Golf IV / Jetta IV :: 2001 - Won't Shift Smoothly
I have a 2001 Jetta 1.8t. O2j trans obviously. It shifts not so smothly in any gear but stays in all gears fine. When the car is up to temp and the trans is warm it grinds going into second. It's ONLY when the car is warm. Shifts perfectly fine before that. And it's only when I shift from first into second. I can go from third to second just fine and I can pull out of first put into third without letting go of clutch and put it into second without a grind. I've changed the oil to Lucus oil 70w/90 gl-4 rated and there was absolutely no change.
View 1 RepliesGolf IV / Jetta IV :: 2001 2.0 Won't Shift Into High Gear
My buddies Jetta won't shift into high gear. I am going to take a look at it this saturday to find more out.
View 4 RepliesGolf IV / Jetta IV :: 2001 - Shifter Won't Shift The Transmission All The Way?
I have an 01 Jetta, 2.0L, 5 Speed manual transmission.
The issue seems to be that the shifter wont shift the transmission "all the way" into 1st, 3rd, and 5th gear. When I shift into the gears that are forward on the shifter, it will go into gear, but then the shifter (in the car) moves back toward neutral a little. I can drive in 1st no problem, but in 3rd and 5th some weird stuff happens...
While driving, when I shift from second to third I have to keep my hand on the shifter otherwise I get kicked out of gear. Also, when I drive on the highway, I periodically get kicked out of 5th gear if I don't keep my hand on the shifter (usually, when I let off the gas).
Anyway, being that I've fixed many problems on many cars by searching forums and google, I spent the last few days trying to figure out the problem by looking through the forums, but I have yet to find a solution. I tried adjusting the shift linkage using the method described in the dieselgeek video on youtube [URL] ...., but it didn't work. I'm pretty certain it's not the shifter bushings because i have almost no play in the shifter in neutral.
I had someone cycle through the gears while I watched under the hood, and its clear that the cable that controls the forward and back part of the shifting is not pulling back far enough on the counterweight on the transmission. (When shifting into 1st, 3rd, and 5th.) When the shifter puts the tranny into these gears I can still move the counterweight on the tranny further than the shifter will pull in in the same direction.I tried adjusting the linkage to compensate for this, but the cable is as far into the cable end as it will go...
Golf IV / Jetta IV :: 2001 Doesn't Want To Shift Into 4th (slips In And Out)
My 2001 1.8T Jetta doesn't want to shift into 4th (slips in and out) when the operating temp gets to normal value. It looks like I will need a full overhaul. Of course the overhaul price is worth more than than car is worth. I may be able to get a tranny from an 03 Jetta with a 2.0 in it. I think it bolt on but are there any other issues? According to this site the ratios are similar -not sure what R&P is.
[URL] ....
I will be getting a tranny shop to do the work. Is this something that is doable?
Golf IV / Jetta IV :: 2001 - Transmission Will Occasionally Not Shift Into 4th Gear
Got a 2001 Jetta 2L automatic 200k miles with gremlins. possibly multiple unrelated problems. First problem that presented is that the transmission will occasionally not shift into 4th gear. I discovered that if I stop the engine, then restart it, it will again return to normal operation, hence the thought that it is electrical. After a year or so of this, second problem pops up: the engine will die while the car is driving, or some times idling at a light. I've also noticed that the interior lights flicker somewhat in intensity when on and the engine is operating, so there could definitely be a grounding issue somewhere. I have heard that the ECU/ECM connectors could become corroded, but haven't yet dug into it to look. Any guesses as to where to begin?
View 2 RepliesGolf IV / Jetta IV :: 2001 VR6 Hard To Shift And Cannot Get Into Any Gear When Engine Running
01 jetta vr6 5 speed. Alright so earlier today I pulled out the driveway. (Hard) was in 1st gear around 3 or 4 grand and I stomped it. Got to 6 grand and hit 2nd. Took 2nd to 6 grand and let of around 60 mph. After that I short shifted into 3rd, 4th, then 5th. I noticed going into fith was hard. Had kinda rev match to get it. I stayed in 5th till I got to my destination roughly 4 miles. When I came back out to leave I had a hell of a time getting it into reverse. On my way home it was extremely hard to shift and now when the car is running I cant get it into any gear. This is what I did.
Car shifts fine with car off.
Car will not shift with engine running.
When started in gear with clutch depressed I can still let the clutch out and stall the car.
When starting car while in gear with the clutch NOT DEPRESSED the car jumps forward.
I can figure it out ove tried re adjusting the linkage. Nothing.
Golf IV / Jetta IV :: Can't Shift Into Second Gear After Shift Linkage Done
So i was trying to adjust my freinds shift linkage on his o2j and i got a little ahead of myself and forgot to put the shift tower in the home position before making the adjustment. after i realized you can't shift into second ( either that or 2nd and 4th are extremely close together now and feel like the same gear ). I try to get it in home position even with the cables off ( did this for experimentation) and still wouldn't go into home position...meh. still have all the other gears including reverse .
View 4 RepliesGolf IV / Jetta IV :: 2003 - Transmission Will Shift From 1st To 2nd But Won't Shift To 3rd
My 03 Jetta is having transmission trouble. It will shift from 1st to 2nd but wont shift to 3rd. It is an automatic 2.0.
View 10 RepliesGolf IV / Jetta IV :: Car Won't Shift Out Of Park When Turned On
I have a 2002 Golf GLS. About a week ago I was driving around like a raped ape and spilled some soda down the gear shifter. I cleaned it up and didn't think anything of it. Recently, now that it's been getting colder out I found that my car doesn't want to shift out of park when I turn it on. No worries, just did the ("Step on the brake pedal five times,
hold the brake pedal down, start the car, shut off the car, turn the key a quarter turn, move the shift lever between neutral & drive, start the car and then you can move it into drive.") and shifted into gear fine.
[URL]............................
Golf IV / Jetta IV :: 2003 Won't Shift Until Warmed Up
I just recently bought a 03 Jetta and it doesn't shift until it is warmed up, once warmed up it runs great. I was told it needed a transmission change but when taking it to Aamco they said it needed a valve body. I read that it could be the solenoids that are causing the issue. Should I replace the whole valve body or just the solenoids? What is the main components in the valve body?
View 2 RepliesGolf IV / Jetta IV :: Clutch Never Came Back Up When Trying To Shift
So i was driving and I went to shift and my clutch never came back up. Long story short after searching the forums i think it might be my slave cylinder and throwout bearing. There was a puddle of fluid under the car.
I was planning on using this DIY : [URL] ....
Just wondering if all i have to do is follow this up to step 48 and replace the throwout bearing and slave cylinder.
Golf IV / Jetta IV :: Won't Shift Out Of First Gear When Cold?
Started noticing an issue with my trans awhile ago, the other day it stopped shifting out of first when cold. It's a 1.8T auto 5 speed tiptronic, it's the Jatco 09A. I know the shifting problem is the solenoids and it doesn't look that hard to swap them out. The trans shop said it looks like there is slippage on gears 2-4 and the fluid is toast. Looking at replacing or rebuilding, shop said 4-5 grand, how easy would it be to swap in a used trans? And what kind of issues would I be looking at?
View 1 RepliesGolf IV / Jetta IV :: Trans Will Not Shift From 3rd To 4th Gear
I replaced the old auto trans that was slipping in my 2000 golf with a same year auto trans from a beetle. The beetle had 115k miles and the PO toasted the 1.8t. I replaced the TCM also and when I finished the install I took it out for a drive this afternoon and when I shift it into drive it starts out in 3rd. It will manually shift through the gears but it will not shift from 3rd to 4th. Could I have left something unhooked? Is this a solenoid issue?
View 10 RepliesGolf IV / Jetta IV :: Hard To Shift Into 1st And Reverse When Car Is Hot
Over the past few weeks, my car (2002 Golf 2.0L) has gotten really hard to shift into 1st and reverse (has crunched once or twice), but only when the car is hot, after driving it for a little while. When this happens, and I try to shift into reverse, the shifter feels really "sticky" and can get kind of stuck in the depressed position near reverse.
I bled the hydraulic system and replaced the slave cylinder, but no dice. I haven't noticed any clutch slipping. Shop wants to replace the whole clutch. Is this the right answer?
Golf IV / Jetta IV :: Code P0785 - Car Sometimes Not Shift From 3rd To 4th Gear
When I'm driving, the Jetta will sometimes not shift from 3rd to 4th gear, so I just turn of the car a start it and it seems to work, but eventually does it again. Once it is in 3rd gear it does not downshift and stays in 3rd even when stopped. The trouble code is P0785 which is the shift/timing solenoid. Not sure if I need to get a new part or which solenoid to get. Also I cannot figure out where this solenoid is actually located or what it looks like.
View 1 RepliesGolf IV / Jetta IV :: 2002 GTI / Manual Shift - No Reverse
When you sit in the car and put it in reverse it wont go in.
If you stick your hand in the engine compartment, push down on the golf club looking linkage and shift it into reverse it goes right in and you are able to back up the car.
So my question is which linkage may need fixing or replacing or adjustment. The shifter linkage in the car? the linkage on the golf club thing or any parts in between.
Golf IV / Jetta IV :: 04 - Tranny Wouldn't Shift Out Of First Gear
Okay so I bought this car and a week later tranny wouldn't shift out of first when I would slow down or at least it would take a min. I would hit 4or 5 grand then it would jolt me back. It wouldn't do it every time though. I bought it to go to college drove it the 900 miles on the highway and had no problems except right before I left town but then fine. All I did was change the tranny fluid before I left which I can confidently say I don't think has been changed before that. stunk bad bud no metal.
Alright now I'll go jump in the car to go to class and it will not leave first. If I put it in the manual mode it thinks it's in third but clearly if in doing 15 mph at 4000 rpm that's not the case. It doesn't do it every time. Kinda hit or miss. After driving for a min it usually shifts. Sometimes I make it the two miles without it shifting though. Also sometimes It will shift but once I slow down it won't shift out of first again.
I have seen a code for torque management since I bought the car. The check engine light is on now but I haven't seen the torque code since I change the MassES. that's not to say it's not still there. I used a different handheld computer for the check engine light the last time I did it and I could have missed it because I was unfamiliar with it. I have put a mass airflow sensor, battery, alternator, and changed the tranny fluid since I have owned the car. drained 3L of tranny fluid and put 3L back in. Oh and the last time I checked the light it said lean in bank 1 but I was assuming that was an unrelated issue.
Golf IV / Jetta IV :: Hard To Shift When Car Warms Up On Hot Days
When it gets hot outside and the car warms up (15 mins or so of highway driving), the stick gets extremely hard to move and it doesn't go back to center when it's out of gear. So I could push it all the way left or right without putting it in a gear, and it would stay there, it wouldn't pop back to the center like it should. It becomes really annoying and difficult to drive because it gets so stiff and hard to move, what could be causing the problem? I've already adjusted the shift linkage and that didn't work.
View 3 RepliesGolf IV / Jetta IV :: 2003 - Hard To Shift Into Gears
My 03 Gli 24v manual transmission has been acting up lately. First it started to get a little difficult to shift into gears about a week ago. Then tonight i was driving through a parking lot in 2nd, and after i came to a stop i tried to put it back in to first and it would not go into gear. As i was trying to get it into 1st i could tell it was grabbing a little bit and the car was inching forward.
I got it to a parking spot and starting reading about other peoples issues, one i read said they were able to get it to move after pumping the clutch some. After trying that i was able to get it into gear and drive it to my parents. Looked at my brake fluid and its full. Took it for a test drive around the neighborhood and it was shifting fine at first then started getting a little difficult to shift again. I tried taking off in 6th and it stalled. I tried going from 1st around 3k-4k rmps to 6th and it was still driving with very little lugging. My clutch feels and is still stiff, not loose at all. I do have to go all the way to the floor with the clutch before im able to shift
Finally to my questions. Could my clutch be going bad? Could my cables need adjusting? Something I read about a pressure plate maybe?