six months ago. Is there really any danger to the flywheel or the starter itself not fixing this? I don't mean from a purist point of view, of course it's not good. I don't really care about the noise. Does it maybe 1 out of 3 starts in the cold. Are things really getting chewed up, or it's really no big deal.
View 13 RepliesGolf IV / Jetta IV :: Starter Clicks Once But No Startup
I've bought new starter cleaned starter contacts battery contacts jumped it bypassed the ignition and relay but taking a wire and touching the positive to the signal wire..used jumper cables as a direct ground to to the starter the torque converter spins so it's not seased...I don't understand what could possibly be stopping this thing...it's just one click like the starter is jumping out but not enough power to turn... 2002 Jetta 1.8t auto
View 18 RepliesGolf IV / Jetta IV :: Starter Spinning / Engine Does Not Firing At All
My wife was driving our Jetta (08 2.0T DSG) this afternoon when it cut off on her. She eased off onto the side of the road and tried to refire, but the starter was just spinning. I popped the hood and the oil was extremely low, so I thought that might be the issue. I put in a quart of oil and everything looked good...tried to start the car, and it's not firing at all. I disconnected the battery hoping that resetting the car would work, but the car just wouldn't turn over or fire...it's like the starter is spinning itself and everything else connected to the belt, but not the motor. I had to leave it about 30 miles away, but plan on going back out in the morning to mess around with it.
View 2 Replies