Ford F-150 (2004-2008) :: Crank But Not Start In The Morning
Went to leave this morning and my '05 with 135K would crank but not start. Pulled air cleaner and sprayed a little starting fluid and it fired some so I had a feeling it was fuel related. Reset the fuel cut-out with no luck. I then remember seeing the issues on the forum about the fuel pump driver module corrosion and failures. Bought a new one at the local dealer, installed it and it fired right up.
Pics below...from the side it didn't look to bad but was holed through on the bottom. I highly recommend replacing this if you live in the rust belt.
Ford F-150 (2004-2008) :: 2007 - Won't Start But Crank Good?
So I used my 07 F150 4x4 Lariat (5.4 l) yesterday and it ran with no problems. Today, I went to start it to go to work and it would crank over strong and fast but not run. I filled up two days ago and it has been below freezing the last couple of days. What to check as I currently have my wifes explorer for work tonight.
View 14 RepliesFord F-150 (2004-2008) :: 2006 - Engine Won't Crank - No Start?
I was working on trailer lights and now no trailer lights and relays click but eng no crank. Batt has 12volts.
View 1 RepliesFord F-150 (2004-2008) :: Slow To Start / Crank Over For 10 - 15 Seconds
06 5.4 screw. This truck sits in the garage all week long as I drive a work van daily. When I take the truck out on the weekends it starts up normally at the house and when I stop someplace for a few minutes it starts right back up but if it sits for an hour or more it will crank over for 10-15 seconds, it does always start back up. It always runs and drives fine, it is all factory as far as the motor, intake, exhaust, tuner etc. What to do with it.
View 12 RepliesFord F-150 (2004-2008) :: No Crank No Start After Removing Manifold / Head
2004 New Body F150 5.4L
Removed all cops, plugs, intake manifold and driver side head to repair bad valve. Removed Left side cat pipes as well. Had to disconnect most of upper engine harness and had to remove cpm and battery.
Repaired all mechanical issues and reconnected all electrical connectors and now when I turn the key to start the red security light on dash is still blinking steadily and I get no crank no start situation and it blows #34 PCM fuse which is injector/fuel fuse as soon as hit start.
Here are some things I have done trying to trouble shoot.
Battery shows 13.65 V
Unplugged FPDM back on rear frame rail and disconnected far left harness (looking from front) from PCM (should be engine harness), both the smaller plug that plugs into another harness and the main plug to the PCM.
Now when I turn on the key the security light goes out, the dash display says engine fail safe mode and the motor will turn over when I turn the key. This is still with the #34 fuse blown.
If I plug the engine harness back into the PCM, same no click no start.
If I leave engine harness unplugged from PCM and plug FPDM back in and turn key now it goes back to no crank no start and the security light blinks rapidly.
Only way I can get anything to turn over is far left harness disconnected, both plugs and the fdpm disconnected. Display says Engine Fail Safe Mode, and the security light goes out when I turn the key to start. I'm at a standstill as to what to do. The truck started fine prior to me taking it down for service.
Ford F-150 (2004-2008) :: 2006 - Random Crank But No Start Intermittently
I have a 2006 Ford Expedition with 95,000 miles that has a crank but intermittent no start problem. When it does happen, it will eventually start after one to two tries. I don't have to wait to start it again and I don't have any problems while it is running. Two or three times in the past two months it will sputter out and die (even though I am pressing the gas pedal) right after starting. I'll crank it again and it starts just fine. I have no problems while driving at freeway speeds or around town.
I never had any check engine lights come on so I replaced the battery and the fuel filter. I finally got two codes and replaced the fuel pump driver module and the fuel rail pressure sensor. The codes went off after replacing these two parts. I can hear my fuel pump turn on every time I start the vehicle. I have even taken the entire fuse panel apart to check Relay 303 which is soldered into the circuit board. It is fine and so is every other fuse in the panel.
Ford F-150 (2004-2008) :: 2007 Truck Does Not Crank When Turn The Key To Start
I have a 2007 F-150 5.4l that does not crank when you turn the key to start. I have tried jumping the starter over and it does crank after that but it will not start. I am completely stumped by this and I'm not sure what the problem is?
View 2 RepliesFord F-150 (2004-2008) :: Starter Click But No Crank - Truck Would Not Start
I have an 04 f150 and just changed the alternator yesterday, and 4 hours later it wouldn't start starter clicks but no crank.
View 3 RepliesFord F-150 (2004-2008) :: 2003 - Crank But Would Not Start / Service Engine Soon Illuminated On Dash
Wifes F150 was turned off while she went shopping when she came out it would not start would crank but would not run. Got it home hooked up my scanner, had no codes, but the Service Engine Soon was illuminated on dash. Just wondering if this has anything to do with the PCM. Has a 4.6L engine, 2X4.
View 5 RepliesFord Wiring/Electrical :: 2008 F150 - Cold No Crank / No Start
I have an 08 F150 5.4L with about 68k miles. When the temperature is 40 degrees or colder it will not crank. I had the same issue with my 2005. I can turn the key and nothing, lights, radio and everything work. The dash display has dashes all the across for the miles, temp and compass. I have found out that it doesn't matter if I leave the key forward in the run position or try to crank, it won't do anything.
Battery is good and no problems with the truck. After the key is in and I give it anywhere from 15 to 60 seconds you can hear an electrical click real faintly and see the red security light come on and then the computer display comes on and then I can start with no problem? What could this be? My dealership has no clues and I can get it to act up because after I get it there it starts with no issue. The remotes work fine and this issue was why I got rid of my '05.
Ford F-150 (2004-2008) :: 2005 - CEL Came On - Stalled And Won't Crank
I have a 2005 F150 5.4l. The CEL came on a couple days ago, but there were no driveability symptoms, and my code reader was 2 hours away, so I didn't pull the codes.
Today, I left for work and pulled onto the freeway, I went to pass a vehicle, and rolled on the throttle (maybe 60%) l and the truck fell flat. I backed out of the throttle, checked the gauges, all looked good, so I tried again. The second attempt ended the same as the first, it fell flat and felt much like a APP/TPS correlation/limp mode.
Before I had a chance to even think, it bucked a couple times and stalled (felt like running out of fuel). I coasted to the side of the road and tried to restart. When the ignition is on, the dash lights come on as expected, when turned to the start position the relay under the dash clicks, but it doesn't crank, and the starter solenoid does not click.
I have checked the starter and PCM relays. Both are good. I have not disconnected the battery or started pulling fuses as I want to retrieve the codes first. I am able to turn the engine over with a pry bar.
Ford F-150 (2004-2008) :: 2005 - Engine Won't Crank Over
ford f 150 2005, engine wont crank over. Tried all these remedies but none of them work. [URL] .....
Here was the scenario: someone drove my truck in 4 low for a very long time.3 hrs doing over 80 km/h) When i drove the truck i could get it out of 4 low it is still in 4 low. But then the truck died on me.
The alternator pulley went on it. replaced the alternator then proceeded with the remedies from the link above.
Ford F-150 (2004-2008) :: 2006 - Won't Crank And Run - ECM Fried?
I have an 06' F-150. Last monday went to start and wouldnt crank over. I have since replaced FPDM, a weak fuel pump, checked Fuel Inertia Switch and now that they are all replaced when I check codes it says "no data available". Pump will not come on. Fuses have been checked. I have traced this problem to everything I can think of. If my ECM is fried, why would it have worked fine before replacing FPDM? I am at a dead end. Mechanic is at a dead end.
View 9 RepliesFord F-150 (2004-2008) :: Ignition Stuck / Crank Sometimes Even After Let The Key Go?
The truck seems to continue to crank sometimes even after I let the key go. Kinda like it's having a difficult time starting and NEEDS to be cranked a wee bit more and takes over for me. Is this an ignition issue that I can (need) to address or is it normal. I have ZERO experience with a newer vehicle nor a Ford truck.
View 2 RepliesFord F-150 (2004-2008) :: No Crank / Engine Will Not Spin Over At All With Key
No crank with key, can jump and it will crank over, no Radio in RUN position, work fine in ASSy position. Engine will not spin over at all with key. Truck low miles like new, what gives? All fuses good and check a full 12volts on both sides. 2008 - 5.4 ....
View 5 RepliesFord F-150 (2004-2008) :: Engine Started To Crank And Everything Went Dead
I have a 04 heritage f-150, V6 I bought a month ago. Truck ran fine till tonight. Got in to start it, the engine started to crank and everything went dead except for a busing click some what like a turn signal. When I raised the hood the light weakly flashed in time with the buss. I checked the cables, clean and tight. The click came from the #2 ( I think) relay. I wiggled it and it stopped and the lights came back on but when I turned the lights on it all started again. The book says the #2 relay is for the PCM. Don't tell me the computer is out!
View 2 RepliesFord F-150 (2004-2008) :: No Crank And Red Theft Light Flashes
...Battery is very weak also but had a couple questions...
I started by reading up on issue and 9 times out of 10 people were saying the fuel pump driver module causes the issue...
So I ordered a Dorman and plugged it in...I did not bolt it down...Just wanted to see if it would fix and nothing...
Now stuck on the starter...Top bolt is a huge nightmare.
Would a weak battery and bad starter cause theft light to flash or is my problem elsewhere?
Ford F-150 (2004-2008) :: Failed To Crank Twice After Changing Battery
I changed the battery 6 months ago and twice it has failed to crank since. Is there something draining the battery?
View 3 RepliesFord F-150 (2004-2008) :: XLT Suddenly Died And Wouldn't Crank Over
I just got a 2004 F-150 XLT. 200k miles AT. The problem is that it won't start. The previous owner was driving it when it suddenly died and wouldn't crank over. He was told by an auto shop it neded a new engine.
I don't think it needs a new engine because it stopped while driving. I may be wrong. I put a new battery in it. When I turn the key to start it, it just makes one loud click and doesn't do anything else. The oil and coolant look fine. What may be wrong with it or how to see if the engine is bad?