GTI 337/20th Anniversary :: Distinct Rattling Noise From Somewhere In Engine Bay
I just picked up a 20th and it seems when it's running and parked i get this very distinct rattling noise from somewhere in my engine bay. I go to put the clutch down and it stops, as soon as i lay off the clutch it comes back (almost humming) could it maybe be the trans?
View 8 RepliesGTI 337/20th Anniversary :: Weird Rattling Noise When Engine Braking
I recently installed my 3" GHL exhaust along with my stage 1 BFI dogbone and I recently noticed a very faint rattle when I am engine braking. I can only hear it when there's no cars around or when its quite. but i cant figure it out. (I still have the stock exhaust heat shield in from the cat back so I am not ruling that out as a possibility).
View 1 RepliesGTI 337/20th Anniversary :: High Pitched Whirring Sound And Rattling Coming From Engine Bay
My 337 didn't pass inspection (control arms, inner tie rod, no cat because the guy I bought it from sucked etc) but it sat for probably 3 weeks and I just sold my other car (I was planning on using that $2000 to get the 337 to pass inspection) but I just drove the VW down the street for the first time and it's making some scary sounds.
Basically when I give it throttle there's a high pitched whirring sound and something keeps rattling that sounds like its coming from the engine bay. I'm really freaked out, I'm leaving in two months because I'm transferring to a new college and I need this thing to run perfectly.
It's also shifting a little strangely and if you don't shift absolutely perfectly then it starts to rattle (not like you're about to stall but something completely different) I can't take it to a VW dealer or anything because I'm way over the 15 days past a failed inspection and I can't afford a tow.
GTI 337/20th Anniversary :: 2002 - Engine Shutting Off Randomly When Cruising In 5th Gear
I have an '02 337 GTI, Chipped but the previous owner don't know what chip is installed
Anyways, lately if I'm just cruising around the city in 5th, or on the highway, the engine will shut off completely. Electrical still on, battery light and all that jazz does not come on unless the RPMs go all the way down, then I have to actually start the car up again. Takes alot longer to crank afterwards.
Sometimes I will be driving and it happens, but I keep my foot down on the throttle, and just wait and engine will kick back in hard as hell!
GTI 337/20th Anniversary :: Rattling Sometimes When Idle
I just put on a magnaflow cat-back exhaust and sometimes when i idle i have a rattle and sometimes it will not rattle. I went under it and shook all around to see if anything was hitting but there was nothing i could see. What could it be?
View 4 RepliesGTI 337/20th Anniversary :: Coolant Light Came On / Car Has Been Rattling
Had it done at 87K years ago. Coolant light came on car had been rattling. Parked and coolant came leaking out. At 157K now was gonna replace belt at 167k, that's 80k since the last job. My guy says had I drove it further would be looking at a new 1.8t.
Does this sound about right to you since it's been 70k since that last timing water pump job. Why didn't the car overheat? Chipped at 40k with apr and very conservative driver. I suppose it just depends on too many variables why the job needs to be done 10k before I originally planned to do it.
GTI 337/20th Anniversary :: Exhaust Is Hitting And Rattling The Bend
I recently just put a set of b&g rs's on the car and now it appears that my 3'' exhaust is hitting and rattling/striking the bend that goes over the rear axle, I know I can raise the car and keep it from doing such but that kinda defeats the purpose of lowering the car, Just trying to see if there is something out there, like polyurethane hangers or something along those line that might alleviate the problem.
View 20 RepliesGTI 337/20th Anniversary :: Exhaust Rattling Against The Heat Shield
I have a 42 DD tb exhaust. And so far I've used a 3" exhaust clamp over the last hanger (after the muffler) which raised the exhaust all the way up against the heatshield, eliminating the rattle over the rear axle beam. But the exhaust was rattling against the heatshield.
So I bought 15 ft of exhaust wrap and wrapped the section that comes in contact with the heatshield. It worked a bit but it still rattles a little! I hate this rattling! How to get rid of the rattling? Should I just use more exhaust wrap?
GTI 337/20th Anniversary :: Rattling Sound Coming Below The Handbrake
I've been trying to locate the source of the noise that is coming under the car. Specifically below the handbrake. Like something is lose, took the car to a shop to have it inspected, checked the exhaust, and there was nothing there, all clamps there and screws.
It only happens most of the time when the car is cold and it feels all the way from the hand brake to the stick shift. Sounds like a rattle like something is about to go off from the car but I cant imagine what could be. Couldn't replicate the noise at the shop, only when you are driving and the car is in inclined it rattles really bad until the car gets back to the normal position. Specifically in 1st gear .
GTI 337/20th Anniversary :: Front End Noisy - Brake Pads Rattling
Having trouble with front brake pads rattling? About a month ago, I replaced pads - rotors - caliper pins on my 20th GLI. I know these cars ride a bit stiff but it sounds like my front end is about to fall off. All brake parts were torqued to spec - I've gone through all T25/T30 torx front end screws etc and I just can't find the rattle??? This has only started within the last few days. Any other places to check for obvious loose bolts etc?
View 15 RepliesGTI 337/20th Anniversary :: Rattling Noise Coming From Middle Of Car / Resonator
So I really don't drive my car much during the year since I'm away at college. Once I got back home a couple weeks ago and drove my 20th, i heard a rattle coming from the middle of the car. Jacked it up and starting banging around. The sound is coming from my resonator. Its either the clamp that is busted or the resonator itself. I have to get in closer to see which it is. But I do have a few questions. If I just cut the resonator cut off and weld a straight pipe to that will it be much louder. I have a stock 20th and I'm not really looking for a loud exhaust at the moment. Is it much louder without the resonator? I know if you put a straight pipe in place of the muffler it is MUCH louder so I'm just curious.
View 1 RepliesGTI 337/20th Anniversary :: Rattling Noise From Hand Brake Release Button?
Having this problem where the button to release the hand brake rattles constantly while driving? The only thing I can think is to replace the spring in it, but Idon't know how difficult that would be. Otherwise my only other thoughts are to find something thing enough that I can slide into it and hope it doesn't ever jam it up.
View 3 RepliesGTI 337/20th Anniversary :: Grinding Or Rattling Noise At Start Up That Stops After Few Seconds - Code PO411?
I have the po411 code, not sure which problem it is but when I first start the car it sounds awful like almost a grinding or rattling noise then stops after a few seconds.
View 3 RepliesGTI 337/20th Anniversary :: GLI Will Not Go Into 1st Gear
Driving home from work, I was about 5 minutes from home, got to a light only to not be able to go into 1st. I popped it into 2nd and drove home like that pretty much. Car will let me get into reverse and all other gears.
I can put the shifter towards first but it doesn't fully go in and when I gave it gas it would let me start to creep and then grind a little and pop out.
Heres a pic for your click .....
GTI 337/20th Anniversary :: First And Second Gear Won't Work
I have a problem with my 20th anniversary gti. My 1st and 2nd gear won't work. Every other gear works fine, the gears never grind before or any unusually noise. I was pulling off my driveway and they just stop working. Even when the car it's on I can move my shifter to 1st and 2nd without the clutch and nothing happens.
View 3 RepliesGTI 337/20th Anniversary :: No Reverse In First And Third Gear
So I get in the car to move my car this morning and I can't get the car into 1st gear. It turns out I can't get the car into reverse, 1st gear, or even 3rd gear. It feels like something is blocking me from even approaching those gears, however the others (2,4,5,&6) seem to be fine.
View 14 RepliesGTI 337/20th Anniversary :: Grinds A Little Bit When Going Into Third Gear From Second
I bought a rebuilt trans from a fellow vortex member a little over a month ago. I had it installed and ever since then when I am getting on it going from second to third it grinds a little bit going into third gear. It only does this when i get on it, but when im just cruising its fine. Could the shift linkage just need aligned? Or what else could it be?
View 5 RepliesGTI 337/20th Anniversary :: Refused To Go In 1st Gear?
As of two days ago my car ust refused to go into 1st gear. I know that it is a common occurrence with the 02j and shift fork, but 2nd works perfectly, so how could it be that shift fork?
View 16 RepliesGTI 337/20th Anniversary :: GLI Hard To Put Into 1st Gear
So I've been noticing that my GLi is tough to put into first gear sometimes. I feel almost like I have to jam it in place and hold it there, it doesn't just click in. Could this be the shifter cable ends or the cables themselves? Its weird... its only ever been a problem for 1st gear though.
View 15 Replies