Golf IV / Jetta IV :: Rotors Vibrates - Hesitation When Braking
I switched my front rotors 4 times in the last 4 years.
I know you probably thinking its the driver. I've owned the car since 2012 and have only put on 46000 kms.
The rotors vibrate and have that weird stop and go hesitation when braking.
Is it simply OEM or nothing?
Ford F-150 (2009-2014) :: Front Brake Rotors Premature Wear
I have a 2014 Supercab Ecoboost F150, which has 37k KM on it (23k miles). I work at sea for 4 weeks on / 4 weeks off so the truck sits a fair bit. I had it in the dealer for scheduled servicing and they noticed the inside pads on both front brakes were wearing significantly more than the outside (4mm vs 7mm). The lube guy at the time had suggested sticking calipers and that they'd be warranty.
A few days later I brought the truck back in to have the brakes looked at and an unrelated warranty item done. They looked and said the calipers aren't sticking and the rotors are grooved and rusted, particularly the inside surface. They wanted to put new pads on and turn the rotors for 400 bucks.
I had a hard time believing it wasn't the calipers, and I was having a hard time getting a good explanation from the service writer of what was going on. So I took the truck back and pulled the pass side tire off in the driveway to take a good look.
As far as I can tell, the calipers are free. The slide pins are nicely lubed and are free, and the pads are free to move in the anti-rattle clips. I squeezed the piston back with a set of C clamps and it seemed to be good. Also, the pads are wearing more or less evenly (not tapered or anything), just the inside is worn significantly more than the outside.
So, rotors wearing out in 23k miles? They aren't really warped, just heavily grooved. My theory at this point is that the weeks the truck spends sitting allows too much corrosion to build up on the rotor, which is getting caught up and wearing down the pads and rotor. Maybe the outside of the rotor isn't nearly as bad because it gets hosed down and washed more frequently?
Inside rotor surface
Outside rotor surface
Inside pad surface.
I still have 7 months of bumper to bumper warranty. Ford says the only cover brakes if the damage is caused by a caliper, so I think I'm out of luck on that front.
Ford F-150 (2009-2014) :: Ice Forming On Rotors After Parking Outside In The Cold
I have a 2011 FX4 F-150. My truck is parked in a garage at night, but obviously sits outside during the day while I'm at work. Almost every single day when it gets cold outside (probably 30 degrees or less), I climb into my truck late in the afternoon and the front brakes shutter like there's ice formation on the rotors. You can actually feel (in the pedal) and hear the rotation of that presumptive "ice" turn on the rotor and touch the pads. It usually "burns" off in just a few hundred feet, and the rest of the drive home is perfect.
BUT, sometimes that shutter is so bad that it sets off all the "check brakes", etc. type warnings on the dash. And I usually have to shut the truck off and back on to get those warnings to stop. Again, it's definitely related to the cold and there's something on the rotors or pads up front causing it. It apparently melts off almost immediately, but not before I have to use the brakes a couple of times just to get out of the parking lot, and it NEVER happens in warmer weather. The pads and rotors up front are new with lots of wear life left on them, and they are OEM Motorcraft pads.
Ford F-150 (2009-2014) :: 2011 - Replaced Rotors But Pads Still Shaking
I've got a 2011 XLT. The front rotors have been turned twice already in 39k miles. Once at 12k and again around 24k covered under warranty. It starting having vibrations on the highway and shuddering when braking again around 36k. Tired of dealing with the OEM rotors and told it would no longer be covered under warranty I went to Autozone and got duralast rotors and pads for the front.
Swapped them out Friday
- took caliper off
- removed pads
- took caliper bracket off
- swapped rotor
- opened bleed valve to push back piston(used a vise/c clamp combo)
- closed valve with piston under pressure
- put in new pads
- placed caliper bracket back on
I did not remove the pins, they seemed to slide fine and the remaining hardware still looks fairly new.
Took it out all was good, bedded the brakes a bit and called it a night. Come out this morning and start to head out and it's shaking like crazy now once above 40 mph. Made it back this afternoon and took the passenger side off and its not making full contact with the rotors. I've read this can be common until the pads are broken in. Driver side appears fine, pads appear to be bedding fine and nothing looks out of the ordinary, I took the caliper back off but had to open the bleed valve to get it loose enough to let go of the pads.
I've even taken the passenger side back off and reset the piston again just to make sure.
Put everything back together and take it for a spin. Truck seems worse now even at slow speeds 25-50mph. Once the brakes start getting hot from stopping the shaking goes away. When the brakes start cooling back down it comes right back.
Going to swap back the OEM rotors and retest in the morning. Will take the new ones back If that puts it back to normal I may just replace with OEM ones then. The brakes work perfect it's just the shaking that I can't seem to figure out.
Anything to check? It seems like the new rotors are warped
Toyota - Tacoma :: 1996 - While Braking Front End Vibrates?
This is a 1996 Toyota Tacoma, 2WD, 2.4L. When I apply the brakes I get a very heavy vibration in the front end, almost like a wobble. The vehicle otherwise stops fine. No noises. The vibration occurs at pretty much any speed over 20 mph. The frequency does not seem tied to the actual speed but it's hard to tell for sure. It does not do it when I apply the emergency brake only.
I replaced the front disk brake pads, with new clips and shims. There were worn down pretty far and needed replacing. Unfortunately that did not make any difference in the vibration. Rotor runout and minumum thickness were checked while changing the disk brake pads and both were within specs. I did a quick inspection of the ball joints and tie rod ends by trying to move the tire and everything seems tight enough.
I'm not very proficient on suspension issues. What else can I look for.
Toyota - Camry :: 2009 Shakes And Vibrates When Braking At High Speeds
I just bought a 2009 Toyota Camry with 78K miles on it. Everything is great except at highway speeds it shakes and vibrates when braking. The higher the speed the worse it is. Steering wheel shakes as well. I pulled both front tires off and the rotors appear to be smoothe on both sides with no grooves, etc. However, I'm due for new front brake pads. There's some pad left but could that be why it shakes and vibrates when braking? How do you tell if rotors are warped? Rotors are smooth but could they still be warped?
View 16 RepliesFord F-150 (2009-2014) :: 2011 XLT 4x4 - Vibrates And Jerks About 65 Mph?
Driving to work the other day on the expressway going about 65 and my truck starts vibrating and jerking like crazy. I thought i had a blow out , so I checked my tires and they were ok. Then, I thought I may had run over something. I continued off the ramp and drove on the highway to work, no sooner than a couple of minutes later it happened again. I had a tow truck take it to the dealer, this was Thursday. It's now Sunday and I haven't heard from customer service after they told me they'd call..... Its an EcoBoost by the way.
View 2 RepliesFord F-150 (2009-2014) :: 2012 - Vibrates When Towing?
Experiencing a vibration when starting out with a load behind the truck, I have a 2012 supercrew with 6.5' box.
View 4 RepliesFord F-150 (2009-2014) :: Vibration When Braking At Slow Speed
For the past 4/5 weeks my truck vibrates when i brake at slow speed ex. Driving out of a parking spot, slightly braking no matter if i go forward, reverse, turn or go straight it'll vibrate, sometimes very lightly, but usually it's very noticeable, can be compared to the clutch pack issue with these trucks. I had the clutchpacks in the rear diff. replaced at 160k ,after that it drove very smooth but that only lasted 20/30k.
So when turning it'll vibrate at about 15/20 km/h, but that's because of them crappy clutch packs
truck:
2009 f150
xlt ext. cab
4x4
xtr package
6,5 ft box
5.4 L
212000 km
Ford - Excursion :: Slightly Warped Rotors But Shakes Without Braking
Recently bought a 2001 Excursion 4x4 but failed to take it on the highway and get it up to speed. It shakes real bad around 65 but I can't tell exactly where the shake comes from. Here is what I've fixed so far. Balanced tires, Alignment, Fixed Steering Linkage, Balanced rear drive shaft, new shocks, new brake pads (slightly warped rotors but shakes w/o braking), lubed everything, replaced all fluids except transmission which was clean, no metal in any fluids, removed front driveshaft. Checked wheel bearing as best as I can.
View 5 RepliesLexus IS 2014+ :: Front Brake Pads Touching The Rotors / E-Brake Engaged And In Park
I noticed the front brake pads were touching the rotors when I was painting the brake calipers. I had my e-brake engaged and in park. I'm assuming the e-brake only brakes the rear wheels because the front rotors were still movable. Although the car still rides fine but I'm not sure if this is normal.
View 1 RepliesFord F-150 (2004-2008) :: Violent Shudder On Braking At Highway Speeds / Warped Rotors?
So my 07 with 125k miles has had new rotors for about 50k miles or so, but for a while now when the brakes get hot it gets a violent shudder on braking at highway speeds....the odd part to me is nothing at lower speeds, and not always at higher speeds....do I just have warped rotors again? The rest of the front end I good and tight....
View 9 RepliesFord Excursion :: Steering Wheel Vibrates When Braking
We have the 6.8 4x4 2001. Mostly use it for towing 6K #. Bought 2 years ago. Front and rear brakes were new and all 4 rotors were machined at Ford dealership prior to purchase. Have put on 13,000 miles since then, majority towing.
View 14 RepliesFord F-150 (2009-2014) :: Sloshing Scraping Thumping Sound Coming From Fuel Tank Under Hard Braking
Hearing a sloshing scraping thumping sound coming from their 36 gallon tank under hard braking accelerating? It's loudest when the tank is between 200 and 150 miles to empty, I checked the spare tire and its tight, haven't had a chance to crawl under and look around yet though, I think something inside came loose. 2013 XLT.
View 2 RepliesFord Super Duty (1999-2016) :: 2014 F450 - Front End Shakes When Braking Hard / Towing
2014 F450. Front end and steering wheel shake violently when braking while towing a 20,000 pound trailer down a long and steep highway grade. It does not happen when towing my 12,000 pound trailer down the same highway. Could I be setting off the ABS braking system?
View 14 RepliesPrius (Gen 3) :: Hard Braking / Brake Rotors Become Rusty
I have never experienced what others have described as the brake delay issue, neither before nor after the ABS recall. I have even purposely driven over rough patches of road to try to duplicate.
After two days of rain, I noticed yesterday that my brake rotors were rusty. I remembered a comment from qbee42 about putting the car in neutral while braking in order to remove regenerative braking and to force friction braking to clean rusty rotors.
Yesterday I was approaching a stop light with plenty of distance and no one in front. I started braking around 45 mph with regenerative braking and then pulled the shift lever to neutral. When in neutral and with the regenerative braking removed, I felt the decrease in braking when transitioning to friction braking and I had to brake a little harder in order to have the same amount of braking as before in regenerative braking.
I can see where someone can "perceive" this as a surge forward but I only interpreted this as a decrease in braking force, as others have stated here many times.
I tried this again at the next stop light and felt the same "sensation" again and had to brake slightly harder when in neutral in order to have the same braking force. It was apparent to me that for the same brake pedal position that the friction brakes do not exert as much braking force as the same pedal position with regenerative braking.
Is this similar to what others are reporting as "brake delay" or "surge forward" issues?
Chrysler - Pacifica :: Shudders When Braking After New Rotors And Pads
My 2004 Pacifica (130k miles) was left parked for 2 weeks while we were away. Upon return it didn't wqnt to back out of the parking spot. After about 1/2 revolution the wheels made a clanking sound and hung up. Rolling back and forth freed things up enough to drive the car to the mechanic (about 40 miles). And after the first mile or so everything seemed to go back to normal, with no absolutely signs of anything not wanting to turn smoothly.. The mechanic thought that the problem had been that the brakes were sticking due to the car being unused and said nothing needed to be done. However, upon examination he found that we could use new front brakes and 2 motor mounts. He said that the need for brakes and motor mounts was due to normal wear and tear, and was not related to the wheels hanging up issue.
But now, immediately after installation of 2 new front rotors and pads and 2 new motor mounts there is a vibration/shudder when braking from anything more than 20-30 mph, which was never there before. The shudder is rapid and sometimes pronounced like going over the warning groves cut into the edges of pavement on the interstate. He thinks that this may be a sign that there is a driveshaft issue, and dismisses it as due to an out of round rotor since they are new. I don't know what to think. By the way, he has always been an excellent mechanic, with a great reputation and loyal following.
Ford Super Duty (1999-2016) :: Steering Vibrates Under Hard Braking?
.I just changed out all the steering linkages due to a lot of slop and worn out tie rod ends. This problem existed before I changed them but I thought for sure changing the linkages would fix it. When I brake hard my front tires wobble very bad. I haven't ever experienced the death wobble that is common in these trucks, but the symptoms seem the same, its just only when I brake hard. I can look at my front left tire while braking hard and see it wobbling. The wheel bearings and ball joints only have about 15k miles on them. I can't tell if the front wheels are moving independent of each other back and forth, or if they are both shaking back and forth together. What might cause this? it's a super uneasy feeling when it happens, especially because whenever you are braking hard there is usually a reason.
View 14 RepliesCamry 2012+ :: Vibration Under Highway Braking - All Four Of Rotors Were Warped
It all started around 18,000 miles when I noticed a vibration under highway braking. I convinced myself that everything was fine for the time being and I would have the dealer inspect the brakes at my 20,000 service. Fast forward to the service and all four of my rotors were warped. The dealer turned them all and said I wouldn't have any more problems. The car sits at 28,500 miles now and I'm starting to get the same vibration sensation as I had at 18,000 miles. I'm definitely going to be bringing the car in for it's 30,000 mile service and I will bring up the issue again. What type of warranty is on the brakes as I hope they will replace the rotors this time.
View 14 Replies