Ford Super Duty (1999-2016) :: Low Fuel Pressure - Engine Power Reduced After Fuel Filter Change?
I had my fuel filters changed at the dealership today on my '15, and then I bought fuel and headed home (70 miles). About half way home I got a "Low Fuel Pressure" message and a little while after that "Reduced Engine Power" along with the check engine light.
I pulled over to see if they did something like leave the drain open, thinking it might be sucking air. Of course it was dark and I could not see anything. However I did hear a buzzing sound and could feel a vibration when I touched the fuel line going into the top of engine filter.
While it is possible I got bad fuel, I suspect they did something wrong installing the filters. Even after cycling the fuel pump multiple times they had a hard time getting it started afterwards; I think they finally disconnected the top fuel line to bleed the air out.
I continued home and made it, but not sure what to do now; its 70 miles back to the dealer.
What is the most likely problem? Improper fuel filter installation or bad fuel?
Should I pull the filters in the morning see if there is something obvious like an out-of-place gasket? If so, top or bottom filter?
Is this a tow truck affair or should I drive 70 miles back to the dealer?
What the heck is the buzzing sound?
Ford Super Duty (1999-2016) :: Intermittent Tire Pressure Monitor System Faults
I have a 2010 F250 Super Duty with 18" factory wheels. I started having intermittent Tire Pressure Monitor Faults. My research lead me to believe that the seven year old sensors were probably running out of battery life. So... When I had new tires installed I also had new FoMoCo sensors installed and I purchased a FoMoCo tool (TPMS 19) to train the new sensors. My problem is that I cannot get the sensor training process to work. When I put the truck into the train mode and try to retrain the LF tire, nothing happens and eventfully the horn beeps twice and the dash reads that the training failed. Where is the receiver that the sensors communicate with? Could it be bad?
View 9 RepliesFord Super Duty (1999-2016) :: Auto Locking Hub Retaining Ring Falls Out
I just replaced the ball joints on my 02 excursion and I can't get the locking hubs to seat far enough in so that the retaining ring keeps them in place. The ring seats but then works out as I'm driving. There is something keeping the hub from sliding in far enough so that the ring/clip can set deep enough in its groove. What's causing that? Its happening on both sides.
View 10 RepliesFord Super Duty (1999-2016) :: Fuel Pump Come On But Starter Won't Crank When Turn The Key
I have a 1999 f350 7.3. Turn the key lights and fuel pump come on but the starter wont crank. I replaced the starter and checked all the fuses i could find. The only way I can get the truck to crank is by jumping the relay under the hood.
View 9 RepliesFord Super Duty (1999-2016) :: 2006 F350 Getting Fuel But Only Crank And Won't Start
So here's the deal, crank no start its getting fuel. Has base oil pressure and i put a ficm on that test good with a voltage meter key on engine off and cranking. I haven't hand any trouble finding info on this issue so. We can keep picking away. Just cant find anything about this.
A buddy of mine who has been trying to figure it out for me, Got it to start using a starting fluid. And it would run if someone was pushing the gas peddle but wouldn't idle. Or start without the starting fluid.
Ford Super Duty (1999-2016) :: V10 Fuel Pressure / No Power Lean
Changing a fuel pressure regulator on one of these? I'm having an issue with it running really lean, like laying down with no power lean.I put the pressure gauge on it and I'm running an even 30 pounds at the rail. Changed the filter in hopes, but no change. Just changed the O2 sensors and they were both white.
View 9 RepliesFord Super Duty (1999-2016) :: Dash Light Out At Fuel / Oil Pressure Gauge
On my 05 Super Duty, the gauge light for the fuel and oil pressure are out. The needles are still illuminated red but the backlight for the gauges are dark. Are these replaceable bulbs or are they a circuit board diode or something that can't be easily replaced?
View 1 RepliesFord Super Duty (1999-2016) :: Truck Only Runs With Lower Fuel Pressure
1999 F250 7.3 240k miles .... This is the second truck to act like this on me after I cleaned the in tank filters.
I had to cut the fpr spring to 30lbs for the truck to start fine cold and idle ok but has no power. When hot it wants to die and or dies at idle and has next to no power. ( I'm guessing from lack of fuel) but it's the only way for me to use it. With a new spring and 60ish lbs of fuel pressure, they won't even start.
I cleaned the in tank filters. New fuel filter. new oil. rebuilt the ipr. unplugged the ipc. no loss of boost. checked my uvch, wiggled all harnesses with no difference. I also tried dropping the tank again in case I pinched the return line but that made no difference.
I'm guessing that I need new injectors. I'm not close to anyone with a computer nor can I afford to throw away any more money at the moment.
Totally stumped and cannot seem to find a definitive answer online so far. Both trucks ran somewhat ok before and got worst once I dropped the tank and cleaned the filters which increased the fuel pressure. This is my second truck to act this way.
Ford Super Duty (1999-2016) :: Growling Coming From Front End - No Fuel Pressure
2003 F250SD 5.4 4x4... When I recently heard a growling coming from my front end. I read some great posts on here about the whole front end tear down. Replaced all my ball joints, universals, wheel bearing hub units, locking hubs.....
So yesterday i came home from work, about 30 minutes later i hit the key on the truck and it wouldn't start. Kinda sounded like it wanted to but was starving for fuel. SO i grabbed the fuel pressure gauge and did a quick check......and No fuel pressure at all. Checked the fuse, Couldn't find a Relay in the fuse panel (Is there one for the fuel pump??). Anyway 4 hrs later the trucks starts right up like nothing is wrong.
Go figure, I'm 2 days away from my last payment ...now everything has to be going wrong.... Do these fuel pumps act up like that ??
Ford Super Duty (1999-2016) :: 2006 F350 6.0 HPOP Leak And Fuel In Oil / Hot Crank No Start
I'm just a shade tree mechanic try to diagnose a hot crank no start condition on my 2006 F-350 6.0 that I purchased second hand about six months ago. I first took it to a diesel shop to have them fix it and the mechanic told me that the stand pipes and dummy plugs needed changing out but couldn't tell me 100% if that would fix the hot no start problem.. I have been reading a lot about this problem and it seems that the snap to connect fitting on the HPOP is the most common problem on these trucks. It seemed easy enough to do so I went after it only to find it was already replaced with the updated part.
I went ahead and changed it anyway but it obviously didn't work. So today I pressurized the system through the ICP port with my small harbor freight compressor up to 80 psi and forced the IPR valve closed with 12v. I then listened for a leak in the passenger side valve cover with a hose stuck in the oil fill cap, the driver side cover from some drain hole under the air filter housing and in the oil filter housing. I could hear a mild hissing from the driver side and the oil filter housing but it was clearly louder from the oil fill on the passenger side. This leads me to believe I have a top seal leak from one of the injectors on the passenger side, but not 100% sure. Should I be hearing anything at all from the driver side and from the oil filter housing if its a bad seal in the passenger side?
Another problem I just found out I have seems like maybe fuel in the oil. I done a oil change this week after 3500 miles since last change and drained out five gallons of oil!! The oil seemed really thin. My coolant level is still good so the only thing I can think of is fuel dilution. Could this possibly be the same o ring or injector that is causing my hpo leak or something else? Will a bubble or balloon test diagnose this?
I bought a cheap OBD2 reader that works on my Ipad with a app called Dashcommand so I can see what codes were stored. The codes are...
P0401- Exhaust Gas Recirculation A Flow Insufficient Detected (EGR has been deleted)
P0528-Fan Speed Sensor Circuit No Signal
P0670-Glow Plug Control Circuit/Open
P0683-Glow Plug Control Module to PCM Communication Circuit
P2290-Injection Control Pressure Too Low
So far my thoughts are to replace the injector and nipple cup seals to take care of the hpo leak. Once I have the valve cover off, clean the injectors real good and cycle the fuel pump with turning the key on and inspect the injectors for a fuel leak. Is there a better way than this?
Ford Super Duty (1999-2016) :: 2001 F250 V10 - Truck Will Not Start / No Fuel Pressure
I have a 2001 F-250 XLT 4x4 with V10. Truck will not start. No fuel pressure. My Haynes manual does not show ignition or fuel delivery wiring. I have found the relay box behind the radio/dash. I need a wiring diagram and info on which relay is the fuel pump relay. Want to know so I can jump relay to see if fuel pump is okay.
Truck had sat for a few weeks being ran very little, so had to jump start yesterday. Ran for about 15 min, the shut off, re-started and ran for 30 min. Truck sat for about 1.5 hours then would not start. Charged battery overnight and it is 100%.
Ford Super Duty (1999-2016) :: 2000 F250 V10 - Random No Fuel Pressure At Start Up
2000 f250 V10 ...
Problem: More often than not when the key is turned to run (?), prior to engaging the starter, the fuel pump does not turn on for its 5 seconds. I have installed a fuel pressure tester gauge to watch the fuel line pressure. It was a little shaky to diagnose because if the line had pressure/fuel from the previous run it will start and run a short time and then die from lack of fuel. Unless the fuel pump activates when the key is turned to run, prior to full start, then there will be no fuel coming from the pump. No start. If you work the key to run a few times until the pump engages its good to go. The truck has never died while driving, once it gets that initial pump activation it runs good until the next start up cycle. When the pump does work it builds up to good "book" pressure and holds it at 39 when the engine is shut off.
We have put off changing the fuel pump for obvious reasons but can not see how it could be the problem since it has never quit once after we get it started. Are we wrong? We know the fuel shut off is on as it will run. We have changed the key lock tumblers, the ignition switch and the fuel pump relay. (behind the radio). Next up is to re-seat all the fuses and relays in the main fuse panel box under the hood. I just read that today on FTE. Is there a test we can do or some engine codes we need to look for? This problem is getting old fast.
Ford Super Duty (1999-2016) :: 2010 F250 - High Pressure Fuel Pump Failure
I have a 2010 f250 6.4 About two months ago the truck just quite on me. I am a farmer in south jersey and have a decent background in diesel motors. First thing that came to mind was fuel. I assumed I was having a fuel issue (clogged filters, failed pump, etc.) truck only had 45,000 miles on it so I took it to my local dealership for what I assumed would be a warranty job. I dealer service all my trucks while under warranty. Long story short I was told it was a fuel contamination issue which scared the walls of the hpfp throwing metal pieces into the injectors, fouling them.
I would need all new injectors, fuel rails etc. as well as new filter housings, fuel tank cleaning, etc. I had receipts for every drop of fuel put in the vehicle and fought all the way to through the dealership to Ford who sent out a rep and who denied the warranty work. Fortunately my insurance company covered the ordeal and all repairs were completed. I got the truck back and 2 weeks later the truck died on me again. I called the dealership back who supposedly warranted the repairs but there first words were there is no way it is their problem, they would look at it but I have to consent that if they find it is contamination again I am responsible for the repairs which we all know just to diagnose they have to remove the cab etc.
I of course lost my mind and told them this is there issue and there is no way in hell I am that unlucky that I received 2 bad tanks of fuel from 2 different high volume highway side fuel stations in the same 2 months. it is obvious they missed something or there is another issue that was not addressed. They claim there is no way they missed something. I am at a standstill.
Ford Super Duty (1999-2016) :: No Startup / Won't Even Turn Over
My F-350 has developed a new problem. It wont start. It wont even turn over. All Electricity is on, glow plugs glow, gauges work, lights work, but when you turn the key to the start position noting happens. Some of the indicators go dark.
I even tried a jump thinking my batteries no longer handle the load. Same results. I suppose I can remove the batteries and take them in for testing. In fact, I'll probably do that now.
2002 F-350 Superduty, 7.3 Ltr, Turbocharged. 260000+ miles.
Ford Super Duty (1999-2016) :: Clicking Noise At Startup?
I have a 99 F-250 SD 4X4 7.3 with about 160,000 miles and still running strong. I haven't been able to troubleshoot a strange clicking noise during the Glow plug / pre start warm-up process. It seems like the noise is coming from a vacuum "relay/ actuator" ( I think that's what the part is) under the hood on the passenger's side. But again I am not a Ford mechanic, nor have I owned this complex of a truck before.
There seem to be two different vacuum terminals that both have two outlets that attach to vacuum hosing. The unit does not have a line ( or 2 ) connected to the innermost vacuum outlet. Does this need to be connected? If I put my fingers on the units outlets to restrict the noise becomes more high-pitched, then will cease to make the clicking sound sooner than if I didn't cover the outlets.
I'm unsure on the process on how to insert a photo. it's asking for a URL, does this mean I need a flickr photo account to transfer the photo? Can I just upload a JPG?
Ford Super Duty (1999-2016) :: 2011 XLT - Rear End Clunk On Startup
The last couple of weeks a new clunk has appeared on my F350, 6.2 CC LB FX4. If I've been parked for a while, when I drive off, within the first 30 yards or so there's a clunk. Seems worse when I've turned sharply out of a parking spot. Sounds like the rear diff or drivetrain... I have a locking rear diff. Is this engaged or disengaged while "at rest"? Could it be that its slow to unlock when I start?
View 13 RepliesFord Super Duty (1999-2016) :: Raps Or Knocks For A Second Or Two Immediately After Startup
I just picked up my first truck ever yesterday, a 2012 F250 crew 4x4 with the 6.2L gas engine. It seems to me, when the engine is cold, that it raps or knocks for a second or two immediately after startup...is this characteristic? The truck is a 'new-leftover' model with about 28 miles on it so far. When warm, or even semi-warm, the engine starts right up and sounds like a healthy american V8.
View 14 RepliesFord Super Duty (1999-2016) :: 2008 - Gray Smoke On Startup?
A little background. I bought the 2008 F250 XL, 5.4L with 145,000 miles in December. It had a bad engine (dropped valve). I had the engine replaced with a remanufactured one (Performance Products) and started driving it this month. To date, I have put about 700 miles on it with an oil/filter change at 500.
So, here is the newest problem. Yesterday I finished changing my body mount bushings (with Daystar polyurethane ones) and went for a test drive. When I started the engine, a smoke cloud caught my eye. I took a closer look and noticed it was a gray smoke. I jumped out and ran around to smell the smoke - it had a gas smell. I did not test for smoke after my test drive.
So here is my question. It is obviously burning excess fuel on startup. That would mean that one or more injectors are leaking down after shutdown, correct? Testing this would be done by performing a leakdown test? How do I go about doing this WITHOUT any special equipment?
Ford Super Duty (1999-2016) :: 2000 F350 V10 Backfire On Startup
Started my truck this morning. 2000 F350, V10, 153000 on the clock. Immediately sounded like a shotgun went off under the hood, now it sounds like it's running a cutoff exhaust. Had a tiny manifold tick prior to this, but can it backfire hard enough to crack/destroy the manifold?
View 5 Replies