Ford Super Duty (1999-2016) :: 2002 F250 - Front Wheel Bearing Noise
2002 F250 4 wheel drive manual hubs, 7.3....
My first thought was to have the tires rebalanced and rotated to see if it is tire noise? I am hearing damage on top of the noise from the 7.3, hard to be sure!
Ford Super Duty (1999-2016) :: 2002 F250 - Intermittent Noise Coming From Front End
I have a 2002 F-250 7.3. I was driving home from work on Tuesday (highway), I heard an intermittent noise coming from the front end, sounded like a rubbing/grinding noise. Yesterday on my way to wok, same thing, on and off. Yesterday on my way home the noise was constant, didn't go away. The noise comes at about 45mph and stays until I'm back under about 45mph, so mainly just on the highway. I put the truck in neutral and let off the pedal and the noise is still there which tells me it isn't engine related.
Yesterday after work I jacked up the front end, spun the tires, no noise. No play in the tires top/bottom or side/side. Took the tires off and what I did notice is the right axle u-joint is shot. I am hearing the noise in 2wd so I don't know if its the u-joint that's making the noise. Could it be a bad wheel hub bearing? Is it the u-joint? Maybe needle bearing??
Ford Super Duty (1999-2016) :: 2015 F250 - Hissing Or Whistling Noise While Accelerating
I have a 2015 ford f250 xlt crew cab, 6.2, fx4 with about 1200 miles on it. My questions are, I have noticed a hissing or whistling noise while accelerating. I took to dealer and was told it was the throttle plates not closing all the way.I was told they all do this. Normal? Very annoying noise with windows down. Another noise I have been having is the brake pedal makes a popping noise while applying pressure to brakes. Dealer said brake pedal assembly was out of alignment. They said was out of alignment 1/8". After adjustment within a few days popping started again.
View 6 RepliesFord Super Duty (1999-2016) :: 2010 F250 Whistling Noise While Traveling About 70 Down The Freeway
I have a 2010 F250 extend cab 4x4. While traveling about 70 down the freeway I get a whistling noise. It is usually worse when the wind is blowing hard or behind a semi. Wind makes the noise louder so I assume the noise is coming from the air hitting something. Slow down to 50 and noise goes away. Do not think it is mechanical because when a gust hits the truck it is worse. Checked all the windows, windshield and rubber parts. Where I should look.
View 9 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Front End Noise / Slight Vibration In The Floor
2002 Ford F250 4x4 Superduty Lariat (4 door). Just changed the locking hubs to a new set of Warn manuals. I began to periodically hear what sounds like a rumbling/bearingish/howling kinda sound. Happens when you hit a bump at any speed...then howls till you hit another bump..goes away..then process repeats. Come to a complete stop, and the sound usually goes away till you hit another bump. The hubs are "free" at this time.
Heres the weird thing...when the noise starts...I switch it into 4 wheel drive on the dash...the sound instantly goes away. Click it back outta 4 wheel drive (hubs are still unlocked this whole time) and the sound is gone. drive some more down the road, maybe hit a slight bump, and the sound returns. Switch it back into 4x4...sound instantly goes away. Its not really in 4 wheel drive, cause the hubs aren't locked in...but that cures it till I take it back out. What could be causing this howling ? Its getting worse, and you can feel a slight vibration in the floor now when its doing it.
Ford Super Duty (1999-2016) :: 2011 F250 - Engine Idles Rough Until Warms Or Accelerator Is Pressed Down
On a cold crank the engine idles rough until it warms or the accelerator is pressed down. Also runs rough going up hills or towing. Check engine light is on and is throwing the code for bank 1 to lean and cat performance below threshold. Cats have been tested, good. Fuel trim tested, good. One mechanic said noth8ng is wrong with it well, there is. 2011 f250 6.2 gas...
View 5 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Rattling Noise Coming From Front Suspension When Going Over Small Bumps
2002 F-250 7.3 4x4 ...
I have a rattling noise coming from the front suspension (both sides) when going over small bumps. Most people point to ball joints, but I find my case odd because I just replaced
Upper/Lower ball joints
Track bar
Tie rod ends
Shocks
Front U joints
Drag link
I did not touch the leaf springs or the sway bar, except to grease the links, which otherwise looked good.
Ford Super Duty (1999-2016) :: Truck Missing Bad After It Warms Up
One day after my mechanic replaced the heater core my truck started to misfire after the motor warms up and is under load. No codes and nothing pops up when hooked up to o a scanner. It's been cold in the morning and when I start it up it runs like a top. But after it warms up it start to miss a little, then it gradually gets worse especially when under a load at higher speeds. I thought it was a vacuum hose or something got left unplugged.
View 7 RepliesFord Super Duty (1999-2016) :: 2002 F250 V10 - Squeak From Under The Truck
I have a 2002 f250 super duty v10 with the manual transmission... It has aloud squeak from under the truck when Im slowing down or maintaining a certain speed. The squeak goes away when I accelerate or if I push the clutch in. It does have a vibration to it when im speeding up. And shakes bad sometimes when I let off the clutch from a stop..
View 1 RepliesFord Super Duty (1999-2016) :: 2002 F250 Truck Wanders All Over Road
It's an 02 f250 4x4 crew with 7.3, 6 in lift and 35 in tires. It has all ways wandered a little bit and I just accepted it. I changed everything in the steering from ball joints, tie rods and drag links less than 2000 miles ago. Everything still seems good and tight. Recently it has gotten a lot worse so I checked again and everything seems to be tight. Where to or what to check next? It's to the point I don't feel safe letting my wife drive it and I don't enjoy driving it.
View 7 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Alarm Won't Stop Going Off And Cannot Start Truck
I have a 2002 F250 7.3l with an aftermarket alarm. I can't read what the third letter is on the decal MV? 2000 Modular Vehicle Security. I added a pic of the alarm decal below. The key fob it had was aftermarket for the alarm and stopped working about a year ago. Today I unlocked the drivers door with the key and the lights started flashing and I can hear a clicking sound. It done this a few times back when the key fob still worked and I just kept hitting lock and unlock until it finally stopped. It won't let me start the truck at all and I have tried unhooking the batteries with no luck.
View 4 RepliesFord Super Duty (1999-2016) :: 2002 F250 - IAC Changed - Truck Idling Too High
I just changed out my IAC. Truck is still idling too high. When I squeeze the host to the IAC it idles down. When I unplug the IAC the truck immediately dies.
Does the IAC talk to the the Throttle position sensor? Should this be my next part to change?
2002 F250 5.4L ....
Ford Super Duty (1999-2016) :: 2002 F250 - Brake Went To The Floor Almost Sinking The Truck
Today I was going to launch my new boat and when I backed down the ramp, the brake went to the floor almost sinking the truck. Long story short, the brake line that runs along the frame to the rear brakes rusted through at a bend that I couldn't see. Seems the line is about 8 feet long. What I'd like to know is can I replace it without dropping the fuel tank which of course I just filled yesterday and can I obtain one at a ford dealer or will I have to order one. My truck is my only transportation.
View 1 RepliesFord Super Duty (1999-2016) :: 2002 F250 V10 Truck Cranks Strong But Will Not Turn Over
My 2002 F-250 v-10 sat for over a month with me in the hospital for spinal reconstructive surgery. Battery was dead but has been charged and tested as good. The truck cranks strong but will not turnover. I am unable to do other diagnosis, what might be the problem.
View 2 RepliesFord Super Duty (1999-2016) :: 4r100 Shifts Great Until The Truck Warms Up
I had some more time to mess around with my truck. The 4r100 shifts great until the truck warms up. After about 10 to 15 minutes of driving it starts. With the gear selector in D and under acceleration it will shift at about 2k rpm's and will be in third gear by 25mph. If I climb to higher speeds it will only shift out of O/D when I get my foot into it. It will not downshift into any gears until I am almost completely stopped. It will downshift and hold gears great if I use the column to shift. I'm stumped. No CEL or flashing O/D light.
Things I have checked:
TPS
VSS
All connections to the transmission
Set tune back to stock
Transmission fluid & level
Will the transmission still store codes even if the O/D light has never flashed?
Ford Super Duty (1999-2016) :: Windows And Radio Will Not Work Until The Truck Warms Up
When it is cold the windows & radio will not work until the truck warms up?
View 3 RepliesFord Super Duty (1999-2016) :: 2002 F250 Truck Won't Start / Cranks Fine But Just Will Not Turn Over
I have a 2002 F250 7.3L and it wont start. Its been sitting for the past few days in the cold because the batteries were shot but was plugged in the whole time. I replaced the batteries today and even poured diesel 911 5 hours before trying to start it in case the fuel was gelled. It cranks fine but just wont turn over.
View 2 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Parking Lights Stay On When Truck Is Shut Off
I have a 2002 f250 SD v10 4x4. I had a ground wire break fixed that know noon of my instruments work. Dash lights up but nothing moves. Pulse my parking lights stay on when the truck is shut off or when I turn lights on then off. I have to disconnect the battery to get hem to shut off.
View 3 RepliesFord Super Duty (1999-2016) :: 2006 F350 - No Start Condition After Truck Warms Up / ICP Location
Where the ICP is located on a 2006 f350? I have a no start condition after the truck warms up, everything else is fine. Started fluid works to crank, I suspect the ICP and /or Orings.
View 4 Replies