Ford Super Duty (1999-2016) :: 2010 F350 Shudders When Turning Right - Auto Locking Hubs
My 2010 F350 shudders when turning right. From what I read it could be the auto locking hubs not dis-engaging or sticking in the locked position. Tutorials show it's pretty easy to pull the auto locking Hub out taking out the three screws holding it in place. My questions is what type of grease do I need to apply to the auto locking hub once I have them out and determine that is what the issue is?
View 13 RepliesFord Super Duty (1999-2016) :: 2008 - Transmission Shudders In First Gear
When pulling my trailer away from a stop transmission shudders in first gear, feels like t c. Once it changes to 2nd, it clears up. Getting ready to take in for service. Any thoughts? Still under bumper to bumper warrenty. 2008 6.4 auto f 350. 26k miles
View 4 RepliesFord Super Duty (1999-2016) :: 2004 F350 V10 - ABS Light On
I have a 2004 F350 with the V-10 with a Fleetwood motor home on it. 46000 miles.The fuel pump started acting up and i have low fuel pressure. after a lot of testing i replaced the pump and all the hoses on top of the tank. of course you have to pull the tank to do this.
Nothing was touched to my knowledge that has to do with the ABS system.
After everything was put back together and i started the motor. the ABS light came on as usual during the pre-check then went off, and after a couple of seconds came back on, and stays on. it does this each time its started.
I read the most common problem is the rear speed sensor i tested it and it measured .95 oms so i replace it. the new one measures 1.8 oms.
Light is still on. so today i will be testing the front. to insure they are good. The fuses tested OK. My question is what else should i be checking?
Ford Super Duty (1999-2016) :: 2004 F350 V8 Shaking When Get Between 45 And 55 MPH
My 2004 F350 6.0L v8 has a weird shake when I get between 45 and 55 mph. Doesn't feel like its the tires, feel like the engine. I think I might have the #5 glo plug out. Is that it or could something else be wrong? If it is this how bad is it to drive on.
View 4 RepliesFord Super Duty (1999-2016) :: 2004 F350 - Won't Turn Over?
I have a 2004 F350. I go out to start my vehicle and it may or may not turn over. Other time it starts fine
View 1 RepliesFord Super Duty (1999-2016) :: 2004 F350 - 4wd First Not Shifting To 4lo
On dads 04 f350 the 4wd first wasn't shifting to 4lo. Would do 4hi and 2wd fine. Then motor on t-case went bad. Replaced motor 2wd and 4hi still good still no 4lo. Then just 2wd so we unplugged t-case motor and power probed motor got it to do 2wd, 4hi, and 4lo. So we thinking bad dash switch but power probed it and its working fine. So we r thinking VP4C3F-14B128-A/ chassis computer bad just behind/above glovebox. R there any test we can do to confirm its bad? We called local junk yards to see bout getting one, nobody had one. If this is indeed bad where is cheapest get one? What all years use this certain chassis computer??
View 5 RepliesFord Super Duty (1999-2016) :: Rear End Shudders When Braking At Highway Speeds
I have an '04 EX with 6.0. When braking at highway speeds the rear end shudders until I get the truck slowed down some. Around town speeds of 45 or less the problem is almost non-existent. It almost seems to be hydraulic instead of pads/rotor issue. Wouldn't a warped rotor show up at slower speeds as well? I have some good mechanics around, but have never found a great brake shop that I can trust. Go in needing pads and they try and upsell saying this or that is going out.
View 9 RepliesFord Super Duty (1999-2016) :: Low Power On Take Off / Shudders / Poor Shift Point?
hey there, new to your forum , been reading alot here , i have a 1999 f 250 super duty, frame was rotted, so i found a 2003 frame with motor , trans , transfer case & both axles , put my cab on it with the 1999 pcm , having trouble with low power on take off , shudders , poor shift points , at highway speeds , turn signal on , the speedometer will pulse same as blinkers, new head gaskets , timing chains , replaced trans with the old 1999.
View 7 RepliesFord Super Duty (1999-2016) :: 2004 F350 6.0L Diesel Won't Start
Truck started to feel like it was missing here and there. A couple rough starts in the morning and a very potent exhaust smell at startup. Then finally after a couple days of this, it wouldn't start.
At first it would try to turn over and almost did several times, then it degraded to just churning and churning with no close attempts to turning over. No codes thrown when we hooked up the code reader. I've had the IPR go out on me twice, the churning and churning is how it acted when the IPR(s) had gone out.
Towed it home and pulled the IPR, everything looked in order with it. Changed the upper fuel filter and oil/filter in an attempt to rule out the easy stuff. Tried to start it up last night after doing this and it churned and churned for awhile (about 2 minutes), then it almost turned over several times. By this time the batteries were too low to continue. Hooked up the code reader again and still no codes.
I'm planning on charging the batteries and replacing the lower fuel filter today, but not feeling real optimistic that it will do the trick. Any other issues to check for?
Ford Super Duty (1999-2016) :: 2004 F350 - 4x4 Hubs Always Needs To Be Locked In
Well long story short, I had the the factory hubs in my 04 f-350 and I was driving down the road and it started making this horrible popping noise. So I pulled over and couldn't find anything and just curiosity locked in the hubs and all was fine. Made me think my hubs were bad, so I went and bought the warren premium hubs, installed them. Went for a drive and still the same noise is there when they are in free spin. But once they are locked in its fine. What this could be? Wheel bearings?
View 4 RepliesFord Super Duty (1999-2016) :: Driveline Noise When Slowing Down In 4x4?
When I'm in 4 high and I coast I can hear something from the front drive line. It's a soft whirring/grinding type noise.
If I'm accelerating there is no sound . Only when the driveline forces reverse and the engine starts to slow the truck do I hear something.
With my hubs locked but in 2wd I don't hear anything.
Is this something to be concerned about or is it regular noise?
We have had a brutal winter so I've been in 4x4 75% of the time.
Ford Super Duty (1999-2016) :: Code P1747 - Shudders And Dies When Drop It In Gear?
It's a 1999 f250sd 5.4l auto. Has code p1747. Truck shudders and almost dies when you drop it in gear, put it back in park idles fine. I have read all the post on here about this and checked wires from trans up to pcm look and test well. Tested plug c1048 wires with the digital meter to body ground with battery unhooked and got 6.66k ohms on pin 11 circuit 925, 421 ohms pins 1 and 12. Plugged c1048 back to trans checked 925 w/y wire at plug c103 got 9.1 ohms back to trans. Is the EPC solenoid bad or is it pcm? I think its epc but want to verify before i take trans apart.
View 2 RepliesFord Super Duty (1999-2016) :: 2006 F250 V10 - Shudders Like Going To Stall When Coming To A Stop
250 2006 Superduty v10. Codes p2106 and p2135 ... Only occasionally when coming to a stop it shudders like it would stall. It happens for just a few seconds then ok again but wrench light comes on. After the next shut off and start the light goes out. I had the throttle control position sensor checked and they said it was ok. Got a software update at Ford. I hate to just start replacing expensive parts. I have about 60000 miles and it is a great truck otherwise.
View 1 RepliesFord Super Duty (1999-2016) :: 2004 F350 - Transfer Case Blowout
The transfer case on my 2004 F350 6.0L 4WD DRW, 230K miles, just blew to pieces Sunday night. See images below. What could cause this?
I just had the front drive shaft rebuilt with new universals and ball. It was making a metallic squealing noise after this.
I noticed that the front drive shaft did not spin freely when parked in nuetral and set for 2WD. I thought the front drive shaft would only engage when in 4WD.
Ford Super Duty (1999-2016) :: 2004 F350 - 4wd Won't Engage / No Dash Light
My 4wd doesn't engage on my 04 powerstroke. The dash light doesn't come on. I replaced the relays, switch, and 4wd module, I checked the fuses, all fuses are good, but fuse 31 doesn't get power to it. The voltage at the relay block reads 12v with the fuses out, but drops to around 7v when they're plugged in. I have no power to the Tcase (.15v).
View 11 RepliesFord Super Duty (1999-2016) :: 2004 F350 - Trip Computer Not Working
I just bought an 04 F350 with the 6.0 diesel. I have the trip computer but it doesn't seem to be working, the screen is just off. Tried the buttons, nothing. Checked the manual, can't find anything. Is there a trick I'm missing? Or is mine broken?
View 3 RepliesFord Super Duty (1999-2016) :: 2004 F350 - Vacuum Pump Not Running
I have a 2004 F-350 diesel. My vent selector is always on defrost so I suspected a broken hose but traced all out and all seem to be fine. I disconnected the line coming from the pump to the tank and no vacuum. The pump doesn't seem to be running but it's hard to tell with the engine noise and vibration. What tells the pump to run and how can I bench check it?
View 8 RepliesFord Super Duty (1999-2016) :: 2004 F350 - Horrendous Clunk Coming From Under The Cab
I just bought a 2004 f350 4x4. There is a horrendous clunk coming from under the cab as soon as I steer and at certain rpm while driving straight. I have researched this topic for hours and everyone says sway bar links. Well here's what I have done so far and the truck still has the same terrible clunk. New sway bar links, new sway bar bushings on axle, new front drivers hub, new front passenger hub needle bearing, both front dust seals on axle, greased all ujoints and balljoints, tightened up some bolts for the dual steering stabilizer, and shook the heck out of all other ujoints and the cab mounts and they all seem good...
View 14 RepliesFord Super Duty (1999-2016) :: 2004 F350 Won't Start / Relay Or Reset Cut Off
My 2004 F350 would not start yesterday, for the second time. I had just been driving it 30 minutes before, but when I tried to start it nothing happened. The dash light came on but nothing else, not even a click. Had to leave it overnight, and this morning it started completely normally. what this might be? It seems kind of like a relay or reset that was cut off and took time to reset itself. The first time it happened, it started up after 20 minutes, but yesterday it still wouldn't after an hour at which point I had to go to work so I don't know what the interval would have been if I could have stuck around and continued trying it.
View 6 Replies