Ford Super Duty (1999-2016) :: Fuel Gauge Slow To Respond After Fill Up
Yesterday went to fill up ($4.05 a gallon geezz!) and noticed that after getting back into the cab, the fuel gauge still showed almost empty. So after yelling a few expletives, I looked again and noticed the gauge starting to make it's way up the dial. It took almost 30 min. before it showed almost full. I'm not sure what the problem is, as the gauge seems to still function. I don't drive the truck much as I use it as a tow vehicle. However, I do try and take it for a spin about 3-4 times a month just to exercise it. I was wondering if the fuel has started to gel and that is the reason for the slow fuel gauge response. Should I add a fuel conditioner/cleaner now that I have a full tank?
View 9 RepliesFord Super Duty (1999-2016) :: 2002 F350 Shutting Down When Slow Down For A Stop Sign
I have a 2002 F350 with the 7.3 diesel. I have had this truck since it had 30K miles on it and it now had 90K miles. It has been trouble free minus new pads and batteries. I recently changed the fuel filter and used a Donaldson filter. In the last week while driving the truck just mysteriously shuts off when I slow down for a stop sign. The only lights on the dash is the red battery light, and it fires right back up. I believe it has the original CPS in it as I have never changed it. Do you think this is the CPS going out or something else? I was wondering if the Donaldson fuel filter has anything to do with it?
View 5 RepliesFord Super Duty (1999-2016) :: 2000 F350 - Fuel Spills Out During Fill Up
My 2000 F-350 during fill-ups will spill out about a quart or more of gas from under the truck somewhere right when the filler clicks off. Also can smell fuel sometimes when between half and full tank. 2000 f350 SWR crew-cab 4x4, 5.4 gas.
View 3 RepliesFord Super Duty (1999-2016) :: How To Remove Windshield Washer Nozzle
2011 F250 with hood mounted windshield washer nozzle. How do I remove the nozzle? In a campground with basic tools.
View 6 RepliesFord Super Duty (1999-2016) :: 2001 - Won't Fill Up With Gas?
so long story short a few weeks ago my truck would start clicking the pump. Every 3 seconds it will click and stop. Tried different pumps, upside down, nothing works. Now it won't even go in like something is stuck in the fuel neck and its spitting gas back out. I stuck a wire and it went down pretty far. I see people saying the evap lines but I have no clue where they are.
View 9 RepliesFord Super Duty (1999-2016) :: 2001 - Gas Tank Won't Fill Up?
I had a new Fuel Pump put in the cheaper plastic one into my 2001 F250 5.4 with a 112,000 miles.
Problem I am having since getting it back is when filling the gas tank up it will shut the pump off at 3/4 tank. I then have to sit there playing the squeezing game to get more gas in. The vent line looks fine no kinks in it and the tank looks level so what could be the issue causing me this headache?
Ford Super Duty (1999-2016) :: DEF Warning Came On / Cannot Fill Tank
Just got back from a 2500 mile trip and the 800 mile DEF warning came on. Went to a DEF pump but it just filled the neck. Went to another DEF pump, same . Went home and used a Ford DEF jug with the Ford spout. It still will not go in. If I squeeze the jug, I can hear a little bit dropping into the tank.
The vent and fill pipes are not kinked. The vent hole in the fill tube looks clear. I washed off the top of the tank since there is a vent there.
Still no fill. I do not have a bore scope to look in the fill tube. I ran a 1/2 inch flexible hose down the fill tube until it stopped. Still no fill.
Ford Super Duty (1999-2016) :: Stripped HPOP Fill Plug
I have stripped my HPOP fill plug. Any experience on getting one out? And a part # for a new one?
View 10 RepliesFord Super Duty (1999-2016) :: 2005 F350 - Radio Shutting Off By Its Self
2005 F-350 diesel... When I first got it the radio was shutting off by its self, my 02 did the same thing so I wasn't to worried about it.
But things have advanced , radio shuts off , windows wont work? Goes on and off at will , does not seem to be road bump related as they go off and on when Im not moving.
Will stay off until I restart truck sometimes and other times it only stays off for a few minutes.
Ford Super Duty (1999-2016) :: Fan / Heater Stays On After Shutting Truck Off?
So when i shut my truck off the heater will occasional keep blowing. it also has a string of LED type lights inside the dash by the speedometer, those also stay on sometimes. It's happened before and we thought we had it fixed. We had a whole new fuse box put in and some kind of module. What could be the problem? I am thinking maybe some kind of wiring?
View 9 RepliesFord Super Duty (1999-2016) :: Shutting Off Low Tire Pressure Message?
How to shut off the Low Tire Pressure message? My tires are at 65-70 pounds and the message still shows up at every start up.
View 6 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Easier Way To Fill Rear End?
Is there an easier way to fill the rear end on my '01 f250? I have a gadget with a valve on it with a length of tubing that you put on the bottle, but you still have to snake the bottle up through the chassis.
View 14 RepliesFord Super Duty (1999-2016) :: Hard To Fill Up At The Pump After Canister Replacement
My 06 f250 with the 5.4 has a hard time being filled at the pump. So I followed the tsb and replaced the carbon canister, filter box and solenoid with the kit from my local ford dealer. Before it was impossible to get fuel in. Now it is way better but I have to fill it up with the gas nozzle upside down in order to fill at full speed. I have blown out the vent with compressed air.
View 6 RepliesFord Super Duty (1999-2016) :: 2003 - Hesitation / Truck Shutting Off Randomly
I have a 03 F250 5.4 4x4 auto, last year I had a problem with the truck shutting off randomly. So after doing all the dumb stuff and research I ended up concluding that the FP relay was acting up and my understanding is that, it is located in the fuse block. So not wanting to replace it I wired up my own relay next to the safety switch in the passenger side kick panel and it has been fine ever since. I did put a new pump in it (Cali emissions) Now to present day-
Over the past month my truck would have a slight hesitation problem when accelerating on the highway/up grade. The issue was it would go away for a while when you would shut the truck off and be good for a while. Well then it started happening all the time.
I knew I was do for a tune up (215,000) so I did all the plugs, COP's, fuel filter and a PM. It got a lot better but was still there at the top end. So after doing a lot of research I found a lot of people having the same issues, so for testing purposes I cut the CAT out and installed a section of flex pipe. (Iwill be installing the cat back in)
So last night I take it out and its even worse...I went don to my buddy's place and hooked up a Versus and got no codes at all, no misfires on the counter..absolutely nothing. So I did what I should have done in the beginning and duct taped a fuel pressure gauge to the windshield and took off.
At idle I have 30 or so PSI, and when it was fine it would stay around that, when it started acting up it would drop to 5-2psi under load and go back to 30 or so PSI at idle. The other thing is now I only have 1/4 tank of gas.
What I am concluding is that the pump is getting hot and weak, because when I had a full fuel tank it was better and now I have less fuel to cool the pump and it is happening faster. Should I just throw another new pump in it? Or go after a voltage problem to the pump?
Ford Super Duty (1999-2016) :: Code V0100 - Cluster Gauge Keeps Shutting Off?
I keep getting this v0100 code in my tuner. Says lost communication with pcm/ecm? Bit truck doesnt die. Still runs but the rpms goes way higher before turbo kicks in?? What keeps causing this? Also my cluster gauge keeps shutting off and on so the cluster is going out. I will be replacing it. Do these two problems go hand in hand?
View 4 RepliesFord Super Duty (1999-2016) :: Front Axle Sits Out / Gas Pump Always Shutting Off When Filling Up
Just wondering if its normal that my front axle sits out about 1 1/2 inches further on the drivers side than the passenger, also gas pump always shutting off when filling up...
View 6 RepliesFord Super Duty (1999-2016) :: Dome Light Stays On For A Bit Before Shutting Off After Closing The Door
Had this issue for a while, but it doesn't seem to cause a problem. It's more of a curiosity than anything... Most of the time, the dome light operates as usual- close the door and the light stays on for a bit before shutting off. But about a quarter of the time, the light goes off immediately after the door is shut. It's done this the entire time I've owned the truck (about 2-1/2 years). Why?
View 1 RepliesFord Super Duty (1999-2016) :: Door Ajar Light Staying On And Radio Not Shutting Off Upon Exiting The Truck
Truck '02 F250 SuperCab - I was having an issue with the door ajar light staying on and the radio not shutting off upon exiting the truck. After having no luck with the WD-40 fix, I replaced the door switch sensor on the driver's side door and disconnected the negative battery cable for a few minutes (maybe 5-10).
Problem solved or so I thought...a few days later (approximately 5) the door ajar light came back on and the radio did not shut off. I disconnected the negative cable and sure enough that fixed it...again The problem is that every few days I have to go thru this. I'm not sure if it's related or not, but the CD player has started giving me "error reading disc" on even brand new CD's.
Ford Super Duty (1999-2016) :: 2008 F250 Has Been Slow Going Uphill
Last few months my 08 F250 has been slow going up hills. The fluid checks out ok and it shifts fine.
It just seems to take forever to get up hills. Has 124K....
Also has a huge hissing noise thats RPM dependent on the passenger side. Will make the sound in neutral just revving.