Ford Super Duty (1999-2016) :: No 4WD Light When Turn The Key On
I am having some problems with my 4WD, it's not working. When I turn the key on, I do not see the 4WD light. I have locked the hubs with no change. I noticed that my switch was not illuminated either, so I started there. I took the switch out, cleaned it up a bit and reinstalled it. Now it's illuminated but still no 4WD. I have swapped the two relays and still nothing. I have checked all the fuses under the dash and they were all good.
I don't believe the switch is the problem(they seem to be pretty simple and it doesn't look like there's much to go wrong. Is there a better way to test the switch other than just seeing the illumination light on? I plan on testing the transfer case shift motor tomorrow but I don't believe that is the problem since I'm not even getting the dash 4x4 light.
My other thought is replace the GEM but I was trying to rule out a few of the cheaper alternatives first.
I almost forgot to mention, approximately 7 months ago, my buddy and I were going coyote hunting. Being the genius he is, he didn't unload his rifle while we were in the truck and at some point, something happened and he touched off a round.
The shot was a well placed point blank shot and went right through a large group of wires on the passenger side trim panel under the glove box.
Initially, he bagged himself a trophy size Superduty but after some emergency surgery and a bit of soldering, everything has been fine.
I haven't used the 4WD after this incident but I can't say for certain this caused it because I haven't checked until now. Do you think this caused it? Is there a hidden/residual problem that I missed?
Ford Super Duty (1999-2016) :: 2001 - Power Steering Hard To Turn
Every time I try turning at idle or with foot on brake it wont turn at all. Is this just a super duty thing or vacuum leak or power steering pump going?
View 9 RepliesFord Super Duty (1999-2016) :: 2001 F250 5.4L - How To Manually Turn Over The Engine
I have an 2001 F-250 5.4L.
It has the Triton engine and the problem with spark plugs blowing out. I have a kit with thick inserts that I'm going to install. I need to drill and tap the heads, but first I need to get the piston in the cylinder I'm working on to get close to the bottom and have all the valves shut. But I can't manually turn the engine over. I tried using a long ratchet with a socket that fits the nut on the crankshaft pully, but the nut just seems to tighten more, instead of turning the engine over.
And trying to turn the fan pulley doesn't do it either. Also, using the electric start for a split second at a time still seems to turn the engine over too quickly for me to get the piston where I need it. Do I need to pull all the spark plugs to do this? I really just wanted to work on one cylinder for now, instead of opening up a can of worms.
Ford Super Duty (1999-2016) :: EBrake Light Show Up On Dash / Turn Signals Stopped Working / Heated Seats No Longer Turn On
Coming back from a trip I got a e-brake light show up on the dash then noticed the signals stopped working and the heated seats no longer turn on. I scanned it with my AE and got a brake fluid sensor error come up but nothing about the signals .... is this a common problem or is there a connection between all this? 2003 F350 6.0L .....
View 2 RepliesFord Super Duty (1999-2016) :: Turn Off Oil Change Light?
I change my own oil. I've done it at 2K, and 5K. Odometer just hit 5500 (Had it almost a year, Man I gotta get out and drive it some more!). Now when I start it up the "engine oil change soon" message appears. I can hit reset on the steering wheel, and it goes off, but the next time I start up, it's back. How can I let the truck know that the oils been changed already?
View 6 RepliesFord Super Duty (1999-2016) :: Tow / Haul Light Turn On By Itself?
I just noticed that on the highway sometimes (3 times) the tow/haul light is lit. I press the button and it will not turn off and when I get off of the highway I can tell the trans is shifting through the tow/haul strategy. Once I shut the engine off and restart it the light goes off and it drives normal. When it is driving normal I can turn the tow/haul off and on with no problems but noticed the light coming on it's own recently.
View 10 RepliesFord Super Duty (1999-2016) :: Brake Indicator Light Comes On When Turn On The Key
My '99 250 SD - Turn on the key and the brake indicator light comes on.
Start it and the indicator turns off, the E-brake is still on but no light.
It does have an aftermarket radio installed, by PO.
Ford Super Duty (1999-2016) :: 2001 F350 - Grinding Noise When Drive Slow And Especially Turn To The Right
Have an f350 4x4 diesel that when I drive slow and especially turn to the right it makes a grinding noise. It seems to either go away or just gets muffled by road noise when cruising. The ball joints were bad so I replaced them and I figured with this especially when I turn right it had to be a wheel bearing so I replaced both of them and still same thing. Don't want to throw money at it hoping to fix the issue. Also front duff is full of oil.
View 5 RepliesFord Super Duty (1999-2016) :: 2000 F450 Won't Turn Over - Airbag And ABS Light Lit Up
I have a 2000 ford f450 with the 7.3. the truck sat for about three month and now it won't turn over. When I put the key in to start it only the airbag light and abs light up. when i got to turn it over I can hear the starter just click but the engine wont crank. I have checked the batteries and the starter and they are all good. i have also checked the shiftier position sensor on the tranny and it fine.
View 5 RepliesFord Super Duty (1999-2016) :: 2001 F250 - ABS Light Is On And Overdrive Light On Shifter Is Flashing
I recentlyHad to replace the right front wheel bearing and after the install the speedometer and turn signals don't work, the ABS light is on and the overdrive light on the shifter is flashing. I've replaced the VSS on the rear diff, pulled and cleaned Speed sensors on front hub?
View 2 RepliesFord Super Duty (1999-2016) :: 2001 F350 XLT - ABS Light On
My abs light is on. The guy I bought it from said he thought it was the sensor but who knows. Is there a way to test the sensors to see if they are working? Also can any other possible issues to look for? 2001 f350 7.3 xlt...
View 3 RepliesFord Super Duty (1999-2016) :: LED Brake / Turn Signal Light - Loud Squeal In The Cab
I have an 2001 Ford F250 V10 CCSB. I installed 3157 LED Brake//Turn light. Now when I turn in my left turn signal it blinks fast which I can live with that but it would be nice if it blinked at the regular phase. Here my big problem. When I turn on my right turn signal there's a loud squeal in the cab of my truck. !!!
View 8 RepliesFord Super Duty (1999-2016) :: 2001 - Theft Light Blinking?
ive got a 2000 v-10 excursion with 111k. Never had a problem like this before but last week I was driving home an noticed the theft light blinking while I was driving. Got home shut it off. next morning went to start it and nothing! when the doors open it makes a clicking noise under the dash. if I jump it the truck will start right up. If the batt is disconnected them re-connected it will start once until turned off and then nothing until its disconnected again. I ve got an elk hunt in 2 weeks and need to figure it out!
View 6 RepliesFord Super Duty (1999-2016) :: 2005 F250 Fx4 Won't Activate When Turn The Key Light Illuminates Then Turns Off
My 2005 ford f250 fx4 won't activate when I turn the key the light illuminates then turns off but when I start the truck and select it it doesn't go into gear
View 2 RepliesFord Super Duty (1999-2016) :: Dome Light Stays On / No Door Ding / Radio Won't Turn On
I have a 2003 Ford F-450 with the 7.3 Powerstroke. The problem I am having is the dome light stays on, the map lights will not turn on, I have no door ding with the key in the ignition, and the radio wont turn on. If I press the clock button on the radio the clock comes on but the radio will not come on when I press the power button. What it may be? I already hosed the door latches with lubricant and that changed nothing. I checked all the fuses they are good.
View 2 RepliesFord Super Duty (1999-2016) :: F250 - 4x4 Light Flashing Continually When Turn The Switch To High
I have a 2010 F250 super duty. I use it for work so I am not sure what happened to it as others have driven it, but here is the issue. When i start it up in 2wd, the 4x4 Low light flashes continually. If I turn the switch to 4x4 high, the 4x4 high light flashes continually. if i turn it to 4x4 low, that light flashes continually. I have read the forums but haven't been able to find the problem/diagnosis for this.
View 2 RepliesFord Super Duty (1999-2016) :: 2001 F250 7.3 - Overdrive Light Flashing
Tonight i noticed overdrive flashing. No changes in shifting, truck shifted fine. I shut it off when i got home, started back up, light was not blinking, not sure if its like the check engine light and stays on or not. Where light blinks but shifts fine?
View 10 RepliesFord Super Duty (1999-2016) :: 2001 F350 - Battery Light Was Blinking
I currently am driving a 2001 F-350 V10 SuperDuty, and recently the battery light was blinking. I replaced the alternator in it, but it didn't work. I thought it was bad so I went and got another and it still didn't work. Turned out that the alternator wasn't big enough. I then went BACK and got a larger alternator, and it still won't work. Now the battery light is solid, and I'm getting absolutely no charge out of the alternator. I checked all the fuses and nothing is wrong. It seems like all the things you think could be wrong are running perfectly fine! What could be wrong. The truck will start, and idle, but will run off the battery only.
View 14 RepliesFord Super Duty (1999-2016) :: 2001 F250 - 4x4 Light Is Permanently Lit Up On The Dash
2001 Ford F-250 7.3 Lariat, Crew cab, 8 ft bed. Have had the truck since about 2007 and 4x4 has never worked. It has the typical ford "self rotting" vacuum lines (which have all been replaced along with the hubs themselves). Took it to a mechanic a few years back and he n-word rigged it (for a lack of a better word) and bypassed a lot of vacuum stuff and it still didn't work. The weird part is this-- the 4x4 light is permanently on on the dash, even if the switch is in the 2wd position. Flip the switch and nothing happens. No sounds, nothing. No mechanic can fix it and I have yet to find a forum with someone having the same problem. (Worth manual transfer case swapping it?)
View 10 Replies