Ford Super Duty (1999-2016) :: Coolant Smell After Driving / Radiator Leak
About a week ago I began smelling coolant after driving my 2012 F350 6.7. Yesterday I noticed a small amount of coolant on the ground and decided to take it to the dealer. As soon as I told the Service Manager what was going on he said......"You need to leave it......there is no doubt in my mind it needs a radiator". They pressure tested and and sure enough it does. He said they are replacing about 2-3 a month but there is no recall.
Here is where it gets fun. Apparently radiators fall off at 36,000 miles and are not included in the 100,000 Power Train Warranty. It gets better. The Radiator is on national back order for 5-6 weeks.
Ford Super Duty (1999-2016) :: Bump Stops Rotted And Fell Off?
My Bump Stops have completely dry rotted and fell off the truck. I have an 08 with a 2 inch leveling kit, I already did all the body bushings, as they disintegrated as well. Should I bother replacing them? I highly doubt that I would ever bottom out that bad that I would need them?
If I should replace them, then where did u guy's get them and should I go with the Neoprene like I did with the body bushings?
[URL]
Ford Super Duty (1999-2016) :: Air Conditioner Clutch Fell Off / Bolt Lost
My 6.0 lost a bolt that holds the AC clutch and the clutch fell off. It's probably on some highway making people have flats. Is it possible to buy a replacement clutch and NOT remove the OEM pulley, just take the parts off the replacement clutch and put them on the old AC and existing pulley?
View 9 RepliesFord Super Duty (1999-2016) :: Pin Fell Out Of Automatic Trans Gear Selector
The other day I had a metal pin fall out from under my dash and hit me on the foot (only reason I would have know if fell out till I clean the truck)
Ever since then the gear selector handle for my transmission has become sloppy and when I go to turn off the truck, I have to hold the arm up to turn key off all the way. I have looked to try and find where it goes and cannot find the location. I have also looked at a blown up parts diagram and cannot find it. Where it goes?
2002 F250 SD V10 with auto...
Ford Super Duty (1999-2016) :: 2006 F250 - Rear View Mirror Fell Off
I have a 2006 F250 and the other morning I came out and found the rear view mirror laying on the cab floor. No biggie, I'll just glue it back on. Then I noticed the small black decal looking thing on the inside of the windshield. My question is, does this have to come off in order to re-install the mirror with standard Permatex mirror adhesive, or do I just put adhesive on top of it? Also, is there a different, specific adhesive used here that won't crack the windshield 2 weeks from now, like I read. Took a closer look and realized they used a thin adhesive patch to attach the mirror. I'll get one from the dealer.
View 3 RepliesFord Super Duty (1999-2016) :: Burning Brakes Smell After A 30 Minute Drive / One Of Pistons Fell Apart Of Caliper
I pulled into my driveway after a 30 minute drive and smelled burning brakes. The right front was the culprit so I took a garden hose and cooled it down. The next day I remove the caliper and one of the pistons fell apart. So I need a new caliper and trying to decide if I buy after market or go with Motorcraft? I think the rotor, caliper, and pads are original since I the rotor is stamped Ford and the caliper bracket has TRW and Ford markings.
View 12 RepliesFord Super Duty (1999-2016) :: 2008 V10 - Timing Chain Broken Or Fell Off On The Passenger Side Bank
Today I either broke timing chain or it fell off on the passenger side bank of my 08 F250 V10. Put a hole in valve cover. What to expect for repairs. Is this engine Zero tolerance.. unsure if I should expect bent valves or not and just how far I may have to go with this.. best way to test. I have a bore scope camera and mechanical abilities.
View 14 RepliesFord Super Duty (1999-2016) :: 2006 - Antifreeze In Radiator Without Mixing?
OK to put the Motorcraft Anti-freeze in my radiator straight without mixing?
View 6 RepliesFord Super Duty (1999-2016) :: Trans Cooler Lines In Radiator
I have Russell fittings and hose coming to hook up my new 6.0 cooler into my 5.4 powered truck. Have a question on the fittings on the bottom of the radiator for the cooler lines, first what is the 3/8" line called? Is it a double flare or what? And second question the female end that's into the plastic tank with the hex head does that unscrew or is it made into the tank? Trying to figure this out so I can overnight two adapters so I can get rid of the fugly hard line completely and use Russell braided line throughout my install
View 14 RepliesFord Super Duty (1999-2016) :: 2001 - Trans Fluid In Radiator?
I have a 2001 Ford F250 V10 crew cab, I am getting trans fluid in radiator. i have had radiator replaced. it was good for about 3 months.
View 6 RepliesFord Super Duty (1999-2016) :: Increased Temps - Clogged Radiator?
My radiator has been leaking very little for some time and it is stock after 250k so im sure it is plugged....my engine has been running 202 .... My tranny only goes over 200 while towing...otherwise if is under 190
View 14 RepliesFord Super Duty (1999-2016) :: Hose Coming Through Radiator Fan Shroud?
Just picked up my truck from the dealer after a trans flush. While it was there I had them replace both windshield wiper nozzles. They called and told me the hoses needed to be replaced as well--- OKAY fine do it.
Come home and decided to "make sure" the trans fluid was at the correct level.
Open the hood to discover a loose black hose approximately 1/4" or so in diameter coming out of the radiator shroud directly at center of the top. The end of the hose was somewhat towards the passenger side battery.
I figured okay the tech probably just left my old windshield wiper hose on top of the motor and forgot to discard it...
I follow the hose and it appears to go in between the rubber seal for the shroud and the plastic housing. I looked back behind the fan and can see the hose twirled around an aluminum or stainless steel pipe coming up just in front of the fan but behind the numerous condensers...
MY question is two fold: Should this hose be here, or is it indeed the wiper hose that got sucked into the fan?
if it is supposed to be here, what does the end that was leaning towards the passenger battery connect to? it certainly appears to have been previously connected to something whether the washer or some other barbed fitting....
Ford Super Duty (1999-2016) :: 2001 F250 - Hole In Radiator
2001 f-250 7.3 radiator. If you ever have to change the water pump think about removing the radiator first. Looks like they are paper thin and very easy to damage. Must be a problem since the local parts house carrys them in stock. Just thinking.
View 1 RepliesFord Super Duty (1999-2016) :: Transmission Cooling Line Leaking - New Radiator?
My transmission cooling line is leaking. It leaks where it connects to the radiator. Im not sure how I go about removing the connection from the radiator. It is tough to tell from the rust on the connection weather or not I can use a wrench on it. I have read here that there are cooling lines in this part of the radiator for the transmission. Is it serviceable or do I need a new radiator. I dont want to touch it until I know what I'm looking at.
05 F250 5.4L 4x4
[URL]......
Ford Super Duty (1999-2016) :: 2008 - Radiator Isolator Bushing Removal?
2008 6.4L F250 Crew. I just recently had a new radiator installed while the cab was off for an oil cooler change. I noticed that my lower front bushings are gone and need to be replaced.
I thought it would be an easy, pull the bolts drop the lower bushing and reinstall. Looks like they don't come out so easily. Is there a trick to getting the lower mounts/bushings separated from the uppers?
Ford Super Duty (1999-2016) :: 2004 - Transmission Line From Bottom Radiator Leaking?
So this is my major problem, leaving for a camping trip tomorrow afternoon. It's just 15 miles away, easy flat drive. What has happened is the trans line coming out of the bottom of radiator is leaking next to the fitting about an 1/8 ' out, So I can't cut off and splice in hose for the trip. I worked on it for about an hour, rusted on, tried some heat and now have some PB Blast on it and all I am doing is starting to round off the head of fitting. Is there any way to bypass this just to get the camper to campground and then get to a shop while we are gone Don't care if I have to splice and cut, will get new lines later.
2004 f250SD 5.4 83000miles
Ford Super Duty (1999-2016) :: 2008 F250 - Coolant Leak Above Lower Radiator Hose
I'm trying to troubleshoot a leak on my 08' F250 with a 6.4 powerstroke. It's been dripping coolant when cold pretty aggressively. Once the truck heats up, the coolant leak seems to mostly go away.
Here's a picture of the drip, it's marked by a dart, so you can see the location from the top (second pic). The radiator house connection around the engine seems dry.
Pic from Top ....
What's hidden here that could be causing the leak?
Ford Super Duty (1999-2016) :: Radiator Noise - Humming Real Loud Like Its Relieving Pressure
I have a 2011 F-350 diesel crew cab dealer said I had a radiator leak so they replaced it now after I shut truck off it starts humming real loud like its relieving pressure my temps and everything else seems to be ok...
View 1 RepliesFord Super Duty (1999-2016) :: 2013 F250 - Small Leak In Engine Side Radiator?
The truck has 64k miles and has developed a small leak on the engine side of the radiator with no apparent damage. There is no variation on the pressure test and the dealer was able to find the very small leak with dye in the system. It has lowered by about 3/4 of a gallon of coolant over the last couple of months. There are no visible signs of a leak but you smell the coolant when you stop the truck.
View 11 Replies