Ford 6.0L Power Stroke Diesel :: Fill Rear Differential With Rear Axle Shaft Out?
I currently have the rear axle shafts off the truck. I took off, cleaned then put on the rear diff cover.
I live in an area that does nothing but form rust anywhere and everywhere in very little time.
I don't want rust forming in the rear diff gears - can I fill the rear diff up ? Or will it leak out of the rear shaft holes ? Can I fill it up halfway then ?
Ford F-150 (2009-2014) :: 2010 FX2 - Rear Axle Gear Ratio?
I just purchased a used 2010 fx2 screw with 5.4 and 6-speed auto. How can I find out what rear gear ratio the truck has? do I have to contact a dealer to find this out or are their any web based sites that can decode the vin? Is the gear ratio marked on the truck anywhere?
View 2 RepliesFord F-150 (2009-2014) :: 2012 - Clunking Sounds When Electronic Rear Axle Is Locked
I have just started to have this problem or what I think is a problem. When the electronic rear axle is locked and in icy conditions I am getting clunking sounds out of the rear end sometimes. Its hard to explain but it sounds like it is slipping in and out of engagement. Sometimes it works fine or what I think is fine and locks both wheels together and I get no sound at all. I switched off the traction control thinking that the sounds I was hearing were a result if it kicking in but this didn't change the sounds the rear diff is making.
View 11 RepliesFord Excursion :: Drips Coming From Rear Axle Input Shaft Seal
I have noticed a few drips coming from the rear axle input shaft where the drive shaft connects. It has only done it once and there is no residue on the trailer hitch so I know it didn't dump everything on the road. If change this seal, how difficult is it and do you have any information which might make it easier.
View 14 RepliesFord Ranger / B-Series :: Rear Axle - Drive Shaft Not Fixed In Diff Perfectly Straight?
Today I took the bed off of my 99 ranger. I was sitting on the cab looking down at the rear axle noticed the drive shaft was not entering the rear diff perfectly straight. As I looked further into it, I noticed the distance between the rear spring on the passenger side tire, is noticeably different. To visualize it, the wheel, at the bumper side of the axle, has a shorter distance between it and the leafs than the cab side. Not massive, but a few inches, and it's noticeable now that I can stand over it. I'm beginning to be very annoyed by this truck and it's previous owners, whom I take it , scammed my brother quite well with a $5k tag for a truck with so much not right with it. It's about to become my yard art for awhile.
View 8 RepliesFord Super Duty (1999-2016) :: 2004 - Rear Drive Shaft Broken?
I have a 2004 F350 with a broken drive shaft.
Got the original shaft off and it has the following part number (2C34-4K145-DNA)
but I've since learned that the part number has changed but the only info I could get was 2???. 4R602DQA.
Trying to find the part number so I can find it under 750.00 from the dealer
Expedition :: 2005 - Rear Passenger Axle Noise Down To The Right Side Of Half Shaft
My wife has been complaining about a noise from her 2005 expo.
As she drove the truck today I have narrowed the noise down to the right side of the half shaft. From looking underneath and comparing what I was seeing and hearing, the track bar is not centered. Its more in on the driver side and out on the passenger side. I had her to stand on the running board and shake the truck.
I can definitely hear a kinda cluck? It sounds like the half shaft going to the tire but at the same time the bushing on the outer tire rod end. I can't determine what it is exactly.
when you rock the truck you can definitely hear it. Its not like violent loud but i'd like to get it taken care of. I looked for some grease points but I don't see none..
2nd question for the grease points that I do see how much do I grease it? how many strokes?
Ford F-150 (2009-2014) :: 2010 F150 Cam Shaft Position Sensor
I have a 2010 F150 with the 5.4 V8. How many cam shaft position sensor do I have ??? I replaced one but I swear I see one one the passenger side...
View 1 RepliesFord F-150 (2009-2014) :: Universal Joints On The Drive Shaft Require Lubrication?
I have the subject truck and do my own oil changes. I see that the front end has sealed ball joints and doesn't require lubrication.
Do the universal joints on the drive shaft or any other components require lubrication? 2014 F150 XLT ....
Ford F-150 (2009-2014) :: 2012 - Electronic Locking Axle Same On As 2wd / 4wd?
While I was test driving 2012's I noticed that the e-lock for the axle was on the same as the 2wd/4wd. I asked the sales-kid if it was in 4wd or 2wd when the rear axle was locked and he couldn't tell me. I figure its in 4wd, but its on the 2wd side of the
View 10 RepliesFord F-150 (2009-2014) :: Fuel Door Broken?
My fuel door took a dump last week and won't stay closed now. The truck is out of warranty, so I'll have to try to fix it myself, but I don't really know how to get to the broken part. Looking at it from underneath, it appears to have some kind of a spring set up, but I'm not sure how to remove it and then if I have to replace the whole housing, how does the actual door detach?
View 6 RepliesFord F-150 (2009-2014) :: Groaning Like Humming Noise From Front Axle
My front axle is making a groaning like humming noise when the truck is cold and first starting to drive it. It does it when speeds are at 30 mph and under and goes away when putting it in 4WD. It sounds like the hubs but I'm not sure. The dealer hasn't been able to duplicate it because they haven't kept it overnight. I'm just wondering if this happen to the truck, was it fixed and what was the issue. Like I said, I think it may be a vacuum issue to the hubs, but not sure.
View 12 RepliesFord F-150 (2009-2014) :: Grinding / Ratcheting Noise In LH Front Axle When In 2WD
Wife's 2010 F150 4x4 85000 KMs makes grinding / ratcheting noise in LH front axle when in 2 wheel drive. Mostly when turning left some times when traveling straight never when turning right. Never makes the noise when in four wheel drive. I am suspecting the auto hub is the issue but wonder if others have had this trouble ?
View 5 RepliesFord F-150 (2009-2014) :: How Does 4x4 Engage - Click Sound Coming From Front Axle
Curious, how does the 4x4 engage in the new F-150's? When I put the truck in 4WD I can here the click sound coming from the front axle, where as it comes from the t-case on my Ranger. Just wondering how it's set-up.
View 5 RepliesFord F-150 (2009-2014) :: Fuel Door Would Not Pull Itself Closed / Broken
On a roadtrip, went to fuel up and when I was done... the fuel door would not pull itself closed. I pushed on it, whatever spring or band was there pulling it closed is no longer functioning. 37500 miles on an '09. This really bothers me because of the no fuel cap design. Will have to take it to the dealer when I get home and find out what's the solution.
View 14 RepliesFord F-150 (2009-2014) :: 2012 - King Ranch Sunroof Track Broken?
2012 F150 King Ranch broken sunroof track TS
Does the ASI-44420 broken sunroof track TSB apply to 2012 F150? I see a lot of complaints from 2011 & 2012 users online, however having trouble locating a TSB. The fix for 2009-2015 is the same, so my initial thought was the TSB should cover all those years as well.
Ford Transmission :: Drums Seized Onto Axle Shaft
I purchased a 1964 9 inch from a Galaxie 500 to use in my 51 merc M1. The drums were seized onto the axle shaft and after trying everything, I was forced to break them up with a sledge to get them off. The axles turn freely and I have removed the 4 bolts that hold the shafts to the housing flanges. The axles should slide right out but the do not. Am I missing something? How do I pull them if they don't budge?
View 1 RepliesFord Excursion :: Front Axle Shaft U-Joints Won't Come Apart
its a 2000 limited 4x4, must have been in the snow a lot because it was from up north and is pretty rusty on the underside. my dad and i have tried everything to get these caps off but nothing will work. lots of pb blaster, hammering, even cutting the one of the four joints and trying to wedge something from the inside. If we cant get it could a shop do it? and how much might they charge?
View 9 RepliesFord F-150 - 1997-2003 :: Busted Axle Shaft Boot
I have a 2003 Ford F150, 4x4, and I recently installed torsion bar leveling keys, i did not notice before i put the keys on, but while parked level, wheels straight, my wheels stand awkward, the bottom sticks out while the top is kinda sucked in, when i took a closer look, my inner axle shaft boot on my passenger side is busted and slinging all the grease out, what is the solution?
View 8 Replies