Ford Super Duty (1999-2016) :: Vibration / Slight Growl At 50 - 55 Speeds
New, 2 month old 2015 CC, gas 4x4 with standard bed. At 50-55 I have a rolling vibration, or it can even be explained as a slight growl. Seems worse since I upgraded to 285/75/18 Toyo AT's and new wheels. If i speed up to about 60, goes away. If I pop it down to 5th gear, it seems to go away, however, I need to try this a few more times to make certain.
View 9 RepliesFord Super Duty (1999-2016) :: Nasty Growl And Vibration When Turning
Ok here is whats happening. 2003 F250. When the axle gets warm and I turn a slight left or right turn I get a bad vibration and Growl from the rear axle. I have changed the fluid and added two bottles of the Ford Limited slip fluid but the problem just keeps getting worse. The question is am I looking at limited slip clutches or do I have bigger issues. I had new Ford 4:30 gears installed about 3 years ago and don't know if they put new clutch pack in or not,
View 13 RepliesFord Super Duty (1999-2016) :: 2006 - Vibration / Jumps Up And Down At Certain Speeds
I am yet another sufferer of the 40mph vibration syndrome I commonly read about on this site. I have had my 2006 f350 club cab sd to the dealership about 7 times for this, and now am being told it is a normal characteristic of this truck. They have replaced wheels, tires, vibration machine analyzed, put on a vibration damper, etc., but nothing fixes the problem. It has done it since the day I drove it home.
How many of you out there are upset about their super duty that jumps up and down at certain speeds? Lately, my dealership has had my truck more than me. From the amount of posts I see about this problem, I am certainly not alone. Ford is now trying to brush me under the carpet, yet I have a truck with a built in gyrator that is totally unacceptable. The truck now has about 20,000 miles of bouncy misery on it, and it isn't getting better.
Ford Super Duty (1999-2016) :: 2003 F250 - Vibration At All Speeds And In Rear End When Braking
My 2003 Ford F250 V10 seems to have a vibration, sometimes at all speeds and sometimes at freeway speeds. I replaced front hub assemblies and ball joints and rear calipers last year. When braking i have a vibration in rear as well, which I think is from uneven rotor but can it be causing my vibration? Also sometimes I can smell hot brakes from the rear.
View 2 RepliesFord F-150 (2009-2014) :: Loud Noise From Under Truck When Driving At Slower Speeds
Whenever Im driving at slower speeds - parking lots, side streets, etc I get a squeaking/squelching sound coming from somewhere in the front end of the truck. I thought at first it may have been a rattling heat shield someplace under the truck, but now Im not so sure. No loss of power, check engine light, or anything of that nature has occurred so Im not sure what to do. Its a 2010 Ford F150 XLT 4wd ....
View 5 RepliesFord Super Duty (1999-2016) :: Rear Pinion Angle - Vibration In The Truck Around 65 - 70 Mph
Trying to figure out my rear pinion angle should be. I still have vibration in the truck around 65-70 mph and sometimes around 80mph if i go that fast. I checked my rear axle last night and its at 8.5 degrees on top of the pinion snout is that correct???? And i forgot to measure the rear driveshaft angle but i can do that after work when i get home. Truck is a 2004 ext cab short bed 4x4...
View 7 RepliesFord Super Duty (1999-2016) :: 2008 F350 - 4x4 Low Light Flashing And Truck Surges Badly At Low Speeds
I'm having a strange issue with my 2008 F350 6.4. I have only had this truck for about 2 months now. Every time it gets wet (from rain or a carwash), the 4x4 low light begins flashing, and the truck surges badly at low speeds. When I get above about 25 MPH, the light stops, and the truck runs normally. At the next stoplight, it happens all over again. After a couple days of dry time (?), the truck is back to normal (until it gets wet again). I have found a couple of old threads involving some similar symptoms, but they were never resolved on this forum (that I could find). I believe the transfer case selector motor has been replaced at some point, as it has a Dorman brand sticker on it. I wouldn't think Ford would use Dorman parts as original equipment.
View 4 RepliesFord Super Duty (1999-2016) :: 2004 - Truck Starts Sounding Off Like A Foghorn At Slow Speeds And Idle
My truck starts sounding off like a foghorn at slow speeds and idle, goes away as soon as you tap the gas pedal. The truck is all stock. 2004 5.4L ....
View 1 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Vibration Under The Truck Near The Back When Accelerate
2003 f250 crewcab 6.0 auto 4x4. I all of a sudden started feeling a vibration under the truck near the back when I accelerate and when I let off the gas no other time. No noises or clanking just vibration. I can wiggle the driveshaft inside the carrier bearing do you think that could be it or is it the rear end.
View 14 RepliesFord Super Duty (1999-2016) :: Rumble Noise At Low Speeds Like 30 Mph Or Lower And More Prominent When Come To A Stop
Experienced rumble type noise, like if you drive over those highway rumble things on the edge of the road. It happens at low speeds like 30 mph or lower and more prominent when you come to a stop. It came on all of a sudden . Replaced new tie rods, dampener and stabilizer bar links and still have it. Tires wear great and thought the hub's were still turned in as it sounded the front differential drive line was going around. This is on a 2002 F250 crew cab.
The complete tie rod kit that connects to the the pitman arm isn't cheap, it did need replaced as there was a lot of play in it but damn, when on a set income and it still have same problem , very upsetting. On social security disability and I told them that I can't keep spending money on parts that they told me were bad and it didn't work. Everything is tight on the wheel according to the tire shop , it takes me a while to get underneath and I can't find anything .
Ford Super Duty (1999-2016) :: Drivetrain Noise Changed To Vibration
I have a 04 F350 srw , 6.8 . Recently developed loud whine from the rear . I had the differential (10.5 sterling ) completely rebuilt . It quieted way down . But I still had a couple of high pitched whines . Took it back and had the rebuilder ride with me . At first he couldn't hear it ( it can be faint but gets louder under a load , I pull a 40' trailer and didn't have it with me), when he finally started hearing it he said it might be a planetary making a little noise, just watch it . So I made a short run (450miles RT) . Same noises but I noticed that sometimes when I stopped and got fuel , it would quiet down for 50 or so miles . I got to thinking maybe it could be a rear wheel bearing going bad and the sound transferring through the axle to the drive line . It only did it accelerating ( before and after rebuild ) and got louder going up a hill .
Today I drove it in to town and parked it ( still the same ) and a couple of hours later after a cold front came through ( maybe 10 Deg. temp change) I got in and the noise was about 90% gone , but at 45 to 60 mph. it vibrates . Let off the gas , vibrates ,, Put it in neutral- vibrates, revved the engine in neutral - vibrates and no change from rpm diff. . As long as its rolling between 45-60 , it vibrates . Hit the brakes- vibrates.. I have had 3 mechanics check it out ( 2 good ones and one that the other 2 take what they cant figure out ). Left them all scratching their heads. Checked the driveline and I changed one U joint (prior to the short run ). All seems tight .
Ford Super Duty (1999-2016) :: Noise / Vibration That Periodically Comes From Front End
I've been chasing a noise/vibration that periodically comes from the front end of my '99 F250 SD. Quick & dirty of it........basically while cruising 55-60 down the road, sometimes when I hit a bump in the road or go over some railroad tracks or something like that I will get a grinding/vibration from what sounds like the front drivers side wheel. Best way to describe it is it literally sounds like my wheel is running on the rumble strip on the edge of the road at road speed. It will fade in & out a little & last maybe 5-20 seconds & eventually quite until some time farther down the road if I hit another bump. Doesn't happen all the time, just randomly.
So far to try & problem solve I have lifted the front & spun & kicked & wiggled & pulled on the wheel to see if I can feel or hear anything & everything seems solid. I have pulled the wheel off & looked the whole hub & wheel bearing over & everything seems fine. I have even pulled the 4x4 lockout out & inspected everything in the lockout & inside the wheel bearing & can't find anything that seems to be bad. (My original thought was that the Warn hubs I have might be messed up & the hub is trying to engage while driving down the road & that is the grinding & vibration I'm feeling.).
As mentioned above I have Warn manual hubs, I just replaced the wheel bearing last summer (only have about 10,000 miles on it), & all the seals & ball joints were done about 3 years ago.
Ford Super Duty (1999-2016) :: Whining Or Vibration Noise Seems To Come From Somewhere Around The Antenna
I have a 2014 super duty extended cab truck and at times I get a vibration noise which seems to come from somewhere around the antenna. The little rubber flapper at the base seems to move and isn't tight against the metal. Is this causing the noise...
View 4 RepliesFord Super Duty (1999-2016) :: Grinding Noise At Slow Speeds - Clunk When Coming To A Stop?
Every once in a while, while driving my 06 350 SRW at slow speeds, I hear a grinding noise coming from the left side of the truck. It is almost like a winding grinding noise if that makes sense. It will grind slow to a stop, and then I hear a clunk.
This is a very intermittent problem. The tires are completely shot on the truck, and I thought that would be it, but considering it is intermittent and the clunk I hear as I come to a stop I figured it could be it.
Ford Super Duty (1999-2016) :: 2003 F250 - Moaning Noise From Front End At Highway Speeds
I noticed a moaning from the front end a few weeks back and it seems to be slowly getting a little worse. It is only noticeable when I'm accelerating or maintain speed, but as soon as I let off the accelerator and start to decelerate, it goes away. Sometimes, when the truck hasn't been driven for at least a couple hours, I pull away and there is a really noticeable sort of "clunk clunk clunk" but then it goes away and it just moans. I can also hear some noise from the front end at highway speeds, but of course it is hard to hear much else other than engine and road noise from the cab. It's a 2003 F250 with a 7.3 and four wheel drive.
View 8 RepliesFord Super Duty (1999-2016) :: Bull Whirring Noise / Vibration When Driving
2002 F250 4x4 ... There is a bull whirring noise that started about 4 months ago. I attributed it to tire noise. Then this past winter I put the truck into 4 wheel drive and it went ok, however everything started vibrating. First thought was u-joint however none are loose. Then I thought needle bearing, the axle has no play in it at all. So I looked at the drive shaft, it has a sloppy turn, not sure on how much play it should have.
Then you turn it and it then kind of binds up, you can push through that bind then it goes until it hits that spot again. I jacked the truck up and turn the wheels there is no noise. The noise is only when it is driven. Took it to ford and they came back with nothing, they replace the rear pumpkin gasket and cover stated those gears where fine and they inspected the rest, and came back with nothing. Should I just start by replacing front hubs and bearings and see what happens.
Ford Super Duty (1999-2016) :: Truck Won't Start / Just Rapid Clicking Noise
So I was trying to put led turn signals in my truck then I decided not to because it was getting too dark. Earlier today started without complaints. Then after I was done with the headlights I tried to start my truck, nothing besides rapid clicking. First thought was battery was dead from me leaving the dome light on the entire time while working on it and also having the headlights on a good portion, so I decide I'll jump it. Get it all hooked up and and start the donor truck then wait 2 mins and try to start my truck still nothing but rapid clicks. I got the voltage meter out to check the battery and had 11.97 volts (that's not great but either way it wouldn't start when I tried to jump it). Put it on a charger? Bad starter? Solenoid?
View 11 RepliesFord Super Duty (1999-2016) :: Squealing Almost Chirping Noise Coming From The Rear Of Truck
So When driving around I'm hearing this squealing almost chirping noise and it sounds like its coming from the rear of the Truck. I greased the bushings and leafs but that didn't fix it, to me it sounds like a rotating noise. Don't think it's the brakes cause it makes the noise when driving not stop.
Also, a bad alternator would make noise while driving over 40+mph, like a loud whistle?
Drive a 2012 F250 6.2L 19k miles
Ford Super Duty (1999-2016) :: Truck Makes A High Pitched Whining Noise
I noticed my truck makes a high pitched whining noise. It does it at idle and while acceleration up to 40 mph or so. The pitch of the wine increases with RPM'S. It is not the cold start whine issue I have researched on YouTube.
It is in the cold or warmth. No difference. It's always there. My 2012 6.2 did not sound like this at all. I have crawled under the truck and it appears like it is coming from the transmission.