Ford Super Duty (1999-2016) :: Overdrive Switch Blowing PCM Fuses
Just recently I started blowing PCM fuses (#19 in the fuse panel) After replacing lots of fuses, I finally figured out what was causing them to blow. I unhooked the overdrive switch, and no fuses blow. I can't see anywhere where the wire is chafed. Maybe it is chafed, and I can't see it or the switch is bad. Can the whole OD switch be replaced? If so, how??
View 13 RepliesFord Super Duty (1999-2016) :: 2006 F350 - Keeps Blowing Fuses For The Brake / Turn Signals?
I have a 2006 F350, it keeps blowing fuses for the brake/turn signals. The puzzling​ part is it only does this when the truck is running.
View 2 RepliesFord Super Duty (1999-2016) :: 2000 - A/C Blowing Through Defrost Vent?
I have a 2000 f250 4x4 7.3 diesel. I had problems with my a/c and controls for sometime now. my a/c was blowing threw the defrost vent. I was told my blend door was bad. I bought a new blend door installed it,still doing the same thing. I was told to check my vacuum lines. I check them, they were bad. I replace my vacuum lines and my vac pump as well. that fixed my problem blowing threw the defrost vent. I can control my air flow from floor,dash vents and defrost vent. the problem I have, I not able to control my temperature when I turn my center from red to blue. It blows hot air and the air that is coming out of the vents isn't very strong at all.
View 1 RepliesFord Super Duty (1999-2016) :: 2000 F250 Blowing Instrument Cluster Fuse?
My wifes truck is having some issues right now. Last week I was driving it down the highway, and the gauges all went off, the door buzzer was sounding, and the door locks where going up and down constant when I had my foot off the gas pedal. Found the fuse and fixed it with a replacement, but its down it three times all together since then?
View 9 RepliesFord Super Duty (1999-2016) :: Blown Fuses / Won't Shift Out Of Park
I did a bad thing last night, I put a jumper in the 20 amp cigar/data link connector and all kinds of things went out, will not shift out of park, no directional, power windows, power mirrors, no brake lights ,no hazards, no wipers, no interior lights and I don't know what ever else is not working.
View 3 RepliesFord Super Duty (1999-2016) :: Power Point Fuse Keeps Blowing
I blew 2 fuses the other night, one in my power point and one in my lighter. I was using my ipod in the lighter and my beacon light outta the powerpoint. i changed them both (20 amp) and the lighter is fine but the power point keeps popping. What the problem might be? I would take it right to ford but unfortunately my warranty expired 9 days ago...
View 12 RepliesFord Super Duty (1999-2016) :: 2002 F350 - No Radio Even All Fuses Are Fine?
02 f350 xl with factory cd player. I have power going to the unit like the clock but will not turn on completely. I have checked all the radio fuses and they are fine. I also swapped another factory radio from another one of my trucks and it does the same thing. Any thoughts?
View 4 RepliesFord Super Duty (1999-2016) :: 2006 - Black Smoke Blowing Out The Exhaust - No Power?
I have a 06 6.0 Powerstroke 6 Speed every time I get on it or even try to get going I have no power and I have pure black smoke blowing out the exhaust somebody told me to change the fuel filters which I did which they were pretty nasty then after I did that I seem to still have the same problem so then they told me to check the EGR valve put injector cleaner in it to clean the injectors which I have not done a gr or injector cleaner yet just wanted to know, what it could be or what I can do to prevent the black smoke I have no power either...
View 1 RepliesFord Super Duty (1999-2016) :: 2000 - Rough Idle - Low On Power
I have a 2000 F250, SuperCab, 5.4 triton, 100,000 miles. It's been a great truck - got it at 63,000 miles. Once engine warms up, it has rough idle, and shift rough. I can give it gas to RPMs up and it smooths out some but is low on power. If this was my 76 F150, I would guess the vacuum hose off the intake manifold to the transmission came loose.
View 6 RepliesFord Super Duty (1999-2016) :: 2000 - Power Steering Too Lose?
All of a sudden steering is WAY to easy i can flip it one way or the other with my finger. Front end is tight no lose tierods etc and no play in steering box when you turn it the steering turns immediately.
Thinking power steering is going bad maybe over pressure? Repair will be a pain has central hydraulics lines all in way. 2000 F450 7.3 ....
Ford Super Duty (1999-2016) :: 2000 - Power Mirrors Adjustment?
I have a 2000 Ford F-350, I can only adjust the mirrors (both) in one direction, (to the left only) the up and down movement works also.
View 14 RepliesFord Super Duty (1999-2016) :: 2000 F550 / No Power And No Start
I'm working on a 2000 7.3 that was running but had no power so we changed out all the injectors and glow plugs and rebuilt the turbo now there is no start ...
View 2 RepliesFord Super Duty (1999-2016) :: 2000 F550 Lost Power / Shakes And Dies
I have a 'new-to-me' Ford F-550 with the vaunted 7.3 Powerstroke diesel engine. The truck only has 120k miles and ran great when I bought it. Last week it began acting up. While driving on the highway, it lost power, began running rough, and once I pulled over, it died.
After a few minutes, I tried re-starting the truck, it started, but had little to no power....I could get up to 30-35mph and then it would slow down and lost all power. I let the truck sit for about 20 minutes while I refilled the diesel tank, it started right up and drove normally for another 10-15 minutes and then the same thing happened again.
The truck sat for a day and then drove normally for two entire days. This morning, it began acting up. It is the same as before..... what to do with this type of issue?
There is not a check engine light lit (yes, it works). The diesel is from a good source that is not causing problems in anything else. The truck is otherwise strong.
Ford Super Duty (1999-2016) :: 2000 F250 Engine Overheating / Low Power And Sputters
I just bought this truck for a pretty good price it has 225000 on it the engine was over heating. The guy put new rad, new water pump, new fan clutch, and a new heater core with thermostat. The truck still over heated so I pulled the thermostat to see what happens and the truck over heats even faster. All this happens while driving regardless of ac on or off. I got a motor and put a motor in it with all new pump and thermostat. I put new coolant in and flush radiator. I cut a hole in the cat to see if the cat was plugged for the truck seems to have low power and sputters. With in 1mile the truck over heated dumping all the coolant out of the system which the truck did as well before. Will the diesel rad work in this truck I have a diesel one I can put in since its a bigger rad?
View 14 RepliesFord Super Duty (1999-2016) :: 2000 - Power Door Locks / Won't Lock Or Unlock
2000 superduty. When you hit the door lock/unlock button, they try but won't move up or down on any of the 4 doors. The switches no longer are illuminated either. Where or have a wiring schematic for the drivers door with power windows/locks? I have done some testing for power, which seems to me there isn't enough voltage going to the actuators, but I can't seem to find power anywhere. The power mirrors don't work either. All fuses are good.
View 8 RepliesFord Super Duty (1999-2016) :: 2000 F250 2wd V10 - Loss Of Passing Gear Power
When passing or going up small inclines on freeway, my F250 seems to make the shift to the passing gear but then almost a complete loss of power. Jerks around for a few seconds and finally provides enough power to at least get back to the original speed. (It feels kind of like the lurching, etc. I used to get when those stinking GM diesel injectors would act up in the 1990's.)
It also stays in first/second as I punch it while entering the freeway and doesn't want to make the shift. I can put it in neutral and race the engine, so I don't think it is an engine problem, unless the transmission is electronically controlled. I have a lot of computer dashboard gauge resets after falling to zero and sometimes have to set and release the parking brake to get the auto door locks and windows to work. (That started after a car break in where the door electronics were apparently pinched, but that was a couple of years ago.)
Does it sound like the transmission or electronics? In the old days replacing an automatic transmission filter seemed to fix a lot of transmission issues. Not an option now, but would I expect to see any results doing a transmission flush and fluid change? It's probably been about 60000 since I had that done. (157000 now).
Ford Super Duty (1999-2016) :: 2000 F250 5.4L - Power Steering Pump Flush
Any link on how to do a flush on the 5.4L power steering pump? I screwed up on installing my new power steering pump and used power steering fluid (new to ford) and it is moaning so I need to flush and get mercon ATF put back in the lines. The write up I found was for the diesel hydroboost and I do not have that setup.
View 3 RepliesFord Super Duty (1999-2016) :: 2000 - Power Door Locks Make Noise But Don't Work
2000 crew cab powerstroke 4x4... It's a XLT, six inch lift, weld wheels, BFG all terrain (50%). 277,000. One owner. Clean Carfax. All service done by purchase dealer. Mostly stock other than that. Dealer just replaced AC compressor and charged system. Interior is good, except for driver's edge seat. Good cleaning and ok.
The (my?) Truck.Downside. Power door locks make noise but don't work, remote mirror switch intermittent, stereo broken. During my test drive (alone) it drove straight, stopped straight and hard. 4x4 engaged and worked well. No noise in system. Good acceleration. No rattles or noises. Doesn't drip anything on the ground. Cruise and all accessories work.
I'm supposed to go in Monday. My girl is afraid of the mileage. But it seems well maintained for 17 years old. Is 10k an acceptable price? They wanted 11,900. Anything I should be looking for?
Ford Super Duty (1999-2016) :: A/C Blowing Warm Air?
this doesn't make any since to , what's going is, sometimes the AC starts blowing warm air, I found out if I goose it I can hear what sounds like the damper door slamming shut, then AC starts blowing cold again. I changed out electric vacuum pump, but it still does it, starting to get worse & its hot.
Truck is a 2002 f250 powerstroke, the way I understand it, is only thing vacuum pump is supposed to control is AC & 4 wheel locks, my truck is only 2wd. I don't understand why when when I goose it ,it goes to working, what can I do to fix this.
I just found out the " heat and cool "adjustment is electrical, not vacuum, it goes to something under dash, but what it is, heat strip, reastat(sp)??? where and what damper am I hearing. It is not like heater is on ,not that hot, feels like ambient temp, I am at a loss...