Ford Super Duty (1999-2016) :: F350 Fuel Tank Not Filling To Capacity
I have a 99 F350 with a 29 gallon tank. I filled it up yesterday and the total gallons was a little over 24. The low fuel light was on and the gauge only goes up to almost 3/4. I recently bought this truck. I've searched for a thread on here possibly addressing this but have been unable to find one. I've been going through possible issues in my head.... What the problem is?
View 14 RepliesFord Super Duty (1999-2016) :: 2014 F350 - Fuel Tank Capacity
I have a 2014 350 crew diesel short box. I am told, I have a 28 gallon tank but can't get over 22 gallons in it even though my gauge show e and my read out says I have 10 miles left until empty? Dealer says the left over 6 gallons is a reserve...
View 14 RepliesFord Super Duty (1999-2016) :: 2003 F250 V10 - Fuel Smell / Gas Tank Vent Leak
New to me 2003 F250 Super Cab 6.8 V10. Great condition inside and out. 68,000 miles. Began smelling fuel (gas) a few days after driving it 250 miles from purchase location. Traced leak down to the top of the gas tank. Staining was visible around the rear vent. Applied about 5 psi to the tank and sprayed soap around until I saw bubbles coming from a hairline crack at the rear vent connection. Its where the fitting for the hose comes out of the tank.
My first choice would be to hot weld the crack. I'm not very comfortable with the idea of a heat source near a gas tank. I'm not sure, but the heat from the plastic welder might be hot enough to ignite fumes? Second option is to try some industrial 2 part epoxy (PIG) and seal it with that. Is there pressure inside the tank, and if so how much? Can try this fix with epoxy or JB Weld?
Ford Super Duty (1999-2016) :: 2005 F250 - Fuel Gauge Read Almost Full When Only Have Half Tank
I recently bought a 2005 Ford F250 Super Duty, diesel 6.0.
As I was driving to work this morning I noticed that the fuel gauge read almost full when it should have only had a half tank. A little while later I heard a beep and saw that the gauge was now on empty with a "Low Fuel" message displayed. Then I noticed the heater was suddenly blowing cold air.
I've only had the truck for a few weeks, but haven't had any other problems. I did replace the CD receiver and all of the instrument cluster lights a couple weeks ago, but everything seemed to be working fine after.
Ford Super Duty (1999-2016) :: 2015 - Fuel Tank Size?
It doesn't say on the window and in the owners manual I should have a 23 or a 35. The most I've put in my truck is 29.somthing and I had 3 miles till empty and the needle was in the red. I'm thinking I have a 30 gallon tank but how can I find out for sure.
I have a 2015 F250 6.2L CC SB FX4
Ford Super Duty (1999-2016) :: 2012 - Full Tank Gas But Low Fuel Light On With CEL?
I have a 2012 f250 6.2L gas that the check engine light, low fuel light and the fuel gauge says it's empty. The truck has a full tank of gas. I am in camp for another 2 weeks and my girlfriend is driving the truck. I am thinking a blown fuse or disconnect the battery to reset the computer could solve it. Hoping it's something I can instruct her to do on her own over the phone.
View 13 RepliesFord Super Duty (1999-2016) :: F250 - Adding Additional Diesel Tank?
I've been looking at adding an additional diesel tank to my F-250, since the stock tank only holds some 38 gallons. However, I do not want to lose the space on the bed and have been looking at tanks that are mounted under the bed.
Most tanks I see are welded steel, completely overkill and accordingly priced. I'm wondering if a second stock tank pulled from a junkyard might fit in well, but haven't lowered mine yet to check the complete dimensions.
Ford Super Duty (1999-2016) :: Fuel Gauge Going From Half Tank All The Way To Full Going Down The Highway
As I was driving to work yesterday I noticed my fuel gauge going from half tank all the way to full going down the highway. I started looking at the rest and they seem to be in there normal spots. I looked up and watched the outside temp go from 40 degrees to 5. This morning the fuel gauge goes straight to full and the outside temp bounces between 2 degrees and 10. What may be going on to cause this?
The truck is a 2000 F350 crew cab with a 7.3 Power Stroke
Ford Super Duty (1999-2016) :: Water In Gas Tank - Blow Compressed Air Into Fuel System?
I am a little skeptical of this, but someone told me that since I got water in the gas tank of my 2003 F250 I should blow compressed air into the schrader valve on the fuel rails to eject it all into a bucket under the disconnected fuel filter.
View 10 RepliesFord Super Duty (1999-2016) :: OEM Fuel Tank Has A Crack - Transfer Flow Replacement
My stock OEM fuel tank has a crack in it. I've got to replace it. I was thinking of getting a TransferFlow replacement tank. It would nearly double my capacity. My wife wants me just to go stock to save the money, but I'm thinking the extra capacity would be nice. One thing that did concern me, however, is how much my fuel efficiency might diminish because of the extra weight of the tank (150 lbs) plus fuel. Since it is a gas truck, not many options.
View 8 RepliesFord Super Duty (1999-2016) :: 2005 F250 - Howling Noise Coming From Gas Tank
Have a Howling coming from my single gas tank, truck was sputtering now and then. Yesterday it died and would not start. Towed it home and then it started. Think its the fuel pump, Is it tough to change.... 2005 F250 Super Duty109K Miles...
View 14 RepliesFord Super Duty (1999-2016) :: Low A/C Pressures While Being Over Capacity
In all fairness, this isn't for my SD, but there aren't really any forums for my '94 Villager and all A/C systems work pretty close to the same, so I thought I'd at least throw my question up here and see what comes of it. It's a bit of a hodge podge of manufacturers (Mercury, Nissan, Ford, Mitsubishi), but it's a Mercury, so technically a Ford.....ish.
My A/C crapped out last summer, so I finally got around to rebuilding it earlier this summer. I replaced absolutely everything except the rear expansion valves and the evaporators, which I flushed out with A/C flush and compressed air real good. Then I blew a line on a dirt road because I didn't get a line all the way clipped in. I got a bit paranoid about grit in the line, so I went ahead and replaced the line and dropped in a new dryer, sucked it all out good again, put a splash of POG oil in there, and filled it up with 134a.
According to the specs I could find, the capacity of my system is 52oz, or 4.3 of the standard 12oz cans. I always bleed the lines between cans to rid the lines of air and moisture as much as I can, so 4.5 cans usually gets about 52oz in the system. Anyways, it was 90 outside, so my readings should be 45-55 and 250-270. After adding 4.5 cans, and letting it run for a bit, my readings were still a bit low and my vent temp was only 60, so I went ahead and finished off the can. They were still reading low, so I sorta reluctantly hooked up another can and started filling. It sucked the whole can right up any my readings were 45 over 220 with vent temp at about 57. The low side is about on the low end of the acceptable range, but the high side still isn't quite up to the desired range and I don't want to stick another can in even though my readings indicate I'm not over-filled. I'm wondering if something's not right in there, or if maybe I'm just expecting too much from a 23 year old A/C design...?
Strolling into work today at 35-45 mph, it was a touch over 80 outside and my vent temp was a smudge over 40, so I guess that's not too bad. My radiator fans works fine, but they don't move a bunch of air. I usually drop an additional ~15 degrees when I'm on the move as opposed to sitting at idle.
Ford Super Duty (1999-2016) :: 2006 - Fuel Gauge Dropped To Empty From 3/4 Of Tank - Sensitive Gas Pedal?
I bought a 2006 F250 6.0L a couple of months ago, from a dealership. It's been bulletproofed already, has an intake, coolant filter kit. Has 95k (mileage). Today, my fuel gauge dropped to empty from 3/4 of a tank for a couple of miles and set off the CE light. I hooked my scan tool to it, to clear the code (P0460).
After just checking other things out with the scan tool. I cleared it and went on... I had to run to the store, later on... I was pulling out of the neighborhood and the gas pedal was a lot more "touchy" and the truck, responded to it and it launched pretty good and blew a good amount of black smoke.
Do any of you think this has/or had a tuner on it and I may have activated it with my scanner?
Ford Super Duty (1999-2016) :: 2004 - Fuel Gauge Showing 1/4 Tank - Computer Flashing 5 Miles Empty?
I just bought a used 2004 F-350, 4x4, crew cab, short bed, 6.0L diesel. I'm having a WTF moment on fuel. Gage indicates just under 1/4 of a tank of diesel but the on-board computer is flashing like crazy stating 5 miles to empty, what the hell is that all about?
View 1 RepliesFord Super Duty (1999-2016) :: Crank Case Holds 14 Qts - Oil Capacity?
I recently purchased 1999 7.3 PSD The owners manual says that the crank case holds 14 qts. I have read on other sites 15 quarts. In my engine 14 is barely at the add mark. The cross hatch area is 2 quarts to the high mark. My question is should I put is 15 quarts to get the level up onto the cross-hatched area or leave it down at the add mark ?? I'm using Motorcraft 15 W 40 Dino oil. and I replaced the filter with the correct Fram filter.
View 6 RepliesFord Super Duty (1999-2016) :: 2005 F250 Seemingly Not Getting Fuel
2005 F-250, Diesel, 105K miles, all stock, fuel and oil filters changed in May, about 4000 miles ago.
three times in the last 4 days the truck has seemingly run out of fuel. Got a full tank about a week ago, at the same place I always go, so I doubt it is bad fuel. It ran thru a 1/4 tank with no problems.
4 days ago, it wouldn't start. It just didn't seem like it was getting fuel. It sat for several hours and then ran fine for about 15 minutes and then slowly died out. It wouldn't restart. It sat for 8 hours, and then started again, ran for about 15 minutes and I cut it off.
The next day, it started fine, I drove it 3 miles, cut it off, and an hour later it started but ran for only 10 -15 seconds and it slowly died out just like I was running out of fuel.
I started it this morning and it fired up right away. I let it idle in the driveway for 30 minutes, and it ran fine. I cut it off, went to start it 30 seconds later and it won't fire again.
The backyard mechanic I use for simple stuff wants to replace fuel filters and see what happens. BTW - twice when it wouldn't start, he hooked up his computer and it had no error codes. You can hear the fuel pump running when you turn the key on and the mechanic said he could feel the pump working when he put his hand on it.
Should I let him do that or is there something else we should be looking at?
Ford Super Duty (1999-2016) :: F250 V10 - Fuel Gauge Not Working
1999 F250 V10 gas. I changed out the fuel pump, and now the gauge doesn't work. Checked all fuses - they're good. Is there any possibility that I could have accidentally pinned the float under the pickup sock, or got it hung somewhere? Is this a common occurrence? Don't really want to drop the tank again - but looks like I will have to in order to check/fix.....
View 3 RepliesFord Super Duty (1999-2016) :: 2004 F250 - Fuel Leak - Fix?
2004.5 F250 SD XLT 4dr 6.0L
CAI, 4" Straight exhaust
EGR Delete, 6.4 Injector pump
Coolant filtration system.
New injectors al around
New ICP, New IPR, New Oil Cooler.
Recently Bulletproofed on ARP head studs, and the stock Head gasket,
New injector harness and FICM from DieselTech Ron
SCT tuner, running innovative diesel tunes. EGT Sensor
37x13.5r18 nitto trail grapplers
Truck started bucking and stalling when warm and over 60mph. No codes.
Ford Super Duty (1999-2016) :: 2014 F250 - Fuel Mileage While Towing
My 2014 f250 4x4 crew cab with 6.2l gasser only gets about 7.5-8 mpg at 65 mph while pulling my 27' bumper pull travel trailer. I know that thing is basically a wall trapping the air but is there anything I can do to gain a couple mpg more? I can average about 15 mpg at 65 mph without the trailer on the highway.
View 14 Replies