Ford Super Duty (1999-2016) :: Truck Won't Start - Turned Over 3 Times And Just Stopped?
The whole trip over here weren't any problems. Yesterday I went to the store, started fine. When I walked out of the store, the truck turned over 3 times and just stopped. After that all I got was a click at the relay on the pass fender. I have good batteries. I have verified current through the fender relay down to the starter but I cant get it to turn over. Another thing to note is the solenoid got so hot it burned me.
This, I have never run into. I replaced it today with a new starter with no luck. Could I have a bad, "new" starter? What would cause the solenoid to generate so much heat just sitting there? The longer it stayed connected, the hotter it got.
Ford Super Duty (1999-2016) :: F250 - Series Of 5 Warning Beeps When Start In The Morning
Went to start my 99 F250 SD this morning and I got a series of 5 warning beeps. Kept repeating this for 5-6 times? What's up with that?
View 3 RepliesFord Super Duty (1999-2016) :: Truck Would Squeal All The Time On And Off When In 4x4
My truck was in 4x4 and would squeal all the time on and off. Here is the situation today, this has happened prior but i just didn't post on here until it lasted for 30 miles on the highway.
4x4 system:
-MM hubs
-all stock minus the hubs
-Pass side vac hose melted against tire (doesn't matter with the MM hubs but too much info is not a bad thing)
-Replaced u-joints in November
-the screeching when not engaged predates the MM hubs that i installed, it occurred when i had my auto hubs locked last year because they would not disengage
Trip:
-average of 45mph
-30 miles from NH to MA (route 3)
-truck was operating up to temp
When it occurs:
-Under Acceleration
-15-45 mph
- when going from stop-30 it makes a hollow tapping noise instead of the screech
- when hubs are locked and t-case is NOT engaged it screeches for about 1 miles and then stops
Sound in the video occurs within the first 8 seconds, its faint in he video but very loud in person. Highway didn't look that bad in the video but i was in a plowed sctretch other than that the last 25 miles were through about an inch of snow and slush.
Ford Super Duty (1999-2016) :: Morning Time Grumble / Truck Stumbling
I'm assuming I might have a coil going but I'm not sure. Yesterday morning and this morning I started my truck and it was fine, I backed out the driveway again truck was fine. I put it into D and pull forward it was fine till I hit about 1300rpm, then it felt trike the truck was stumbling, I went a little faster to 1500/1600rpm and it stopped, as soon as I slowed up and then hit the go pedal it started again at around 1300rpm and stayed till 1600rpm and then it went away. So this is twice now two days in a row this has happened the exact way and only in the morning and goes away with no problems. I hooked up my SCT X3 and there are no codes and when it stumbles I have no lights come up. What I should do?
View 14 RepliesFord Super Duty (1999-2016) :: 2002 Truck Started To Ping And Knock Worse Over Time
2002 5.4 super duty. My truck had started to ping, and knock worse over time. I did some research on this site, and I decided to remove my K&N air filter. Replace it with a traditional paper filter. Then I cleaned my mass air flow sensor. The results were great, no more knock and ping.I will check the MPG next to see if I get any improvements.
View 1 RepliesFord Super Duty (1999-2016) :: 2001 F350 V10 Won't Start Without Cycling The Key 5 To 10 Times
I have a 2001 ford f350 v10 dually. about 2 months ago it blew a plug out and i had it fixed and shortly after it developed a starting issue. It starts fine for a day or so then after it sits for a day it wont start without out cycling the key 5 to 10 times....It cranks fine just wont try to start or even sputter....took to a shop that replaced my jem Module and he had it for a week and only one time did it not start. I drive it home and it sits overnight and wont start the next day. took it back and he couldn't find out what is going on.
Its has started and ran just fine no issues once its running but shut it off for a couple hours you got a chance it wont start. I've eventually got it to start every time so far. The shop said my fuel pressure was 40 psi but would go down after it sat to about 10 to 20. The one time it did not start for the shop they said it had no fuel pressure but then he just cycled the ignition a few time and it started. What to check that would be normal like the fuel pump or relays and fuses. I should say early this year around jan feb it had the starting issue once and thought it was due to a autostart that was installed before I bought it and so got it going and just removed autostart when started having trouble with starting.
Ford Super Duty (1999-2016) :: Trailer Module Fault All The Time At Start Up?
Im getting this almost every time I start it up. It happened once about a month ago, then more often. Now almost every time.
Truck has 1700 mi
I hate to have to bring it to Ford so soon
Ford Super Duty (1999-2016) :: Truck Would Not Start - No Crank
Last night my truck wouldnt start. Drove fine all day, started up bunch of different times. Went to go home at night. No crank, everything else works, hear the fuel pump prime windows radio everything. smacked the starter a few times but no change. Checked the fuses and relays, all appear good. So im guessing the starter or the starter solenoid, but I cant find one on the truck just something that looks like it could be it attached to the starter.
View 9 RepliesFord Super Duty (1999-2016) :: Truck Won't Start But When It Does, Runs Perfect
So I just bought my first car, a 2003 F250 Super Duty with a 5.4 V8 gas engine with 150,000 miles that I will be using to tow my horse trailer. It has some things I need to fix. The main issue is that it wont start.
When I first went to look at it I tried jumping it, as the battery was dead and I still couldn't start it, though it was turning over. The previous owner then tried jumping it the next day, got it started and met me half way where I bought the truck. Turned it off where we met and it started right up again and I drove it home. It sat in my driveway overnight and then wouldn't start the next day, though it is turning over like before.
The battery is only a month old. There is another sensor issue where they had to disconnect the dash or the truck would randomly stop running. I believe it's the speed sensor? I received the repair reports from the dealer saying "code B1352 in memory for ignition key fault" and they removed an aftermarket remote start. "four U1027 and other U codes found, replaced crankshaft sensor".
Ford Super Duty (1999-2016) :: When Start The Truck In Garage / Cannot Seem To Get Into Reverse Right Away
For the past month or so, probably about a half dozen times now, I will start the truck in the garage but I can't seem to get it into reverse right away. It may very well be a timing thing with me depressing the brake pedal, but I'm not so sure. I've been backing the truck out of the garage for five years and I've never had a timing issue, and I'm definitely noticing it now.
Is/was there an issue with the brake pedal as it related to putting the vehicle in gear? Could it be something going on with the brake pedal for that function? It is very sporadic, maybe once or twice a week it happens (I don't take it out that much). Trying to gather info before hitting up my dealer.
Ford Super Duty (1999-2016) :: Batteries Run Down To The Point That Sometimes Truck Will Not Start
I have a 6.0L diesel that is not a daily driver so it sits for days and even weeks at a time. When I go to start it the batteries will be run down to the point that sometimes the truck will not start and I will need to charge the batteries. I was thinking about installing a battery tender and leaving it plugged in so the batteries will stay charged. I'm looking at the tender in the link.
View 14 RepliesFord Super Duty (1999-2016) :: Fuse 28 Keeps Blowing When Start The Truck
My truck keeps blowing fuse 28 in the inside fuse box. This fuse belongs to the ignition relay, and only blows when I go to start the truck. It is intermittent
View 14 RepliesFord Super Duty (1999-2016) :: 7.3L Truck Won't Start / Starter Not Engaging
Truck was running fine up until now. After the WTS light goes out, I crank it and.... nothing. It doesn't even try. It's not a battery problem. I have 12.6 V from each battery before and after cranking. The lights are bright, the horn works, the dash lights are strong and bright all both before and after cranking. It just doesn't want to engage the starter. I tried my backup key as well, thinking it might be a problem with the PATS. No dice. Where to start looking?
View 6 RepliesFord Super Duty (1999-2016) :: 2000 F350 - Truck Won't Start Sometimes
I have a 2000 f350 xlt and it has been very good until now. I can be driving normal and stop and park, when I get in and try and start it , it acts like the neutral safety switch is not working. the key turns and all my dash lights work, radio works, everything but the starter. I have to put it into neutral to get it to start. then after I stop again, it works fine. I don't get the problem all the time and I can't find a neutral safety switch.
View 8 RepliesFord Super Duty (1999-2016) :: 2012 F350 Truck Won't Start
I have a 2012 Ford F350 I've been looking to install a compressor on. I've poked a hole in the gasket that runs wires through the firewall and cut the tips off of a couple of the accessory wires. Went to go get some more parts and now the truck won't start! The lights and radio turn on when the car is turned on but the starter doesn't even click when I try to start it. What should I look at?
View 7 RepliesFord Super Duty (1999-2016) :: 2001 F350 Truck Won't Start
i have a 01 Ford F-350 7.3L quite and won't start I have replaced the ipr valve and sensor and the crank sensor and the truck still won't start...
View 1 RepliesFord Super Duty (1999-2016) :: Truck Will Start To Buck / Jitter At About 60 - 70 MPH
I have a 2006PSD 6.0. At about 60-70mph my truck will start to buck/jitter if i give about 5-10 percent throttle. It only happens at these speeds and i tried all sorts of fixes so far. Also there are no codes. Truck starts and idles great. At more than 10 percent throttle at 60mph, it acts normal. My current fix is just drive normally at 80mph. I also see talks about the possibility of the Turbo vanes being stuck, but wouldn't that happen at other speeds also?
Oil Change,
Fuel filter change
EOT and ECT within 8 degrees
FICM Change with Atlas 40
EGR Replacement (Unplugging and driving didnt change it.)
Replaced IPR valve
Turbo cleaned at 90k (Currently 140k)
Visual check of exhaust system and up pipes and no leak
Current mods
Fabtech 6" Lift
FICM Repair.com with Atlas 40
Blue Spring
Coolant Filter
Edge CTS
4wd ESOF hose kit
SS Brake Lines
Ford Super Duty (1999-2016) :: Truck Won't Start / Just Rapid Clicking Noise
So I was trying to put led turn signals in my truck then I decided not to because it was getting too dark. Earlier today started without complaints. Then after I was done with the headlights I tried to start my truck, nothing besides rapid clicking. First thought was battery was dead from me leaving the dome light on the entire time while working on it and also having the headlights on a good portion, so I decide I'll jump it. Get it all hooked up and and start the donor truck then wait 2 mins and try to start my truck still nothing but rapid clicks. I got the voltage meter out to check the battery and had 11.97 volts (that's not great but either way it wouldn't start when I tried to jump it). Put it on a charger? Bad starter? Solenoid?
View 11 RepliesFord Super Duty (1999-2016) :: 2000 F250 Truck Won't Start Consistently
I just bought a 2000 F250 SD, 4x4, 5.4, Quad Cab. I drove it off the lot, stopped to put air in the tires, jumped back in and it wouldn't crank. All of the dash lights worked fine. Tried jumping at the starter solenoid and got nothing. Got under the truck and jumped it off the starter, vroom, fired right up. Replaced the starter solenoid and had no issues for about 2 hours. Then it did it again. This time it wouldn't start at all. I towed it back to the dealer and they had it for 3 weeks.
Then yesterday I called and they said it was done. Picked it up, drove to the barber shop, got my hair cut, came back out and it did the same thing AGAIN. After jacking around with the shifter and turning the wheel back and forth 100 times it started. The key is kind of hard to turn sometimes in the ignition, so I'm thinking that the ignition cylinder needs to be lubed real good, but that shouldn't stop it from cranking the motor over, right? I was going to swap out the ignition switch, but I don't know if that will do any good either.