Ford Super Duty (1999-2016) :: 2004 - Removal Of Bench Seat?
Just bought my first 04 F250 super duty Xl...4x4 Ext Cab...need to get this bench seat out and buckets and console in!!! I hear this is easy swap but never done before, or believe anything is easy.
View 1 RepliesFord Super Duty (1999-2016) :: Front Seat Head Rest Removal
So, I bought a set of seat covers yesterday and I'm trying to install them this morning. Surprise, surprise!! The head rests won't come out. I tried pushing the little button and pulling up hard, No good. I look for a little clip or some other retaining device. Nothing. How do I get the front head rests out?
View 5 RepliesFord Super Duty (1999-2016) :: 2012 F250 - Rear Seat Removal?
I would like information how to remove the rear seat back on a 2012 F250. I want to remove the head rests and from what I can find out they are bolted solid to the rear panel. I asked the same question earlier and got a reply for 2011, would that be the same? Is there any place I could get a schematic, a picture is worth a thousand words.
View 5 RepliesFord Super Duty (1999-2016) :: 2014 F250 - Rear Seat Back Removal?
I've got a 2014 f250 xl super cab and can't for the life of me figure out how to remove the back seat back.
View 2 RepliesFord Super Duty (1999-2016) :: 2013 F550 - Key In / Door Chime Disconnect?
Really love my 2013 F550 but the door chime is driving me crazy. On my 2003 f150 you could just drop the column cover and unhook one wire running to the tumbler. So I had a look and found it to be totally different. How to unhook it on this truck?
View 2 RepliesFord Super Duty (1999-2016) :: Batteries Keep Running Down
I have a 2006 f350 superduty 6.0l diesel and if one of the batteries are bad will it drain the good battery...had them tested and one tested good but I keep having to charge them both
View 2 RepliesFord Super Duty (1999-2016) :: 2003 - New Batteries Now No Start?
Just bought 2 new batteries as one was toast, and the 7.3 was really hard to start. After installing started like a new truck..This morning temp was 54 and would not start after several attempts, trys to run but after a few seconds stops. Just bought and looks like a new solonoid had been installed. What should I check??
2003 F-350 7.3
Ford Super Duty (1999-2016) :: Batteries Run Down To The Point That Sometimes Truck Will Not Start
I have a 6.0L diesel that is not a daily driver so it sits for days and even weeks at a time. When I go to start it the batteries will be run down to the point that sometimes the truck will not start and I will need to charge the batteries. I was thinking about installing a battery tender and leaving it plugged in so the batteries will stay charged. I'm looking at the tender in the link.
View 14 RepliesFord Super Duty (1999-2016) :: 2002 F350 - Batteries Keep Dying
The batteries keep dying. I can charge the batteries and drive it to work a couple of days and by the fourth day, it's dead again. Have replaced alternator, batteries, and starter and I am still having issues. Just noticed this weekend, the instrument cluster going off, coming back on, shutting off again all while the truck had been running for about an hour. I'm not sure if it is because the battery was dying or what. As soon as we got home after the instrument cluster incident, turned the truck off and tried to start it. The battery was completely dead.
I have been looking up on sites and I keep coming across the GEM Module. I want to ask around before I buy it. I have also noticed small issues with my 2000 Excursion. Back windshield wiper starts up upon the vehicle starting. Goes a few times and stops. Not sure if this is the same type of issue as in the GEM Module.
2002 Ford F350 7.3l Diesel with 148000 miles
Ford Super Duty (1999-2016) :: 2015 F350 - 12V For Charging FW Batteries
How many Volts available at plug for charging FW batteries, and what can be don to trick alternator in to keep charging when truck batteries full, install larger wires? From alternator or truck battery, if yes which battery. 2015 F350 Lariat 200 alternator.
View 14 RepliesFord Super Duty (1999-2016) :: Starter Bogging Down Batteries / Slow Crank
Got 01 F350, 7.3
Started having issues with starter bogging down my batteries. Slow crank, it would catch anyway and runs great. I have spare used starter in the garage, threw that on and it cranks fast, but occasionally just free spins half way thru the cranking.
My question is, can I make one good starter from these two? Monday AM buyer is coming to get my truck, and I don't want to have to buy brand new starter if I can avoid it, but I want him to have reliable used starter.
What causes free spinning (not flex plate related), and what causes power drag and slow crank? I was thinking throw solenoid from fast starter onto slow one, since slow one doesn't spin out but it bogs down my voltage?
Ford Super Duty (1999-2016) :: 2002 F350 - Reconnected Batteries Now It Won't Start
I pulled the battery cables this weekend to install a flatbed on my 02 f350, I did do some welding on the frame of the flatbed during install and the bed was in contact with the truck frame which is why i removed the batt cables in the first place, now after my project is finished i have reconnected batts only to have my gauges bounce around and an audible clicking under the hood when I try to start, gauges bounce back and forth several times, odometer comes on slowly.
2002 f350 7.3 diesel 4x4 auto
Ford Super Duty (1999-2016) :: 2000 F350 - Batteries Draining Down / Alternator Seems To Be Running Really Hot
2000 f350 7.3 .. I'm having a horrible time trying to figure out why my truck is draining down the batteries. I can charge my batteries over night and put hem in and the truck will run for a few hours but then it dies completely. The alternator seems to be running really hot afterward like it is being over worked. I put in 2 different alternators and 2 new batteries and it didn't fix the issue.
I then put in a new starter relay. Still having the same issue. I believe I have a short because I tested for it but am unable to locate the short. I heard if you over work the bushings in the starter they can ground out on the casing which will cause something similar to this to happen. I work in ND and had to cold start it in - temperatures the morning this all began. I purchased a new starter but don't want to put it in if that is not the issue.
Ford Super Duty (1999-2016) :: Truck Dying While Cranking But Batteries Supposedly Good
I drive a 2002 F-250 7.3l and have been having a lot of issues. The most recent one is that my truck won't crank unless I've had the block heater plugged in. Like I said in the title, the batteries are supposedly fine. They've been tested by a mechanic and Advanced Auto Parts. But when I crank the truck, it will only turn over for 10 seconds or so before it loses enough juice to even turn over. So it's kind of cold, but only 40-50 degrees, so I didn't think the truck would have that much of a problem starting. I'm wondering if my issues are a combination of an electrical problem and a heating issue.
View 8 RepliesFord Super Duty (1999-2016) :: 2006 F250 - Truck Cranked And Batteries Died
My truck ran and drove then I changed my Steering Gearbox. After all that, I went to go start it, the trucked cranked and the batteries died. Hooked up the charger then and nothing, No start no crank. F250 2006 diesel 6.0 ...
View 14 RepliesFord Super Duty (1999-2016) :: 2003 F550 - Batteries Not Charging / Instrument Cluster Does Not Work
I have a 2003 F550 6L diesel flatbed truck. Last week, the overdrive button would activate by itself. I'm assuming there was a loose wire so I taped the button to keep the overdrive off. Two days later, the overdrive came on while the button was pressed in and then smoke came out of the steering column/lever area. I pulled over and turned off the truck. The smoke stopped after 10 seconds and I restarted the truck. The overdrive light/functionality no longer worked and the instrument cluster also wasn't working.
The next day I was driving, and the truck died at a stoplight. I got it towed home, and opened the steering column and noticed that the overdrive button wire had burned. I removed the harness clip and charged the batteries. It started but the instrument cluster still didn't work. 2 minutes later the truck died. I replaced the alternator but still it won't charge the batteries. The truck dies 2 minutes after getting a battery boost to start the truck. The instrument cluster also doesn't work. What could be causing this issue?
Ford Super Duty (1999-2016) :: 2002 - Batteries / Cables And Starter All Good - Truck Barely Turns Over?
On my 2002 7.3 liter for the last about 1 week it has been getting harder and harder to start. Up until yesterday when it will not start at all. What it does is this. A week ago I noticed it cranked slightly weaker but still ran perfect once started. This has progressed slowly but definitely. It has never gotten better, only worse. Even with jumper cables hooked up it does not improve at all. The starter is a Carquest POS but only has 50 thousand miles on it.
I have driven hundreds of miles with this problem in the last week and the truck has never skipped a beat aside from the starting issue. I took the batteries in to no less than 3 places and they all said the batteries are good. However when I put my multimeter on them when it is being cranked the volts drop from 12.6is down to about 8 volts. When I did get it started the other day and put a meter on it the batteries were charging up to around 13.7 or so.
When there is no load on batteries they show good but have been unable to get a solid answer if any of these places are load testing them: I am convinced they are not. I checked the resistance of the cables and they all have none. The grounds are all good. So I pulled the starter and took it in as a last result. They say the starter is good also! The connections were all tight and I cleaned them all very well.
Ford Super Duty (1999-2016) :: 2014 - Removal Of Bed Stickers?
I want to remove the 4x4 stickers on my 2014 SD box. I think it looks cleaner without them. Are they difficult to remove or does the hair dryer trick and then some Goo-Gone do the trick without a big time effort? The last thing I want to do is make a mess of the paint finish.
View 13 RepliesFord Super Duty (1999-2016) :: Tailgate Handle Removal?
Looking to get rid of the step handle, I did this mod on mine and it was a direct fit...take off old liner and unbolt handle, then get a liner from a non-step tailgate and it is a direct fit:
View 7 Replies