Ford Super Duty (1999-2016) :: Medium Pitched Grinding - Gear Noise?
I have a 2016 Superduty. I was sitting still in the drive, engine running and Tx in Park. Following the manual's instructions, I put the Tx in Neutral, turned the 4x4 to 4x4 high and then to 4x4 low. I then pulled the to engage the electric locking rear diff. I put the Tx in Reverse with the foot still on the brake and then as I gradually lifted pressure off the brake pedal (I think) and started creeping, I heard a medium pitched grinding; not so much like spur, helical, or hypoid teeth grinding; more like cog gears. I stopped the truck and disengaged everything. Later in the day while on dirt I put her through her paces proper and all was fine. I guess I'd like to just know, given that this is my first 4x4 with so much electric shifting, what actually happened. If you are pretty sure of what I heard but are puzzled by the sequence, I could have the order of things a bit off as my brain was just about wiped completely free of all memory when I heard that sound so I may have the order of what I actually did, wrong.
View 4 RepliesFord Super Duty (1999-2016) :: 2000 F350 V10 Backfire On Startup
Started my truck this morning. 2000 F350, V10, 153000 on the clock. Immediately sounded like a shotgun went off under the hood, now it sounds like it's running a cutoff exhaust. Had a tiny manifold tick prior to this, but can it backfire hard enough to crack/destroy the manifold?
View 5 RepliesFord Super Duty (1999-2016) :: 2005 F350 Will Not Downshift With Pedal Pressed To Floor At Medium Speeds
Recently my F350 has failed to downshift when the accelerator pedal is pressed to the floor to speed up in traffic. It will usually happen when traveling at speeds in the 30's-40's. It will shift quickly at slower speeds. I have a scan guage on it all the time and it is not throwing any codes.
The transmission has only been serviced by the dealer; last done about 24000 miles ago. No leaks or low fluids/no burned smells. Stock setup with no heavy towing use. Currently at 228000+ miles, this is the first issue with the transmission assuming I am looking at the right area for the cause.
2005 F350 XLT 4WD
Ford Super Duty (1999-2016) :: 1997 - Gets Hot Under Acceleration?
Okay here we go. 97 F250 HD with 460 and e4od.160,000 miles, MSD 8.5 Super Conductors, Mallory 6A, KNN air filter, Transmission Flushed new filter including inline and Mercon V. New Hedman Headers and Y-pipe into Cat delete stock exhaust. New front fuel pump and filter. New 38 gallon conversion rear tank and fuel pump. Air pump delete. New IAC valve. Timing set to stock. oil just changed Valvoline high mileage full synthetic, KNN oil filter , Lucas Full Synthetic oil Stabilizer, Injectors cleaned on truck with Berrymans, Entire cooling system has been thoroughly flushed. New 4 core radiator and 180 degree high-flow thermostat, new belts, new water pump, new hoses, new 13lb rad cap.
So here's the problem. It gets hot under acceleration. If I do a 0 - 80 mile per hour run the temperature gauge will go from a steady "O" reading to the high side of "R" (of course I am referring to the word displayed "NORMAL").. if I am Towing 0 - 65 mile per hour run will put the Gage to a solid "A" Reading then drop quickly once the throttle is lifted. It can idle all day long with the AC on and it will not come above the"O". I would normally think that this has caused buy a stuck thermostat however the thermostat is new and a stuck thermostat while running easy, would most likely cause the lowest temperature to be around the letter "N" on the gauge. I have no condensation coming out of the exhaust whatsoever except what is normally associated with first start up on a full exhaust system. I have no additional pressure or bubbling in the radiator. I have no foreign fluid in the radiator either from oil or transmission fluid being introduced. And I have no coolant contaminants in the oil at all which would normally indicate a head gasket or intake issues. This is definitely a concern because Towing an RV in hilly conditions will allow the gauge to climb rapidly. The bigger the hill the longer and harder the acceleration the higher the temperature will climb. I am stumped.
Ford Super Duty (1999-2016) :: 1999 F350 V10 - Loss Of Power / No Acceleration Over 2500 RPMs
Truck sat for 1 1/2 years. Changed filter and put in 15 gallons of fuel. Had maybe 1/2 gallon old fuel in tank. MAYBE. Fixed fuel line because it wasnt getting fuel and it fired right up and idles great.
Truck has no acceleration over 2500 (or so) RPMs but idles fine. This is depending on how hard you push the pedal of course.
If you drive the truck normally like a grandmother it seems to be ok. As long as you dont need a passing gear or need to accelerate more than 1/4 pedal
If you try to push the pedal to get the next higher gear it will sometimes hit the gear fine. IF you floor the truck it will totally lose acceleration. Then the truck will run like crap even slow for a good while. But then it will clear up for the low end. Then you can drive it normally. Then when I think I can test the upper end I get the same thing again.
Ford Super Duty (1999-2016) :: 2012 - Overheating But Only Under Acceleration
My Son drives a 2012 6.7, and just recently it started overheating bu only under acceleration? It runs cool while idling, and once you reach the desired speed, it cools back down, but under acceleration it overheats? We've checked the obvious (coolant etc...), but can't figure out what it would do this only under acceleration?
View 6 RepliesFord Super Duty (1999-2016) :: 2005 - Acceleration Is Very Sluggish
My '05 5.4 SD CCLB is running badly. 95k mikes. Plugs done 6 months ago. Acceleration is very sluggish. Sometimes uphill from a stop is almost impossible.
No CEL codes other than an intermittent coolant temp gauge that spikes but resets as soon as I shut down and restart.
When it is bogging the exhaust note changes - almost like there is a blockage. It is almost a booming sound. I would like to test to see if the cat is clogged. I have a vacuum gauge but need to find a vacuum source after the throttle body to do so. If I pull out the O2 sensors ( to allow the exhaust pressure to exit ) would the truck run badly because the O2 sensors were not functioning?
If it turns out that the converter is bad. Can I just eliminate the cats? I do not need emissions testing here in PA because the truck is so heavy. But I don't know if eliminating the cats will cause other problems.
Ford Super Duty (1999-2016) :: Truck Lost Acceleration When Got Up To About 35 MPH
I drive a 2000 F250 XL Super Cab LB 2WD 7.3 Powerstroke. i drive like a grandpa. No rompin on the accelerator or anything. I was leaving the house got up to about 35mph and the truck lost acceleration. Motor still running fine. I coasted onto a side road. Put it in park, killed it, started it again and same thing. Will not go into drive at all. However will go into reverse just fine and accelerate in reverse. Desperately wanting my favorite means of transportation back!
View 14 RepliesFord Super Duty (1999-2016) :: F250 XLT - Acceleration Sluggish With A/C On
2016 F250SD XLT CC 4X4...13K miles... Now with it being blazing hot in Florida I have been running windows up and a/c on. Beginning to notice the truck is not accelerating the same with the a/c on as it does with the a/c off. It seems like it sluggish till it gets to a certain RPMs then you feel it kick in and somewhat take off. Is this normal?
View 7 RepliesFord Super Duty (1999-2016) :: 2003 - Missing Under Acceleration
2003 6.0 is acting crazy again. Has new ICP, IPR, oil discharge tube, and hpop. It cranks right up but one time you crank it and all the gauges work correctly, especially the fuel gauge. The engine will idle perfect but when you accelerate it has a dead miss. May crank like that 2 to 4 times. Then you crank it and it runs like crap, and the gauges won't work, the fuel gauge goes past E and the light comes on. As long as that happens it runs terrible, but when the gauges are working it idles great but has a miss under acceleration! It was running fine, then just went nuts!
View 4 RepliesFord Super Duty (1999-2016) :: 2007 F350 - Whistle On Acceleration
2007 F-350 4X4 King Ranch... I have the 6.0 diesel. I am on the road to Houston, Tilden and San Antonio TX, and I am noticing a whistle on acceleration. I can change the tone by how hard I push down on the accelerator. I thought it was a radio issue and turned the radio off and got no change. Turned the a/c off, no change. Down hill or coasting, nothing.
View 3 RepliesFord Super Duty (1999-2016) :: Clunk At Acceleration From A Dead Stop
I have a 2002 F-250 7.3 Powerstroke 4x4. My truck has developed a "clunk" for lack of a better term when accelerating from a dead stop. It is not a shudder as it only happens once within a few seconds of depressing the accelerator and then goes away until the next time I stop moving.
It feels like either something in the drivetrain is not engaging right away, or something is releasing, like a stuck caliper or something. From the way it feels and what I've read so far about the TC/Trans, I'm assuming it is something worn in the drive-shaft/rear diff.
But it needs brakes badly (already have all new rotors & pads ready to install) so maybe a caliper is sticking when depressed and then popping loose under initial acceleration? I think this is unlikely but possible.
Ford Super Duty (1999-2016) :: Vacuum Leak Under Dash Under Acceleration
I have recently developed a vacuum leak on my 2002 F-350 V-10 under the passenger side of the dash. It is only audible when I am accelerating moderately to heavily or when the truck downshifts going up a hill. None of the vehicles HVAC or ESOF functions seem to be affected by this leak from what I can tell, but it's rather annoying to listen to this loud sucking noise every time I hit the gas moderately hard such as climbing a hill or merging onto the freeway. I don't know how I could search for this leak since it only happens when I'm driving and accelerating and not at a stop. What might be going on or where I should begin my search?
View 2 RepliesFord Super Duty (1999-2016) :: 2015 - Vibration On Soft Acceleration?
I just purchased a new 2015 F250 SC 8ft bed 4X4 2 weeks ago. I am experiencing a vibration on soft acceleration (I feel it through the floor), by that I mean when there is power going through the driveway, not coasting. I plan on making an appointment with the dealer. New F250 SC LB 4x4 truck.
View 8 RepliesFord Super Duty (1999-2016) :: Battery Light Comes On During Hard Acceleration
I started to notice my battery light comes on during a hard acceleration. So I have been keeping track of it. When the rpm's hit 3200 and above the light comes on bright but never at any other time. I put a volt meter on it and I have 13.4 volts at an idle, as the engine revs up the voltage climes to 13.9 then when it hits the 3200 mark voltage drops right off to 12.4. It seems like a regulator issue to me. The parts store says my 5.4 has an external regulator is that so or is it built right into the alternator?
View 7 RepliesFord Super Duty (1999-2016) :: 2002 V10 - Buzzing Noise On Acceleration
I had a buzzing noise on acceleration so today I cut all the heat shields off the exhaust system and also bent the bottom of the transmission inspection plate toward the front of the motor. It cured the buzzing noise but when I started the truck up there was a new rattle kind of sound, so I looked and found my y pipe is cracked where the passenger side pipe comes down off the manifold and connects to the pipe that goes to the cat converter.
I don't want to get a whole new y pipe could I order the spd Y pipe and that should work out right? it should be cheaper than a whole new y pipe aswell. I filled up the crack (it cracked 360) with weld but it was tissue paper so I would like to fix it before winter. I also still need to do my passenger side manifold studs and weld a new muffler because I found the rear half of mine is rotted off lol so I will probably do this all at one time.
I'm probably just going to pull everything manifolds and back off the truck, I have a feeling theres a bunch of rust sitting in front of the cat or muffler making the new rattling noise. Also in all my years of wrenching I have never figured out an easy way to get the exhaust off those rubber hangers, I always try to spray wd40 in there to get them to slide easy but always end up tearing them while trying to get them off.
Ford Super Duty (1999-2016) :: 2006 F250 - Fan Clutch Roaring On Acceleration
I have a 06 6.0 with 340000 miles on it believe it or not still pulls great. The problem is my clutch fan keeps roaring when I press the gas it's extremely loud all my gauges are fine so the truck isn't overheating? Also not a bad fan clutch I wasted 300 bucks on that and it's still doing the same thing.
View 6 RepliesFord Super Duty (1999-2016) :: 2015 F350 - Hesitates Momentarily On Acceleration?
2015 F-350 diesel purchased in Sept 2014. When moving slowly such as turning a corner and I have to let up on the accelerator momentarily, when I press down again there is nothing for an unsettling period of time, maybe 2 seconds, as though the engine died, but it didn't and it always comes back. Is there a firmware programming update for this?
View 3 RepliesFord Super Duty (1999-2016) :: 2011 F250 - Jerking / Lunging During Acceleration
I have a 2011 F250 Lariat, 6.2L V8. The past couple months i have noticed truck jerking/lunging during acceleration in the mornings usually between leaving the house and getting on the highway. Over the last 2 weeks the problem has progressed and seems to last longer. I have tried fuel injector cleaner with no success. This morning was the worst so far and after all this time i finally saw the maintenance "wrench" pop up on the on dash.
This was good news to me hoping that a local shop could read the code. However, when i dropped off my daughter and started back up the "wrench" went away. After warming up the problem seems to go away. This morning was so severe i lost speed and felt like the engine was going to stall.
I feel like this is related to the fuel system (injectors/pump/filter) but also haven't changed the spark plugs yet. My truck has 72,000 miles and otherwise is in good shape. How I should move forward?