Ford F-150 - 1997-2003 :: 2001 - Got Code P0401 - Replace DPFE Sensor?
I have a p0401 generic exhaust gas recirculation flow insufficant detected code on my truck I was wondering what would be the first thing to check to get ride of this code? my truck hesitates from a stop while excelerating to several thousand rpm. should I try replacing the dpfe sensor? what does dpfe stand for? do they sell this sensor at oreilys or do you half to get this a the dealership?
View 9 RepliesFord F-150 - 1997-2003 :: 2001 - Cranks But Will Not Start
I have a 2001 F150 Supercrew Lariat. About a month ago I stopped to fill up with gas and afterwards it would crank but not start. After a few tries the engine would no longer turn over. My battery was 7 years old so I replaced it and the problem went away for about 5 days. Then the same thing, crank but no start. I checked all the fuses & called the local Ford dealer.
After talking with the parts dept. I tried hitting the panic button then the truck started. After talking to parts again I replaced the PATS transceiver. After 3 weeks with no issues the problem came back. This time I locked the doors with the keyless entry remote then unlocked them & the truck started. So I'm wondering what is my problem. Could it be the PATS module or something with the keyless entry module or some other issue.
Ford F-150 - 1997-2003 :: 2001 - Cranks But Won't Start?
F-150 Super Crew 5.4 4X4 cranks won't start. what and where do I check first?
View 8 RepliesFord F-150 - 1997-2003 :: 2001 - Cranks But Won't Start
About a month ago, my 2001 f150 supercrew (4x4 5.4L) didn't want to start one morning. This was after a very cold night (15 degree temps). It sounded like it had plenty of juice in the battery (cranked good), just wouldn't start. Later in the day, after it warmed up, still no start. I dug thru here, and someone recommended disconnecting the positive battery cable for a minute then retrying. I did it, and it worked. All was good.
About a week ago, no start in the morning again. Tried the positive cable disconnect, no luck. After several hours, it just seemed to randomly start, and all was well again.
Today, truck started right up in the morning, but later in the afternoon (warm winter day 45 degrees) no start. Tried the positive cable disconnect, no luck. After screwing with the truck for about an hour, I decided to put the fuel pressure gauge on the rail. NO fuel pressure.
Is fuel pressure associated with the PATS, or is this a straight up fuel system problem?
Additional info: My gas tank fell out this summer, (recall on those tank straps), and I had a new tank, pump, straps and lines installed. I had a no crank, no start issue this summer, but that turned out to be the transmission not registering in park. I assume the two issues are unrelated.
Ford F-150 - 1997-2003 :: 2001 V8 Truck Won't Start In Park
So I just bought a 2001 F-150. It has the 4.6 v8 it's a 4x4 automatic. Sometimes i'll go to start it in park but nothing will happen. But if I put it in neutral. It'll start right up.
View 7 RepliesFord F-150 - 1997-2003 :: 2001 2WD Truck Cranked But Did Not Start
I have a 2001 ford F150 with a 5.4 2WD, with a starting problem. Last Friday I went to leave work the truck cranked but did not start, turned the key off and tried again same thing, on the third try it started. Drove it home 30 miles with one stop on the way, restarted just fine. At home in the driveway I restarted it 5 times without a problem so I was thinking it was just a glitch. Did not drive the truck all weekend thinking the problem was fixed.
Monday morning leave for work and everything was fine, went to start the truck in the afternoon and the same problem as listed above (3 or 4 tries and it started). It home again in the driveway restarts every time. I do not have any check engine light on but I thought I would still plug in my code reader NO CODE. Where to start troubling shooting this problem?
Ford F-150 - 1997-2003 :: 2001 - Cranks But Intermittent No Start
01 supercrew 4.6. Have had intermittent no start. The first few times it did start with a jump. Cranks fine but I thought the battery was weak. Replaced battery, same issue. 40 psi gas pressure at the fuel rail with analog gage. Theft light blinks with battery inserted. Theft light not illuminated while cranking. Battery light flashes while cranking. Battery is brand-new and charged. Opened and closed inertia switch several times to check.
View 12 RepliesFord F-150 - 1997-2003 :: 2001 Truck Turns Over But Won't Start
2001 f150 4x4 5.4 205k ... This truck is not my daily driver but I use it about once or twice a week. Last night I drove it to the store and it ran great. As good as ever.
This morning it won't start. It cranks and the battery is strong but no bang. It was cold. Just below freezing for the first time this year. No blown fuses where would you start?
Ford F-150 - 1997-2003 :: 2001 - Cranks But No Start After Hard Rain
I have a 2001 F150 Supercrew that cranks but will not start after a hard rain. The mechanic checked the gem module and the fuse box, the gem module looked good but the fuse box had some corrosion he thought from water so he replaced the fuse box and had a body shop reseal the windshield. The first time it rained it started right up but after the next rain it would not start. I went out 12 hours later and it fired right up. I wonder if I would be better off taking to a Ford dealer. What to do next.
View 2 RepliesFord F-150 - 1997-2003 :: 2001 5.4L V8 Won't Start - Codes P0401 And P1740
My truck, the aforementioned 01 f150 5.4 has been running fine but has had the codes p0401 and p1740. I know what they both mean I just haven't fixed them yet. Today I went to move my truck and it wouldnt start. It turned over fine and would hit some but wouldn't start. Would the tcc solenoid be the cause of that? Also the reason my egr is throwing is because there is a line that is not connected but I have no clue where it connects to... Where is the best place to get diagrams for the egr system.
View 3 RepliesFord F-150 - 1997-2003 :: 2001 - Replaced Blinker Switch Now It Won't Start
This is a truck at work, I had my student workers put in a new blinker switch, and when they were done it won't start anymore. The "theft" light is flashing on the dash, so I guess the PATS system thinks it was tampered with. How could you trigger this by changing the blinker switch? Does this have to be reset by a dealer?
View 3 RepliesFord F-150 - 1997-2003 :: 2001 XL - Wiring Info For Remote Start
I added a remote start to my 2001 F150 XL. The remote starter says to use the negitive wire for the parking lights to flash, the form I got to wire it up says use the brown (positive) wire for the lights, its spliced into the brown & they don't work. Another question I had the door panel off, noticed that there is a harness going to the lock, is that for the dome light and door ajar light?
Does it have power wires in that harness for power door locks even though it has no lock switches? Last question, I have to hook up the tach wire for the remoter start. The blue and green wire at the tach is the wire they say to use for the tach signal, does it stay the same color into the pcm from under the hood than out the pcm under the dash or does it change colors under the dash at the pcm?
Ford F-150 - 1997-2003 :: Replace Blend Door Actuator?
Whenever my A/C is turned on, it blows nice cold air. As long as the blower is on "1", "2", and sometimes ", it blows cold air. If I turn it to "4" I can hear a small "thud" behind the dash. It sounds like the blend door is shutting. All my functions work like they should. I think the actuator is goin out and isn't pushing the door all the way closed, and when I turn it to "4" it pushes it te other way.
View 5 RepliesFord F-150 - 1997-2003 :: How To Replace Broken Ignition Actuator Rod
1997 Ford F-150 4X4 ignition Actuator Rod. Looking for instructions on how to replace a broken Actuator Rod? I know the rod is broken because the upper part moves and the lower part connected to the switch does not move.
View 4 RepliesFord F-150 - 1997-2003 :: 2000 - Overheating Above 55 Mph - Replace Engine?
I own a 2000 F150 4.2L (I think off the top of my head) v6 XL model. For the past couple of years I've had an issue with overheating. So far I've had the following replaced:
Radiator
Thermostat
Radiator Cap
Water Pump
The intake manifold has been repaired, that was the first item to have some work done to it. The shop I took it to said the coolant hose that runs into the manifold was corroded at the entrance to the manifold. They stated there was no way to actually replace the hose, but they gave me two options:
1. replace the entire manifold or
2. cap the existing entrance port, drill a hole into the manifold next to the port, and run a new hose.
I chose the cheaper option which I suspect is part of the problem. Now to the problem.
I can drive around town all day long no problems even in 100+ degree Oklahoma summer heat. I left it idling on the side of a street for 2 hours during summer and no problems. The moment I get the truck to 55mph it starts to overheat. Not just overheat, but peg completely out in just over a mile after hitting 55mph.
Once I drop the truck down to about 40mph the temp starts to lower, but will fluctuate between normal and 3/4 to max.
What I need to look at? I've been told head gaskets, but there's no leaks and no water in the oil. I've been told to replace the engine, which if I could afford that I could afford a down payment on a new truck. It's a bit frustrating at best.
Ford F-150 - 1997-2003 :: 2001 4.6L Will Not Turn Over Or Start - Engine Rocks Slightly
I have a 2001 F150 step side 4.6L that just stopped turning over to start. The engine rocks slightly when you turn the key, then nothing but a little electrical smell. Was starting fine up to this past week. Battery is strong and good and upper battery connections clean, has original starter solenoid. I am a weekend mechanic, my son's work truck, trying to do this myself.
View 1 RepliesFord F-150 - 1997-2003 :: Transmission Cooler To Replace The Small Stock One?
Is it suggested for transmission cooler to replace the small stock one? I'm going to get towing stuff soon and just want to make sure I'm not smoking my trans. There's a few I've seen....
View 1 RepliesFord F-150 - 1997-2003 :: 2001 - Cranks But No Start / Theft Light Flashing Fast And CEL On
01 F150. Cranks but no start, will fire with starter fluid spray. Theft light fast flash, Check engine light on. Only have one key and don't know what the kid that had owned has done.
View 5 RepliesFord F-150 - 1997-2003 :: 2001 - Won't Start / Only Get Solenoid On The Firewall Click Each Time Turn The Key
Ok so I was looking at my blend door actuator motor to see if it was working. Just took off the bottom vent cover, turned key on and moved the air mixture to see if the motor worked. (it didn't) Then I went to start the truck and all I get is the solenoid on the firewall click each time I turn the key. I put a meter on the opposite side of solenoid and I see 12v across the solenoid. I can't image i did anything while playing around by the blend door actuator motor. I guess I'm looking for confirmation that the next logical step is starter and starter solenoid. Is there anything else I could be missing? is there anything else in that circuit between the solenoid on the firewall and the starter? I also cleaned the battery terminals and the terminals down on the starter solenoid. I also tapped the starter a bunch and put a charger on battery and tried jumping the truck too. Everything else works.
View 10 Replies