Ford Super Duty (1999-2016) :: Burnt Rubber Smell While Driving / Parking Brake Seized
Noticed a burnt rubber smell while driving today. Stopped at a gas station and before I could get around to the other side of the truck, a guy stopped and told me there was smoke coming from the passenger rear wheel well. The truck seemed to run and drive fine. Didn't seem to be any noticeable drag, but once I got home I felt that wheel and it was a bit warmer than the others.
My parking brake pedal is all the way out and pulling on the release doesn't seem to relieve any pressure or "Pop" like it normally would if releasing the brake. We've got a good downpour of freezing rain right now and I'm not able to start pulling things apart. Anything easy I can try for now? Pretty sure it's seized by the way it's acting but I really don't use the parking brake. Auto trans and I live in a really flat area.
Ford Super Duty (1999-2016) :: Heat From Hub / Brakes Burning Smell
I have a 2000 F250 SD 4x4. I noticed the other day that after driving the truck for 10 miles or more and then stopping and getting back in it feels like the parking brake is on. I drove the truck home and on my way back I smelled brakes burning but it wasn't pulling while driving or braking. When I got home I put my head in the wheel well to get a look at the brakes on the drivers side it seemed ok, but when I did it on the passenger side it was hot as Hades! It's been my experience that if the caliper is hanging up it will pull either while braking or regular driving. I just want a better idea before I go ahead and buy a new caliper and hose and tear the dang thing apart.
View 8 RepliesFord Super Duty (1999-2016) :: Burning Smell While Towing Uphill
For the first time while towing a bumper pull trailer, started getting a very strong burning smell, only while going up decent size hills. After the climb, smell goes away. Kind of smells like burning rubber or wiring, but that should be constant and not just while up hill.
Checked tranny fluid and it didn't look burnt or low and never saw visible smoke. Have seen this discussed before but with no definitive conclusions. Truck has 150K on it and has long ago lost most of its towing power and the hills also drop the speed to around 45mph from 70 when I hit the big ones.
Ford Super Duty (1999-2016) :: Burning Smell Coming From AC Vents For About A Minute
When starting up my 2011 F-250 Gas, I have a burning smell coming from my vents for about a minute then it goes away. It smells like new electronics. My A/C seems extra cold as well. We just got back from a 3800 mile vacation. Its been going on now for about 3 weeks and never changes...
View 6 RepliesFord Super Duty (1999-2016) :: Burning Wires Smell Coming Through Vents
So just about every trip that's over 20 minutes I'll get a smell, seems like it's coming thru the vents and it smells like burning wires or like you turned on your heat in your house for the first time of the year.... Is this normal??
View 10 RepliesFord Super Duty (1999-2016) :: 2004 - Burning Smell And Shut Down - Stalls While Driving?
I have an 04 f250 with a 5.4 I smelled something like burning and the truck shut down. the fuse panel was warm. after a min or so it starts back up never know how far till it stalls again.
View 4 RepliesFord Super Duty (1999-2016) :: 2007 - Brake Pad Burning Smell - Caliper Dragging
The wife and I ventured out last Friday evening to run a few errands. When we returned to the house and pulled into the garage, we both smelled burning brake pad. I felt the rear wheels, the drivers side was too hot to touch.
Dragging brake caliper. I got online and reserved a drivers side caliper and a set of pads at NAPA. Saturday morning I removed the caliper. Much to my surprise, one of the caliper pistons was broken into multiple pieces.
I took the offending caliper to NAPA and picked up the new caliper and a set of pads.
Side note - NAPA seems to think the 2007 trucks have calipers that mount in front of the axle, not behind the axle. They will try to sell you a passenger side caliper and tell you it is a driver side caliper. It will bolt up fine, but the bleeder valve will be at the bottom of the caliper instead of the top. You'll never get the air out of the caliper.
Got back home, bolted up the new caliper and pads, then bled the system. All worked well.
I decided to throw new pads on the passenger side brakes as well, since I had 2 remaining. I took off the passenger side caliper, much to my surprise I found a cracked and broken piston on that side also! Another run to NAPA to pick up another caliper. Installed, bled the system again, all working well.
Now, I have never seen a cracked and broken caliper piston like this, let alone one on each side of the rear axle. What might have caused this? About a year ago I had a shop install new backing plates. The pads and calipers are about 3 years old, same shop installed those.
Ford Super Duty (1999-2016) :: Right Front Caliper Sticking / Brake Burning Smell
I know this has been talked about many times and how to solve the issue but thought I would ask some other questions too. Earlier in the summer, I did grease the slider pins as preventative maintenance. I don't drive my truck all that much and when I used it yesterday, (about 30 minute drive) I came home to burning brake smell. I'm wondering if enough heat would cause the caliper to go bad? Should I just grease the pins again or change out some parts?
View 6 RepliesFord Super Duty (1999-2016) :: 2008 F250 - Brakes Burning Smell / Wheels And Right Rear Was Very Hot
I have had the truck just under a year. It has 104k on it i only drive it on weekends. Last weekend going to Home Depot about 15 miles got out and could smell brakes burning. Felt the wheels and the right rear was very hot. Got back home no smell but still hot not as hot as earlier. Pulled the wheel off it looks as if the pads and calipers are fairly new paint is still on them caliper is a TRW. The pads were stuck in the carrier even the stainless clip ends look rusted.
Cleaned it all up both sides lubed the pad carrier with pin lube. Pushed the calipers back in some both sides went in easy. The right rotor has definitley been hot. Put it all back together and went for a test drive. Came back no problems checked the temperature with a laser type heat thermometer all wheels were around 140 f. Went out yesterday morning stopped and could smell the brakes again. Drove it back home and the right rear was 300 f. others 150 to 160 f.
Jacked it up put it in neutral and the you can spin the wheels by hand. Started the truck had the wife get in put it in drive wheels turning applied the brakes they stopped let go they turn freely again tried the parking brake it works fine also. So do I buy new calipers and brakes or maybe is the wheel bearing going bad causing the brakes to heat up?ied.
Ford Super Duty (1999-2016) :: 2002 F350 V8 - Burning Smell - Smoke Coming From The Brakes
I have a 2002 ford f350 triton 5.4 V8. I just put front brake pads on my truck today. Started driving around and i could smell burning brakes. Stopped and alot of smoke was coming from my brakes on my front passenger side but nothing from the front drivers side. Replaced all the brake pads on the front. What is making them so hot?
View 8 RepliesFord Super Duty (1999-2016) :: Burning Brakes Smell After A 30 Minute Drive / One Of Pistons Fell Apart Of Caliper
I pulled into my driveway after a 30 minute drive and smelled burning brakes. The right front was the culprit so I took a garden hose and cooled it down. The next day I remove the caliper and one of the pistons fell apart. So I need a new caliper and trying to decide if I buy after market or go with Motorcraft? I think the rotor, caliper, and pads are original since I the rotor is stamped Ford and the caliper bracket has TRW and Ford markings.
View 12 RepliesFord Super Duty (1999-2016) :: Slight Burning Plastic Smell / Engine Compartment Heat Shield Falling Down?
Recently purchased a CPO 2009 F250SD 6.4L. Happy with the truck overall but this AM I noticed a slight burning plastic smell so I opened the hood and looked around closely. Didn't really find the culprit(I don't think) but noticed that the engine compartment heat shield/barrier appears to be falling down above and behind the turbos (pictures linked below). How big a deal is this? Would it be covered under the CPO warranty? It almost seems like a safety issue. I also wonder if the insulation material, now exposed without the metal reflector material, is what is causing the smell....
View 14 RepliesFord - Escort :: 1999 - Smell Like Rubber Was Burning
I was driving my car today and it started driving like the brakes were on. It started to smell like rubber was burning. Before that I stopped at a traffic light and the car pulled to the left. Is the little car dying. 1999 ford escort zx2...
View 15 RepliesMitsubishi - Montero :: 1999 - Burning Rubber Smell From The Air Vents
While driving my Montero sport last week, I began smelling a burning rubber smell from the air vents. At the same time I noticed, on the dashboard, that both the brake, and, battery indicators had lit up. There was no smoke, mist, or off sounds, coming from the engine, and, the engine seemed to be running no differently than before this occurred. I drove home, parked the car for 5 days, and, yesterday visually inspected what I could see, which was almost nothing unusual. I started the engine and let it run for about 10 minutes in park.
The engine ran normal, no noticeable knocks or pings, no shaking of the engine, the belts ran smooth, no noticeable leaks of any kind. I checked all fluids and they were at normal levels, only the power steering showed a slightly lower than mid level of fluid, not anywhere near low.line. But, as soon as I started the engine, the dashboard indicators lit up and stayed on. There was only a very faint smell of rubber at the end of the 10 minute running of the engine, barely noticeable. The only thing that I did different recently was about 2 weeks ago I added a quart Pennzoil high mileage motor oil 5-30 instead of the usual GTX high mileage motor oil 5-30 that I usually put in the engine, as there was none available at the store. The auto has ran very well for the past year.
Ford Super Duty (1999-2016) :: Airbag Control Module Heating Up
I have a 2002 F350 7.3 Powerstroke with approximately 200,000 miles. Recently I have been having an issue with what I am told is my airbag control module heating up to the point it is too warm to touch when I am pulling a heavier load. It is located just under the dash on the center hump. I removed the black plastic cover revealing the module itself in order to determine that indeed is where the heat and smell of hot electrical equipment is originating from. It gets too hot to touch when pulling a heavy load and making the motor work...once I lighten up on it or am not pulling it immediately cools back down. If it is an option I would just disconnect it but I havent yet for fear of creating more of a problem.
View 1 RepliesFord Super Duty (1999-2016) :: Heavy Duty Rubber Floor Mats With Transfer Case
New floor mats. My truck is going to be 10yr old and has the original King Ranch floor mats. I want some heavy duty rubber ones that will fit around my manual transfer case lever. I ordered the Weathertech digital fit liners and I am not happy with them so they are headed back tomorrow. They have a heavy duty all weather mat but not sure how it will work with my shift lever on the floor. Husky liners/mats look nice and heavy duty but won't accommodate the floor lever.
View 6 RepliesFord :: Vibration And Burning Rubber Smell
My car has a vibration that translates up through the steering wheel. It occurs intermittently at varying speeds, from 1-3 minutes, and then goes away for awhile. The tires, CV joints, struts, and mounts were all checked and OK-ed by a car mechanic. There is also a burning rubber smell that I will notice after several minutes of driving. In addition, when I engage the car into drive their is an audible deep clicking sound as if something is engaging or breaking free from a stuck position. This also sometimes occurs when moving forward from a stopped position. The car has 160K miles on it but its been well maintained.
View 4 RepliesSubaru - Outback :: Smell Like Burnt Rubber / Actual Tires Are Heating Up
The problem with the caller from CA's Subaru smelling like burnt rubber is the actual tires are heating up due to an improper torque split between the tires. Subarus are very sensitive to changes in tire pressure and thus the diameter and will wear the tires down. The driver mentioned 8 sets of tires. He has a bad torque split in the AWD system.
View 13 RepliesFord Excursion :: Electrical / Rubber Burning Smell
So I had been smelling an electrical/rubber burning smell on the Ex about a month ago. After a week or so I popped the hood and poked around. This is what I found!
Now I had a no start in May. The shop that I had it towed to checked the wiring harness, replaced the cam sensor, scratched the truck up and ran through 2 tanks of fuel.
I repaired the harness and all is good. What the 3 wires run/go to.
One was solid Gray with a white stripe.
One was solid Black with a yellow stripe.
One was Tan with a green strip.