Ford Super Duty (1999-2016) :: Starter Does Not Crank - Only Relay Click When Turn The Key
I have an 02 F250 6.8 with 51,000 miles on it. I recently replaced the battery about a week ago, and only actually drove it yesterday for the first time since replacing the battery. I drove it about 25 miles, parked, and when I went to restart, it wouldn't. The starter doesn't crank, so I mean its not a cranking issue as in cranking, and not starting. It only clicks at the relay when turning the key. It acts like when you try to use a wrong chip coded key.
All of the dash lights came on, and I can hear the relay clicking, but that's it. I swapped the relays around, and no luck. If I let it sit a while, about an hour, it will fire right up. The battery cables are tight and free of corrosion. I am curious, since I just put in a new battery, could this be the culprit? Why will it start fine cold, but not hot? I have NEVER had an issue with this truck until now.
Ford Super Duty (1999-2016) :: 2006 F250 5.4L Auto 4x4 - No Crank / Only Got A Click When Turning Key
Only got a click when turning key, in Park or Neutral. Made sure I had >12.4V from battery. Jumped starter solenoid with a remote start switch across main power line to starter and the 's' post, crank pulley almost moved, but didn't rotate. Removed belt, all pulleys rotate, but could not budge the crank pulley with a short breaker bar/socket, rotating clockwise from front. Removed starter, that upper bolt is a super pain! Not even sure I'll get it back in. Jumped starter solenoid again on the bench using a battery and jumpers, not the best connections, starter hesitated little bit, but opened up fully a few times, so I'm thinking it's ok (even though the power line from the solenoid to starter motor needs re-taping). Tried rotating flywheel from starter hole, no good leverage point, but no movement. Before I re-install the starter, how much torque should I be putting on the front crank pulley? Some say it should move easy enough cause the starter isn't that powerful. Others say remove the spark plugs to reduce compression? This truck is new to me, so I unfortunately have no history.
View 1 RepliesFord Super Duty (1999-2016) :: When Crank Lights Lit Up But Not Starting When Turn The Key
Yesterday I was on a pretty long trip and stopped off the interstate to grab some food. My truck is really loud so I always shut my engine off at the drive-thru. When I went to crack it back up everything lit up but when I turned the key nothing happened. I had the truck towed home and I put a new starter on it. Still nothing.....
Well after further investigating where the positive wire that comes from the starter to the battery was broken at the battery post. Don't know how the heck that happened but I fixed it back to factory condition but still nothing. I'm at a complete loss. I checked all fuses and everything looks good.
When I turn the key everything lights up, then turn to crank it and nothing but a slight sound coming from those square silver things in the fuse panel under the steering wheel.
2007 f250 PSD with to many extras to list
Ford Super Duty (1999-2016) :: 2001 F350 - Crank For About 15 - 20 Sec Before Starting
It's a 2001 F-350 Crew cab short bed. Got it from the second owner which had a large file from the original owner on documentation and maintenance records. Truck has 280k, tranny about 80k. Question I have is, I kinda thought it would "feel" more powerful then it does. Temp got to about 35f last night after work and it cranked for about 15-20 sec before it started (yes I let the "Wait to start" light go out).
Then pulling out of work it would hardly get out of its own way. Does this sound normal? When it is warmed up it goes ok, but still I figured when the turbo winds up it would feel a bit "peppier". I get its a diesel and not a hot rod but I was expecting a bit more pep.
MODS on the truck that I can tell: AFE cold intake, 5"? exhaust turbo back, about 4" lift. Stock PCM. In cab controlled rear air bags, nice deck with back up camera.
Ford Super Duty (1999-2016) :: 2005 V10 Engine Will Crank But Not Starting
Having an intermittent starting problem after sitting for a period of time or overnight. Engine will crank but not start, turn key off and back on wait 5 sec and engine starts and runs fine. Restarts all day long no problem. Dealer found a code(unk number) for low fuel rail pressure. Was able to create the problem for the tech. So far we have replaced the fuel filter, the FPDC (fuel pump driver control) and the fuel pump. Also replaced two ground straps, possible poor connection.
Problem continues.
Ford Super Duty (1999-2016) :: Beeping Noises From Dashboard After Starting / No Crank After Shut Off
I have some issues with my 2009 F250 5.4L. Recently I got in the car and went to start it. It started fine but I was getting beeping noises from the dashboard. 5 beeps with 1 second between each beep for 3 times. I shut the car off and go to start it again and engine does not crank at all. I get the relay click every time i try to start it but engine doesn't want to crank. Then the beeps come back.
About a month ago I had a reputable shop here in town install a compustar remote starter. It hasn't given me any troubles at all but I'm thinking this might be the culprit behind the issue. I towed the car down to the place where they installed my remote starter and they got the car started. They said I had blown fuses and the remote starter is not behind the problem I'm having. So I picked the car up and it was all good for 4 days and last night I get in the car and same issue.
I scanned the car and came back with these codes
U2472 Ignition State Unexpected
B1868 Lamp Air Bag Warning Indicator Circuit Failure
U2023 Vehicle communication bus error
I tried resetting the codes and tried to start the car (it didn't) and another code popped up
B1555 for ignition run/start circuit failure.
Whats going on? Problem?
Ford Super Duty (1999-2016) :: 2000 F250 Not Starting / No Crank And No Dash Lights
I have a 2000 F250 7.3 manual tranny that was put away for winter storage and now will not start. Need it to get my weekend work done now that the snow is finally gone. Symptoms:
- not cranking
- no dash lights (no oil light, battery light, etc.)
- radio works
- head lights work
- key buzzer works
- can hear clicking when turn key (assume solenoid OK)
Put in two new batteries, fully charger and terminals are clean. Where should I start looking?
Ford Super Duty (1999-2016) :: Power Mirrors Click But Won't Move
I can move the mirror adjuster switch and I can see the mirror trying to move and can hear clicking, but it won't move. It's like when the mirror has gone all the way in one direction and can't move anymore. But it does it in any position. I have hand-moved them to different positions and no matter where they are, the switch can't make 'em move into a different position. This happens with both mirrors. In case it matters, they are the power towing mirror that have the turn signal integrated on them and also they are heated.
View 5 RepliesFord Super Duty (1999-2016) :: 2000 F250 V10 Won't Start / Only Click When Turn The Key
My 2000 F-250 V10 won't start has a new alternator and new starter all it does is Click when I turn the key?
View 14 RepliesFord Super Duty (1999-2016) :: 2003 - Starter Just Click Then Start After Man Attempts?
I just bought an 03 f250 5.4l . I'm just using it to plow my driveway this winter. The starter just clicks , after multiple attempts it will start. The previous owner said it's been like that for a long time but always starts.
I'd like to fix this now while it's warm out , before I buy a starter I'm wondering if I should look into other causes and how to trouble shoot the issue.
Ford Super Duty (1999-2016) :: ESOF 4WD Not Working / Turn The Knob To 4 Hi Or Lo And No Relay Click
I have a 2001 for f250 with the electronic shift on the fly and when I turn the switch to put it in 4hi or low nothing happens I don't hear a click and the lights don't come on but the 4wd light works it comes on when I first start the truck and I put different relays in that we're good and still nothing I tested the the relay box itself for power and there wasn't any.
I used the truck last year for plowing and it worked sometimes it wouldn't go In or come out but after a few tries it would end up working but I've tried everything I could think of I'm starting to think it's something electrical because the relay box isn't getting power to it but idk if a vacuum leak would do that or a bad transfer case motor or iwe solenoid or if it's something more like a broken wire some where.
Ford Super Duty (1999-2016) :: 2008 - Click In The Steering Wheel At Slow Speeds
2008 F-350 ... Getting a click in the steering wheel. Slow speeds in parking lots. Even with the truck off you can manually move the wheel and notice it has play. Maybe 1/16" - 1/8" of play
Read a few old posts saying there was an TSB on it TSB 05-15-1 ... Couple of the posts say they replaced the steering column. Wanted some input before I pull this apart. It's more annoying than anything ..
Ford Super Duty (1999-2016) :: 2007 F350 - Receiver Would Not Click And Hold The Buckle Of Seat Belt
I need an expert. 2007 Ford F-350 King Ranch and tonight, the wife and I were coming home from friends house and I tried to buckle my seat belt. The receiver would not click and hold the seat belt. Cannot find the replacement. What should I do?
View 13 RepliesFord Super Duty (1999-2016) :: 2004 F450 - Loud Click Almost A Bang When Cruise Control Shut Off
I've got a 2004 F450 that I'm loving, but suddenly having an issue getting it into gear. To get it out of park and into another gear I've got to turn the key a little father towards start (somewhere in between normal after start position and actually engaging the starter) and then the column shifter will actually let me get out of park and into another gear. Once I've done this there is no problem moving between gears. Last, this has to be related since it started at the same time - when I'm in cruise control it takes a greater amount of force on the brake to get the cruise control to shut off. When it finally does, it makes a loud click, almost a bang. If I only lightly push on the brake it won't kick off the cruise control and the engine will increase power to keep the speed and fight me on the brake.
View 1 RepliesFord Super Duty (1999-2016) :: 2009 - Relay Click Under The Dash / Heated Seat Stopped Working
Its and 09, I can hear a relay click under the dash. It has gotten really hot since i bought it in sept to the point where I had to turn it off because I thought it was going to burn my bottom. I am guessing its not an easy fix.
View 4 RepliesFord Super Duty (1999-2016) :: F350 Won't Even Crank Or Start
I have 99 f350 single rear wheels 4x4 . I went to start it this morning and it would crank but not start b/c it was cold. I plugged it in and still wouldn't start then it wouldn't even crank. I checked all fuses swapped relays and I have new batteries. The last thing I did was hit on the starter a few times and it started. So I went and bought a new not remand a new starter and put it on and now it won't crank!? I get 12v at the little wire on the selenoid on the fender. So now what?
View 4 RepliesFord Super Duty (1999-2016) :: Battery Drain - Won't Crank?
I'm waiting on Christmas shopping to be over to replace the ICP and IPR on my '01 F250. In the mean time I have been going out every few days to crank it and let it run up to temp. Now, however, my batteries have slowly been getting drained over the past month, to where it finally wouldn't crank yesterday. So I'm wondering if I now have a drain somewhere, or is running it at idle for about 20 mins just not sufficient.
View 11 RepliesFord Super Duty (1999-2016) :: 2003 - No Crank - Turn Key Nothing?
So I have a 2003 6.0L Powerstroke 1 ton. I just replaced the starter thinking the solenoid was the problem. But my luck it wasn't. I turn the key and the ding stops and it's quiet. Dash lights go off. I have the engine light and water in fuel light on. ABS is on I think aswell. I've run out of options.
View 1 RepliesFord Super Duty (1999-2016) :: F350 Starter Won't Crank?
I have a 1999 f350 7.3. Turn the key lights and fuel pump come on but the starter wont crank. I replaced the starter and checked all the fuses i could find. The only way i can get the truck to crank is by jumping the relay under the hood .
View 5 Replies