GTI 337/20th Anniversary :: Temp Light Is Flashing But Car Does Not Overheat
I have a 20th GTI and the Temp light is flashing. The car does not overheat, and runs normally. The temp gauge acts normally.
View 6 RepliesChevrolet - Monte Carlo :: 2003 - Engine Fan Malfunction / Starting To Overheat
The engine fan in my 2003 MC SS doesn't seem to be working and the car is starting to overheat. The other fan, which I think is the A/C fan seems to be working okay. I know nothing about cars and before I take this to a mechanic. I do not want to go somewhere and get totally ripped off. So it would be nice if I appear to know what I am talking about... when I take it to the mechanic.
View 2 RepliesGTI 337/20th Anniversary :: Not Starting On First Crank
My 20th has been having a starting issue and I've honestly tried everything I can think of, this issue just randomly started one day the car will not start on first crank it starts second or third every time. After it's started and running it runs perfect its just getting it started.
I've replaced the Crankshaft sensor, Camshaft sensor, Coolant temp sensor, the car has had new injectors (440) installed about two months ago, has the new battery. My father is a mechanic and he has also tried everything he knows to do and we asked our local VW specialist and he said to try the things we have already did. Ran codes when the issue started and it only came up with camshaft sensor and we replaced that and cleared the code still nothing. Once this issue started we parked the car and started troubleshooting and the oil was low? even though I know before the issue started it was good and full. the car has a stage two intronic tune, 440 injectors, secondary air delete and all and a shaved and partially tucked bay, there are no resistors is the open unused sensors.
GTI 337/20th Anniversary :: GLI 1.8T Starting Noise Like A Diesel
I just picked up my new GLI the other day. It sounds like a diesel when I start it up. It only has 200 miles so far, so I'm not sure if it's because it hasn't been broken in. My dad has a brand new A4 1.8T with about as many miles as my GLI and it doesn't sound anything like mine when its started up. I don't remember other GLI's sounding like mine when I test drove them. Is this normal or am I being oversensative?
View 20 RepliesGTI 337/20th Anniversary :: Clutch Is Starting To Slip
Noticed recently that my clutch is starting to slip. It only seems to happen when I'm cruising in 6th and floor it. When the boost spikes, the revs will shoot up ~750 rpm and then settle back down before the car starts to pull. It is chipped Unitronic Stage 2 with some other bolt-ons.
What I'm wondering is, should I just drive it like this until it really starts to go, or should I replace it now? And what are my options for a new clutch? I don't want to big turbo this car, so the most it could get is a few more bolt-ons. I'd like a stock feeling clutch.
GTI 337/20th Anniversary :: Not Starting - Replaced Starter / Battery
A few weeks ago, my battery died, got a new one, ran fine for a week. Then wanted to go to work a a few days ago, turn the key and heard nothing, took the starter out, got a new one and put it in (used-but I took it apart and it looked fine) Once I put that in was excited to have my car back, but same thing, not even a sound coming from the starter, doesn't even try. Thought it might be a fuse problem, checked everyone that might have to do with the engine...and they all looked fine.
Something with the relays perhaps? I haven't checked those yet. A ground issue? I'm so lost right now.
GTI 337/20th Anniversary :: Hard Starting In Hot Weather (over 90 Degrees)
So I did a couple searches and found a couple MK3's with this issue however I did not find anything for the MK4.
The last couple days, we have been over 90 degrees in the afternoon. My black 03 20th 1.8t sits on the side of the road at work in the direct sun from 12:30 (lunch) until 5pm when I get off.
The last 2 days, when I have gone to start it, it cranks and cranks for 5-8 seconds before it starts to catch and finally stumbles to life. Once its running, everything feels fine. If I turn the car off and restart it, it starts fine.
In the mornings in the garage, evenings when its cooler or leaving for lunch before the day has gotten really hot, it starts fine. It only seems to be affected after sitting in the direct afternoon heat for a few hours.
I have read vapor lock, dying crank position sensor, ignition issues, starter etc. I am going to rule out the starter as the car cranks like normal. It simply does not fire.
Grand AM :: Cannot Drive More Than 5 Minutes Without It Starting To Overheat
Having issues with there Grand AM over heating? I've got a 99 Grand AM SE , & it's over heating. I cannot drive it more then 5 minutes without it starting to over heat. I'm getting no where fast with this vehicle.
View 2 RepliesGTI 337/20th Anniversary :: 1.8T Engine Noise At Low RPM
So, it's been 8 years with this awesome car. Still enjoying every day. Over the past year or so, I've noticed my engine get gradually louder and louder. By that I mean, the overall engine noise at low RPM. It's a mechanical kind of noise. Clicking, etc. The engine has 101,500 miles on it.
For the past 2 days now, this noise has gotten dramatically louder. I've tried to capture it in the video below. Might have to listen with headphones. The noise is most noticeable at idle and then goes away after about 2000 RPM. You'll see. What this might be? Btw, there is no reduction in the performance of the car.
[URL] ......
GTI 337/20th Anniversary :: Engine Code AWP?
What is the factory AWP 20th AE boost pressure?
View 6 RepliesGTI 337/20th Anniversary :: Low Engine Temperature
I know it has to do with the thermostat and coolant sensor but I am trying to hold off on doing it till the winter cause my car is at 68k so i will be doing the timing belt. It would be easier to install them all at once. is it bad to keep driving the car with this problem?
View 9 RepliesGTI 337/20th Anniversary :: Check Engine Light Came On
I chipped my car with unitronics stage 2 3 weeks ago. 300 mile later the check engine came on. 42 DD down 3" to 2.5 cb no DV yet.
View 6 RepliesGTI 337/20th Anniversary :: Misfire With Engine Code
So i have a 2004.5 gli 6spd that had two of the coils go bad and had a serious misfire with engine code and all car didnt want to even move. So i got this fixed made it about a mile down the road and it had a cylinder 3 misfire took it back had third coil replaced and all new plugs put it. Got the car back it ran fine until i hit about 4000 rpm under heavy boost it misfires but no flashing cel like before and the car still runs but cold start warmed up it misfires under boost
View 20 RepliesGTI 337/20th Anniversary :: Smoke Coming From The Engine
Car was started for the first time after the radiator was flushed and new coolant was put on it. The car was just jumped and charged after was brought from a copart auction. Now my brother said that everything looks smooth, no xxxmas tree in the dashboard, idle is steady, engine sounds good.
Now here comes the thing, the temps of oil and water are at a proper level. When he steps on the gas pedal a few seconds later there is some sort of smoke coming out from the back of the engine (exhaust manifold, turbo, intercooler stock pipes from the SMIC) My question is cause he's not a mechanic and he will arrive tomorrow. crack manifold, shot turbo or some leak in the hoses?
aBtw the car has 105k miles.
GTI 337/20th Anniversary :: Check Engine And ABS Light Came On
So recently my check engine and abs light came on. I went to go get it checked out and it was the MAF censor. And here recently i noticed the airbag light came on. I replaced the MAF today, and the abs went away but check engine is still on due to the downpipe. And the airbag light is also on. Why it might have came on?
View 8 RepliesGTI 337/20th Anniversary :: 2003 VW GLI Engine Running Hot
So, for about two weeks now, my engine has been running hot. I have a 2003 Volkswagen Jetta VR6, the cat converter and the MAF Sensor have both been replaced w/in the past year. Oh yeah, also replaced my thermostat within the past 2 years. Trying to trouble shoot the problem. I had the radiator flushed the other day. No engine light is currently on. It doesn't happen to me in the morning (due to the cold ass weather) but towards the end of my stretch home from work (all interstate) the temp gauge goes past the 190 degree mark. Doesn't reach the red, however its still too hot for comfort.
View 9 RepliesGTI 337/20th Anniversary :: Boost Is Not Going Over 10 Psi And Engine Cutting Out
So I just installed a boost gauge. Vacuum line is running off the fuel pressure regulator. My boost is now not going over 10 psi and the engine is cutting out. It kinda feels like the dv isn't holding psi but just always open. The car is a 05 gli with intake and exhaust.
Also the car seems to be running alright at below 2000 rpm and it just starts to cut out when it should be making boost. And I'm pretty sure this car is reprogrammed because yesterday when I finished the boost gauge install it was running at19 psi.
GTI 337/20th Anniversary :: Engine Code For 2004.5 GLI 1.8t?
whats the engine code for the 04.5 gli 1.8t???
View 5 RepliesGTI 337/20th Anniversary :: Receiving Awp Engine Codes During Ecu Swap
I am trying to swap my ecu for a chipped one out of an 04 gti 1.8. Both awp engine codes. I programmed the immobilized and the car doesn't start. I am thinking it has the ignition kill feature but the guy who sold it to me doesn't think it does. i was just wondering if the ecu's are compatible even though the part number is different.
View 8 Replies