Ford 6.0L Power Stroke Diesel :: Random Starting - Spit / Sputter And Die All While Puffing Black Smoke
So the Ex is starting to behave badly again in the morning! From time to time, when starting first thing in the AM cold the Ex will spit sputter and die all while puffing black smoke. Total time is under 3 seconds.
Start it again and it is fine. I have not had this issue before. There are absolutely no codes what so ever! And since it is such a short time sputtering nothing really shows up on the ScanGauge 2.....
Ford Ranger / B-Series :: 1998 - Occasional Stumble For A While / Blowing Black Smoke
1988 4.0 - noticed fuel mileage going down and an occasional stumble for a while but now I am getting some black smoke more when I let off the throttle than when I going down the road if I rev the truck get all kind of black soot all over the floor otherwise runs fine idles fine the iac has been replaced air filter replaced check the fuel pressure regulator for any gas leaking into the vacuum line and its clean.
View 14 RepliesFord Ranger / B-Series :: 1994 V6 Idles Low - Surges Up / Down - Black Smoke Puffs And Smells Like Gas
I have a 1994 Ford Ranger with 4.0 V6 Automatic. The problem is when it idles it idles low and surges up/down and pushes a very small amount of black smoke puffs and smells like gas. I have installed new coil, new wires, new plugs, new ect, new crankshaft position sensor, and new maf. It has new intake manifold, new injectors, new alternator and it still does the exact same thing. Nothing is phasing it. I ran the key on/engine off test and got egr codes and a map sensor code, then ran the engine running test and got 998 and 126 code. The 998 code says that its basically a hard fault/ have no idea.
I do know this is a donor engine out of another year not sure what year, but i know when i ordered the coolant temp sensor the only ones that would plug into it are the years 1990-1993. Now here's my other question, why would the computer give me a map sensor code when truck doesn't have a map sensor? It has MAF sensor, and why egr codes? The truck doesn't have egr and never came with it. I do know I've unhooked battery and replaced the maf and its like it doesn't even recognize it? Could it be the ecm/computer bad or needs flashed?
Ford Ranger / B-Series :: 2002 - Started Running Rough / Trying To Stall Out / Black Smoke Coming From Exhaust
2002 Ford Ranger edge 3.0 flex ... Truck was running fine and giving me no issues. I woke for work the other day and went to get coffee and truck wouldnt start. I could hear fuel pump running and knew it wasnt that, it was acting flooded. So today I pulled fuse from fuel pump relay, and got it to start. Put the fuse back in and ran to gas station. On the way to the gas station it started running really rough, very low and rough idle, trying to stall out. I noticed it had black smoke coming from exhaust. I got it home, and got it to start barely, and it has the same very low and rough idle, but my oil gauge was going crazy, flickering back and forth all crazy, and the idol is terribly rough and eventually stalls out. Earlier today I did put new spark plugs in it, but not sure that has anything to do with the issue. I also hooked it up to a computer and it isnt throwing any codes.
View 13 RepliesFord Ranger / B-Series :: 1994 - Running Rich / Strong Exhaust Smell
1994 reg cab 4.ol 13ok.. my wife just got it, been doing some small things like replaced dome light, replaced cargo/third brake light, truck starts and seems to run ok. but i get a headache in it which i believe is carbon monoxide, has a leak or something? i text previous owner, he said he replaced 02 sensors, but didnt say if they were bosch or a good brand.. also trucks has a oil pressure and coolant temp gauge fitted on by the gear shift as the dash gauges for those functions are out. Does this mean the CTS may not be working and affecting fuel/air I do not know these trucks i only just found out what this strange silver looking thing was it is the IAC, I Believe, then there is this black plastic vacuum type cylinder by the passenger side firewall, what is that? and right against the drivers side fire wall is a small reservoir type thingy, is this something to do with ABS? i do have an ABS light on, was hoping it was the bulb out on the third brake light or something quirky like that no such luck its still on after starting engine. but i am concerned about this running rich/strong smell as we really cant take it far as is it, its dangerous, may have to get a smoke test? Just got the truck, trying to get caught up..
View 8 RepliesFord Fuel System :: 1987 - Loss Of Power / Black Smoke And Also Dying When Stop
So my 1987 Econoline Van was running fine until recently we noticed loss of power going up the slightest of hills and it will only hit 55 max with gas to the floor. Its shooting out black smoke and also dying when we stop. We are getting very poor fuel economy as well.
We got a tuneup, oil change, new air filter, etc. We also had a few electrical issues due to a short we thought we had fixed completely... So I'm wondering if it could be the timing? Cause it'll idle low, then high, then bog down and lose power...
Also was thinking maybe bad fuel pressure regulator or fuel pump....but how would I check this? And since we did experience a short, could we have blown a sensor too?
Ford Ranger / B-Series :: Black Peeling Rubbery Plastic Under The Side Windows
What is the proper name for the black rubbery plastic material that is located under my side windows of the doors? It is peeling now!! I would like to replace them because I am pretty sure it is the source for water intrusion into my truck.
View 3 RepliesFord Ranger / B-Series :: 1994 2.3L - Coolant Leak Coming From Under Black Plastic Cover
I noticed green coolant leaking from bottom of black, what I think is called, timing belt cover. There is 188, 000 miles, and when I changed the timing belt, I did not change the water pump, although I did change out the thermostat. I have done a lot of work on this truck in the past. I checked the oil and no signs of water or coolant mixed in. The water pump is not weeping from the top well. I rely on this truck and the way I look at it is I may just keep driving it until it goes kaput (its real beat up). Should I go to an auto parts store and see if I can buy some sealant. I would guess it is either the water pump or maybe the timing cover gasket? I have inspected all hoses, and I see nothing. The leak must be coming from somewhere under that black, plastic cover. I am capable and willing to do just about anything other than perhaps a full engine pull, although I have the wherewithal to do that too if absolutely necessary.
View 9 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 Puffing Out White Smoke
I just bought a 2005 ford f250 6.0 diesel. Im used to gas engines but not to familiar with diesel yet. But my problems are it puffing out white smoke. I've just did an oil change with full synthetic motorcraft filter. I changed out the fuel filters. Ran some fuel cleaner put some oil additive (both diesel hot shot brand) . Drained out any water and cleaned out the pump. Took out the egr and cleaned it.
I just installed a coolant filter and drained out most of the ford gold and used something with CAT ECI rating. The smoke smells like unburnt fuel. I'm not losing any coolant. I bought a scan gauge. The fcim doesn't drop below 47 volts. The coolant and engine temp stay around the same. As weird as it sounds it won't smoke all the time. It will smoke really bad then it won't like nothing ever happened. Besides it being an injector failing or something along with fuel pressure I'm not sure.
Saturn - S-series :: White Smoke Coming From Tail Pipe - Smells Like Something Is Burning / Oil Is Black
I am not sure what is going on with my car. I have a 1998 saturn sc2 and this morning it started smoking from the tailpipe. The oil is black but the smoke smells like something is burning......
View 3 RepliesGolf VI R :: 2012 - Puffing Blue Smoke Between Shifts?
I have a 2012 r with 30k miles that's has been on apr stage 2+ for 16k miles and it has recently started puffing blue smoke in between shifts.
View 13 RepliesFord Ranger / B-Series :: 1990 - Broken Fuel Line At Fuel Pressure Regulator?
I have a 1990 Ranger with a 4.0L that I just changer the intake gasket on. I broke the fuel line at the Fuel Pressure Regulator. Cant seem to find one anywhere. It is a nylon inside/rubber outside with a cloth mesh and quick connect fitting line. Where to get one? Can I hose clamp it the FPR by cutting off the connector that broke?
View 1 RepliesFord Ranger / B-Series :: 2001 2.3L - Blue Smoke / Bad PCV?
I picked up a 2001 ford ranger with a 2.3 from a friend of mine for next to nothing. it has a serious oil consumption problem. he just put a head gasket in trying to fix the problem with no luck. he thinks it has a broken oil ring. the truck only has 99xxx miles on it and i find it hard to believe that it broke a ring. I am thinking it has to be something like a bad pcv. If it is rings ill do the job but I don't want to pull the motor down just to find that all the rings are good and it was something that i looked over
View 11 RepliesFord Ranger / B-Series :: 1999 - Smoke From Steering Column
Within the last couple of weeks, periodically I see small amount of smoke coming from the steering column, from the hazard switch. It only lasts a couple of seconds. I've owned my 99 Ranger for about 7 years now, and since I got it, the dome light has never worked, even when installing new fuses. I'm suspicious it's the multi-function switch but not sure. What this means. I'm no mechanic, I just read alot, and from what I've read, this seems to be the issue.
View 3 RepliesPassat (B6) :: Emits Black Smoke With Black Colored Water While Accelerating
I've been told by friends driving behind me that every time I accelerate I emit a plume of black smoke followed by a stream of black colored "water". I checked today by having the wife rev the engine to 4.5k...sure enough, black water shoots out of my exhaust, probably 3 oz. I also see a black puff of smoke which I assume is more normal than the water. Is this commonplace ?
View 2 RepliesHonda - Accord :: Puffing Out White Smoke - Blown Head Gasket?
So just a few days ago my car started puffing out white smoke, not all the time, but every so often. I noticed last month, that when i am sitting still, my temperature gauge is slowly moving up, but when i would start moving, the gauge would go back down. I know my cooling fan is working, because when i would turn the car off, i can hear it going. My car has been drinking oil and coolant like crazy, it has hard starts sometimes, it never runs boiling hot, but it has gotten right above the middle line. Is this a "bad" head or a "blown" head? Its still driveable, i only need this car to last me through may and i am getting another one in june, so if the engine goes by then, i dont really care, the car has 253k miles on it, its ready to retire anytime now. How to make it last one more month? Does this sound like an engine head problem?
View 4 RepliesFord Ranger / B-Series :: 2001 - Won't Stay Running - Blows Smoke?
My wife got off work tonight and went to start up our 2001 Ranger XLT, it starts, but wont stay running unless she puts the gas pedal down, it is also blowing white smoke from the exhaust and she says it sounds like it is missing, sputters and dies when she takes foot of gas.
No previous symptoms, ran perfect this morning, no loss of power all day, no smoke no sputtering and no check engine light. Any clue as to what it is. I have heard head gasket and O2 sensor.
Ford Ranger / B-Series :: 1997 - Breaks Down On Highway - Major White Smoke From Under The Hood
I have a 97 Ford Ranger / 2.3L / 4 cylinder (L4) / 5 speed manual / XL Supercab / 140k miles. I had been having some Check Engine issues and ran rough in town stop light to stop light. But was fine on the highway.
On several visits to the parts store, their OBD tester showed:
PO303 (Cyl 3 misfire detected)
PO141 Bank 1 Sensor 2 O2 Sensor (heater circuit malfunction)
PO171 Bank 1 Combustion Too Lean (the most recent new code to show up)
And the following would show up sometimes, but other times not:
PO 402 EGR Flow - Excessive Detected
P1409 EVR (I cant remember the exact error message for this)
Regards the PO141 code, O'Reilly's sold me a Bosch O2 Sensor (Bosch 15719) and the sales rep told me it was the sensor closer to the engine. And with the attached cable length on the sensor showed was indeed the sensor closest to the engine. But I've been advised the Sensor 2 is for the 'downstream' sensor, furthest away from the engine. And the other sensor, that I replaced is the upstream sensor. And the error continued.
Then back issues showed up and I had back surgery this past year and thus drove the vehicle sparingly. Never resolving the check engine issues. (My bad). Ran on the highway ran fairly well. But recently noticed longer acceleration times and unable to top 65 in 5th gear. I bought spark plugs and plug wires and had plans to change next week.
Yesterday as driving down the Interstate, was 90 miles into my trip, I noticed loss of power even in fourth gear. (note it was the hottest day of the year at 100F). It seemed I used more gas than usual for that distance. I stopped for gas on the Interstate and power seemed to improve. Then about 130 miles into my trip I hit some heavy stop and go traffic, and wasn't able to keep an idle and the engine died numerous times if/when I didn't give it gas at a dead stop. The heavy stop and go heavy traffic and the issues persisted for a half hour for more than five miles. Then when traffic opened up the truck seemed to have a bit more power in 4th gear again. And up to that time all my dash gauges were showing fine. Then a couple miles or so down the interstate, driving 65mph in the inside lane, the check engine light started flashing quickly. And at the same time a sudden loss of power, rough sounding engine with heavy white smoke coming under the hood. And looked back in rear view mirror, with nothing but heavy white smoke. Managed to cross three lanes in heavy traffic and was able the vehicle to the outside emergency lane, finally coming to a stop.
Looked under the hood and saw oil dripping everywhere but with all the oil everywhere I could not find a prime source. Looked like the oil came from the top end of the engine and dripped down. Measured the oil at the dipstick and it seemed like I was at least a quart plus down (I checked the oil before I left on the trip). And it didn't look like any water was in the oil. And my radiator overflow tank was at the proper level. So I figured I lost all that oil during that period of "white smoke".
So had my vehicle towed home. Today in daylight, I did some more inspection and removed the air intake system (hoses and canister) from the air filter to the throttle body. There was significant oil up to the canister piece that fits on the air filter canister (but no oil in the actual air filter), and significant oil inside all the hoses up to inside the throttle body (up to the butterfly which I could see),
When I disconnected these hoses I noticed the blow-by hose connected to the intake hose system was not connected to anything. And a tube opening on the valve cover was open without the a blow-by hose attached and, with no clamp. So I assume all that oil and came out of that blow-by tube on the valve cover, (white smoke created by hot oil hitting the engine).
So appears to me that its not a blown head gasket or worse, which I first feared.
I have the vehicle parked at home.
QUESTIONS: So what are the suggested steps to troubleshoot and repair? Besides reattaching everything and putting a clamp on the blow by hose? And installing new spark plugs and plug wires. I previously replaced plug wires around 60k, even though the manual recommended 100k mile replacement. (And a couple yeas back I had the dealer replace the PCV, which was recommended in the manual and included in the warranty. The timing of the initial check engine lights appeared shortly thereafter).
Is there suppose to be a large amount of oil in the air intake system after an incident like this and should I try to clean/flush out the hoses and the inline canister?
When I disconnected the inline canister from the hoses in the air intake system, unfortunately I failed to document the direction which the canister goes. It has outside markings "ADP with a forward arrow with some horizontal lines, and then at the other end upside down markings with a greater sign PP less than sign. Should the forward arrow point toward the throttle body or toward the air filter (I'm thinking in the direction of air flow, toward the throttle body). I've taken some photos of the engine with air intake hose system unattached, if that might work...
Ford Ranger / B-Series :: 1993 3.0 - Head Gasket Failure / Blowing White Smoke And Using Coolant
Well I finally went and bought another Ranger. Pretty red 5spd 4WD long bed. I knew it didn't run when I got it (crazy leaky fuel line...stupid squirrels), and the owner was pretty sure it had a head gasket failure. He claimed it was blowing white smoke and using coolant. I hadn't been able to get it to run to verify that, but I can't see why he would lie about that.
I finally got the fuel line fixed today (FYI, don't waste your time or money buying those Dorman OEM connector patch kits at Advanced Auto). While we were cranking the truck, I noticed gas escaping the degas bottle the radiator was pressurized before the thermostat should be open. That to me says blown head gasket (crossing fingers it isn't a cracked head) for sure. I tried to get a picture of the dipstick, but in the light it definitely looks like peanut butter. I just wanted to make sure before the massive ordeal of pulling heads/top end work that will follow
Anyway, plan is to fix her up and get her back on the road! Some picture enjoyment .......