Ford Super Duty (1999-2016) :: Metal Bearing Type Noise When Started Up A Hill
I have a 2001 F350 with a 7.3 diesel and automatic trans. I purchased it about 100,000 miles ago. It is all stock as far as I know. The mileage on it was about 14-15 on the road and I decided to put a chip in it. I was somewhat leary of putting too much power to this old of a rig. I put a TS Performance chip in it. It seems to have more power. I am towing a 30 ft. Gulfstream Seahawk I think around 10,000 lbs. When I started up a hill it made a different noise like a screeching noise when I pushed it. When I back off a bit the noise goes away. When I put it back to stock setting the noise is not there just the normal downshift and increased RPM. Not sure how to describe the noise but sounds like a metal bearing type noise. I get the same rush of air or what ever that sound is when it changes back to a higher gear. Is this sound normal or what might it be. It sounds normal when not pressing it.
View 6 RepliesFord Super Duty (1999-2016) :: Rapid Clicking Type Of Noise Out Of Vents When AC Is Turned On
So my truck is making a rapid clicking type of noise out of the vents when the ac is turned on.
The noise sounds like a thin piece of paper getting hit by a fan (that's what I hear) It started during this past winter when I would cold start the truck. but as the heater warmed up it went away completely. well now since its warm out I am running the ac now, and it blows cold but doesn't have a lot of volume to it it seems. but being the problem was when the truck was cold running the cold ac makes the noise permanent.
The blend door acutator is working as should (i can only assume the blend door is ok) the vacuum lines are good and vacuum signal is good.
Ford Super Duty (1999-2016) :: Turn Signal Flasher Type Noise Coming From Under The Dash
I'm having an electrical issue that is driving me nuts. I have an '01 F-250 Super Duty that I just put a new battery in today. The truck normally runs great, I drive it to work everyday with no issues. Today, there is a noise coming from under the dash that sounds like the turn signal flasher, and the clock on my radio flashes in time with the noise from under the dash. All my lights are working ok, and all the idiot lights come on as usual when I put the key in the ignition and turn it to the on position. However, my truck won't start. It won't even turn over. I get nothing but a dead switch when I turn it to the start position. The starter solenoid doesn't even click. Like I said, yesterday everything was just fine. I knew my battery was going bad (6 years old), so I changed it.
View 4 RepliesFord Super Duty (1999-2016) :: 2004 - Swapping Mirrors To Square Type One?
I am wanting to swap out my mirrors from the adjustable "egg-shaped" superduty on my 2004 to the newer style square type mirrors. I like the newer style mirrors, because i drive an F-550 at work and it has those mirrors on it and it makes towing and seeing in general a heck of a lot better and easier. The question is, Is this conversion possible? Will the newer style mirrors fit on an older truck like mine?
View 14 RepliesFord Super Duty (1999-2016) :: 2000 F250 - Manual Transmission Noise When First Started
I am new to being an F250 owner. Just recently purchased a 2000 F250 SD 4x4 with the 5.4 and a 5 speed trans. Got a pretty good deal on it, because I knew some work had to be put into it, and do plan on dropping the trans. Currently, if the truck has been sitting for a little bit, not cool, but not running for a little bit, when I start it, whether it is in gear or in neutral, there is a noise coming from what seems to be the clutch area.
After a couple minutes of driving, this noise goes away and all sounds as it should. A little bit of researching turned up the possibility of the throw out bearing being bad, however, I found other posts online that doubt this. Another symptom that I assume is connected is that if I go to put it in reverse at 0mph from neutral, it grinds.
In order to go into reverse, I have to press in the clutch, put it in first, then put it in reverse, at which point it goes in no problem. I had already planned on replacing the clutch because it seems to me that would be the logical choice as to where the problem originates, so no issue there. But perhaps I'm wrong??
Ford Super Duty (1999-2016) :: Slight Squealing Noise From Pulley When Truck Started
So a few months ago I would occasionally hear what appeared to be a slight squealing noise from a pulley when I started my truck. It was very intermittent, so I didn't think much of it.
After a few weeks, I realized I was only hearing it on colder mornings - it would also go away rather quickly. I bought a mechanic's stethoscope, and figured I'd get to it on a slow day.
Today, I finally broke out the scope and tried to figure out the source. Didn't really find any pulleys making noise, and I did notice that when I shut the truck off, it squeaks for a second or two as it comes to a complete stop.
My dream of finding a bad pulley or perhaps a power steering pump was crushed. I had hoped to do a little Easter wrenching and put this noise to rest. So, I did what any good mechanic would do - I Googled the issue.
I'm reading that it could be the belt. Certainly wouldn't bother me too much as that is an easy fix. The belt isn't too old - about 4 years and 20 - 30K on it.
I took a few pics of the belt and can take a video of start/stop ....
Ford Super Duty (1999-2016) :: Horn Just Starts Blowing By Itself
I have 2002 F250SD, The horn just starts blowing by itself. Bump the horn switch and it stops for a couple of weeks. I've looked at the wires to the fuse box and no wires shorting out the horn wire. I read some very old posts but nothing conclusive was ever decided on, just a lot of guessing. The horn switch has always been sensitive.
Somebody said the air bag is warming up in the sun and expanding causing the horn to blow. Somebody said the horn relay, but in 55 years of working on trucks, I have never had a horn relay act like that. I'm told the horn relay is built in the back of the fuse box and it all has to be replaced. Some say the clock switch. I don't know what that is or where it is. I guess inside the steering wheel. Is it hard to replace?
Where do I go from here....
Ford Super Duty (1999-2016) :: Horn Goes Off In Middle Of Night
In my new to me 99 F250 SD ,Started today off with switch sticking in drivers door causing dome light to be on when doors closed... oiled the crap out of the door mechanism and it started working. Later in the night I look out side notice the radio lights on with no key. Can't figure it out so pulled the face off and figure I'll look at it tomorrow and go to bed.
1:30 am the horns blaring! I open drivers door and horn stops, close it and it goes off I ended up pulling the batt cable so I could go back in the house. I did search for info with no sure real causes. Seems like it has happened to others as well.. BTW it did start raining before the radio stayed on. Thinking water in the dash or fuse panel. But it doesn't explain door switch problems I had earlier. Maybe 2 separate problems. This will be fun! Not!
Ford Super Duty (1999-2016) :: F250 - Horn Won't Shut Off?
Okay so I have an e99 f250 7.3 the problem all started went I hit a puddle the other day. My horn started going crazy and wouldn't shut off so I had to pull the fuse and relay. After that I found another problem, all my dash lights,headlights and running lights will not turn off unless I pull the battery terminals, it does not matter which way the headlight switch is it can be on or off and they stay on. I did find it though if I pull the negative terminals and put them back on the lights stay off if I turn the switch on and try to turn the lights back off with the switch they stay stuck on again untill I pull the terminals what could be the problem I've looked at every fuse and can't find the probelm.
View 8 RepliesFord Super Duty (1999-2016) :: F350 Horn Blowing By Itself
Sitting in the house, heard a horn blowing and ran outside to find my F350's horn was blowing. When I pushed on the horn button on the steering wheel it quit. Couple of hours later, it started blowing again. Pushed the horn button to make it stop and removed the fuse so it would not start blowing again. Did a forum search, but didn't have any luck. Short in steering wheel?
View 14 RepliesFord Super Duty (1999-2016) :: No Horn When Parked Randomly?
My brothers truck has unusual problem of when parked the horn randomly comes on and stays on? Why?
View 4 RepliesFord Super Duty (1999-2016) :: 2000 - No Cruise / Horn Alarming?
Been searching but can't find a clue. I replaced my steering gear box. Went fine, but after starting back up. My alarm goes off, my cruise or horn doesn't work and my air bag is giving a code 32.
Is there a ground wire or something I could of missed when installing the gear box?
Ford Super Duty (1999-2016) :: 2001 F250 V10 - Horn Honking When Off
I have a 2001 F250 V10, 150,000 miles, gas, very basic truck (no power windows, no cruise, no security system, no power locks, etc). In it's previous life, it was an IDOT highway truck I purchased at auction in 2005. Used primarily to pull horse trailer, less than 2000 miles per year. Stored under cover when not in use. Windshield leaks very little, but generally not used when raining.
Last week, 9pm, horn starts blaring solid tone. I go out and unlock door, open door, it stops. I start truck, still fine, turn truck off. Lock door, close door, starts blaring again. I reopen door, leave unlocked, close door, then get intermittent beeps. I reopen door, disconnect battery because it's late, I was going out of town, and felt bad for my neighbors. Just got back in town, too afraid to reconnect battery and not be home in case it starts going off again. I had last used the truck about 36 hours before the horn started going off, weather about 70 degrees overnight.
I've read other threads, but can't find one that fits (I have no cruise, kept out of rain, not freezing cold, not diesel).
Ford Super Duty (1999-2016) :: Horn And Cruise Control Not Working
I have a 2001 F-250 SD XLT with the ABS light on, cruise control doesnt work and the horn only works with the key out. The codes for the ABS is no signal input from the left and right front wheel sensors. No problem there. Also my speedo stops or jumps when I press the horn button while driving down the road. When I quit pressing the horn button the speedo works fine. So after looking over the posts on cruise control, etc. Does the rear speed sensor have anything to do with the cruise, horn not working? All fuses are good so I am thinking the cruise control switch on the master cylinder or a short in the steering wheel column or my ignition switch. What do you all think?
View 7 RepliesFord Super Duty (1999-2016) :: 2012 F550 - Horn Not Working / No Power
I am trying to figure out where the relay would be when i look online for the map of the relay box under the hood it says nothing of a horn relay. I don't have a key fob for the doors to unlock so I wouldn't think its tied to the computer. Should mention nothing happens when you hit the horn also fuse is fine. No power at the actual horn when i hit the steering wheel(horn)....
View 8 RepliesFord Super Duty (1999-2016) :: Custom Horn Setup - Gauge Harness?
My custom air horn setup. I have a schematic here and and need info whether my drawing is right or not. I also need some help on what gauge wiring, what amp fuse and what relays.
View 2 RepliesFord Super Duty (1999-2016) :: 2003 F450 - Horn Not Working / Relay Location
Attempting to debug the Horn not working on my 2003 Ford F450, The fuse is good (shown as #37 15 amps) so next I would like to check the Horn relay.
View 5 RepliesFord Super Duty (1999-2016) :: Lost Cruise Control And Horn After Replacing Steering Box
So i was replacing my power steering box after the shaft broke on it and apparently i didn't have my steering wheel back to exact center. after putting everything back together and started to drive down the road a very thin flat wiring harness broke and got tangled around my steering column under the plastics of the column. I then lost my horn and my cruise control and i believe my airbag. I pulled the wiring harness out and it was very long with two white plugs on either end. I'm not sure what this part is called or where i would be able to buy another one. And if there's some kind of instructions on how or where this harness plugs into sense it was ripped out.
2000 ford f-350 lariat 7.3l diesel....
Ford Super Duty (1999-2016) :: 2005 F250 - Horn Blowing Intermittently / Constantly
The other day I was checking out my parking aids (they kept saying something was behind me when there was nothing there) and the horn just started blowing by itself, constant on until I disconnected the batteries. Been a few days and just got back to working on it, checked the horn switch in the airbag and it is functioning fine. Hooked the batteries back up, no horn, but after a couple of minutes I start getting little honks out of it, then locked on again. Where I should go from here? Truck was parked, switch off, engine off today when I hooked the batteries up. Never started it or turned the key on.
View 6 Replies