Ford F-150 (2004-2008) :: Will Lacquer Thinner Really Clean My Catalytic Converter?
I wanted to ask a couple questions about this method of adding Lacquer thinner to my gas tank to clean my so called clogged catalytic converters. First off, I have a 2006 F150 5.4 with 90k miles on it and my engine light is on. When I took it to autozone, they said it was just a clogged catalytic converter. Well to be sure, I took it to another autozone, and they said it was an oxygen sensor. I run a lot of ethanol in my truck. My instincts tell me that the catalytic converters are probably clogged because when I mash on the gas it doesn't accelerate as fast as it should being a V8.
View 7 RepliesPrius (2004-09) :: 2008 Touring - CEL On At 68K / New Catalytic Converter Needed
My '08 Prius Touring is in the shop today because the 'check engine' light came on at 68,500 miles. I just got word from them that the catalytic converter is bad and needs replacement. Good thing I bought the extended warranty! Well, I searched the forum for similar problems and it seems like this is somewhat common, albeit on cars with a bit more mileage and maybe a year or more older. I don't abuse my car at all, though I often roll into full-throttle while merging.
Is this a symptom of a poor part design or of a system that fouls the cat over a certain amount of time? I'm not looking forward to replacing it again at 130K after my extended warranty expires.
Ford F-150 (2004-2008) :: 2005 - Catalytic Converter Rattling On Driver Side And Check Engine Light Is On
My cat converter is rattling on driver's side and check engine light is on. Rattle is the inside of the converter, not the heat shield. How much $ and what kind of converter replacement is recommended?
View 10 RepliesPrius (2004-09) :: 2008 - Bad Catalytic Converter / Multiple Warning Lights Are On
The check engine light came on a few times. Went to the old trusty repair shop and the codes pointed to an issue with the catalytic converter. When we started the car again, multiple warning dash lights came on: ABS, (!), Check Engine, and emergency brake light. The brakes also felt very stiff after this.
The mechanic at the shop was taken aback. Said there was a glitch with the computer and that we needed to take it to a dealership to have them "perform initialization of linear solenoid valve and calibration." He said that would fix the issue with the lights.
We were a little upset this happened but love this shop and only stopped going because we moved a few hours away. The mechanic has always been very honest and upfront through the years.
I took the car to the local Toyota dealership today, told them what happened and what the mechanic said. All they did was charge me $100 for a diagnosis of bad catalytic converter pipe and tell me that all the lights came on because the catalytic converter is so far gone. They said they couldn't turn the other lights off until the catalytic converter was replaced.
I don't understand why my brakes are affected when the issue with the car is the catalytic converter. I was also told by the guy at the shop where we first took the car that we would be able to drive with a faulty Catalytic converter with no problem.
Acura - Rsx :: 2004 - Catalytic Converter Malfunction
I own a 2004 Acura RSX that I purchased new nearly 10 years ago. The car currently has 182,000 miles on it. Two years ago (approx. 130,000 miles), I had to replace the catalytic converter and both O2 sensors. This lightened my wallet to the tune of $1,200 (aftermarket franchise, OEM replacement). A few weeks ago, the "check engine" light came on. I used my scanner, and got the dreaded P0420 code, and had it verified by another shop. O2 sensors were OK. What REALLY shocked me was that replacement catalytic converters are only warranted for 5 years/25,000 miles (50k in CA). The first replacement piece lasted 52,000 miles (less than half the miles/years of the original part)
Here are THE QUESTIONS: What killed this catalytic converter? What can I do to prolong the life of this part? My car has the base powertrain that (according to the owner's manual) recommends 87 octane fuel. That's all I've ever used. The mechanic suggested moving up to mid-grade fuel, though he admitted that he wasn't sure.
Saturn :: 2004 - CEL Comes On - Replace Catalytic Converter?
The check engine light came on so I took my car in. My mechanic whom I've used for years told me the following: the catalytic converted had started to come off, in the process it pushed the oxygen sensor up against the body of the car and shorted it out. The total damage is that the O2 sensor and the cat has to be replaced. The line-item estimate was $104 for a sensor and $650 for a cat, plus labor. Total: $1000. Now, I'm looking online and seeing cats that work on my car for far less ($200-400 depending). I talked to another mechanic on the phone who verified cats don't have to be $650. My mechanic said they only use top quality parts with warranty, etc. But the other mechanic said that for a car that he wants to get moving again, a cat is a cat and any new part will, of course, come with a warranty. So... what should I do? Is $1000 too much? If I go with the mechanic who says he can get me down to $700, will that be cheap work on my car? It has 108K miles, and I'd like to get at least another few years out of it.
View 19 RepliesToyota - Prius :: 2004 - Catalytic Converter Rattling Under Heavy Acceleration
Toyota says the code is P0420 and the Catalytic Converter is rattling under heavy acceleration showing the Catalytic converter is bad and should be replaced. Toyota wants 2,334.00 which seems very high to me. Is it the Catalytic converter? The car is a 2004 Toyota Prius.
View 12 RepliesPrius (2004-09) :: CEL On / Code P0420 / Catalytic Converter Threshold Below Efficiency
I checked out a 2006 Prius yesterday a guy is selling. It had the CEL on (not sure why somebody would try and sell a car with that, but anyway). He said that it's because they get gas at a station that consistently doesn't tighten the gas cap enough but by the time the tank is down to 1-2 bars the light always goes away. Although I don't doubt his story, I absolutely doubted the cause. So I took it to get the code pulled and it was P0420, which is catalytic converter threshold below efficiency.
View 15 RepliesPrius (2004-09) :: Check Engine Light On / Catalytic Converter Failed
I just moved to Colorado with my 2009 Prius and on the fifth day here the check engine light went on and the dealership said my catalytic converter failed. Luckily I was still under warranty. Is this related to the altitude or just a coincidence?
View 3 RepliesSubaru - Outback :: 2004 - Cruise Control Flashing - Replaced Both Banks - Catalytic Converter?
engine light and flashing cruise control switch--computer says replace bank one---so I replace with factory catalytic converter----six months later light comes back on with flashing cruise control switch and computer asking me to replace bank one---So I use computer to shut light off----four weeks later light comes back on----called dealer they said "we usually replace both banks"---I found it most painful paying for dealer supplied catalytic converter even when I was under the impression that it would keep light off.---This is my wife's car and she is not really buying the piece of black electrical tape I placed on dash over check engine light.---Am I dealing with a bad oxygen sensor ?
View 5 RepliesPrius (2004-09) :: Check Engine Light Coming On And Off / Showing Code P0420 For Catalytic Converter
My check engine light has been coming on and off and it seems to show P0420 for catalytic converter. The light stays off for about a week and it'll come on for a day or two and off again.
Wouldn't a failed converter stay failed? Can P0420 be triggered by loose/bad gas caps?
Ford - [PUT MODEL HERE] :: Catalytic Converter
See related guides and technical advice from our community experts:
How to Replace a Catalytic Converter
Step by step instructions for do-it-yourself repairs
Browse all: Air Intake and Exhaust Guides
Ford - Explorer :: Noisy Catalytic Converter - No Codes
4.6L DOHC - My driver's side catalytic converter is making quite a bit of noise during acceleration when the engine is warm. I have no trouble codes, no cel and the truck seems to be running fine in general.
I am exploring repair possibilities. I've talked to two shops - one general repair, one exhaust specialist. Neither gave me any options other than to replace the whole system. That isn't an option. I'm a semi-competent home mechanic and if that's what has to be done I'll just buy the walker system from RA and do it myself.
Ford Exhaust System :: Catalytic Converter Locations
I have a 2001 Ford F250 Diesel. I recently cut the 4 inch exhaust pipe right behind the end of the cab cutting off the muffler and I thought the catalytic converter as well. I was talking to another super duty owner and he said he thought there was another catalytic converter further up in the pipe. Is this true? If so, how far would would I have to cut it to cut it off. Would this make the truck any louder...wouldn't mind if it did.
View 6 RepliesFord 6.0L Power Stroke Diesel :: Catalytic Converter Is Bad
Looking for a used catalytic converter that is bad ? I want to hollow it out. I have a couple of these trucks so I thought about just hollowing one and swapping it back and forth for smog testing but my luck i will hollow the one that is going to fail next year.
View 12 RepliesFord Aerostar :: Catalytic Converter Rattles When Parked And Idling
I crawled under the AeroRetard the other day while it was parked and idling to find out where the rattling noise was coming from.
It seems to be coming from the rear catalytic converter.
I was wondering if this is the case, would it also cause a lack of power, as in driving up a steep hill or driving up a steep inclined bridge?
Ford - Explorer :: 1999 - Tailpipe Detached From Catalytic Converter
My new truck is running really loud. I got under it and noticed that the catalytic converter is not connected to the tailpipe. What would I need in order to repair it? Is this a common issue with this truck? If I need clamps, what is the proper size, also the size of the proper tailpipe if it's too rusted out.
View 6 RepliesFord Exhaust :: 2000 E250 - Catalytic Converter Clogged
I own a 2000 E 250 Econoline van with 170,000 miles. I've been encountering loss of power on acceleration for months. Terrible gas mileage (8-10 mpg) and just recently, I get that rotten egg smell when I gun it and and travel above 65/70. I can feel heat from under the van when i step out as well. I've been blowing individual coil packs every other month after a long drive with a lot of inclines. It all points to a clogged catalytic converter. This van has 3. A front left and right by the manifolds, and a large one before the muffler. My question is, what causes them to go bad? I want to fix the cause before spend the money on new cats. Ive heard a rich fuel mixture could do it. Are there sensors that need to be changed?
View 1 RepliesFord Super Duty (1999-2016) :: When To Replace Catalytic Converter?
ill be replacing my muffler here soon, its rusted out blows smoke out all the rust holes, and so on. gonna replace with a nice flo master. Question is, when is it time to replace the catalytic converter? 15 years old and 93000 miles, it still seems like its in good shape, but could it be getting clogged? just from the sounds of the exhaust the past few months, it almost sounds like the truck is somewhat congested. The power from the engine is kinda week, but that's the engine itself. I have no real problems getting up to speed. my hesitation issues from before turned out to be water in the gas tank. Figured since im down there does it make sense just to bite the bullet and throw a new catalytic converter on?
View 8 Replies