Ford F-150 - 1997-2003 :: 2000 - Coolant Leak On Right Side Of Cross Over Pipe
I have a leak on the right side of the cross over pipe. I removed one long bolt from the right side and two long bolts from the left side that go through the thermostat housing, and three bolts from the back of the alternator, but the pipe doesn't seem to want to move. I don't want to break anything.
View 2 RepliesFord F-150 - 1997-2003 :: Coolant Smell And Lots Of White Smoke From Tail Pipe
My DD just developed a head gasket leak. I've been noticing a coolant smell for a few days and today saw lots of white smoke from the tail pipe. I figured this is where my coolant was going and sure enough there is coolant coming from the driver's side head. I've ordered the gaskets and new bolts, but need the install.
I think mostly what I will need is the intake and head bolt torque and sequence. I will need to take a few days off work to get it done. Truck is a 2002 F150 with a 5.4L engine.
Ford F-150 - 1997-2003 :: Heater Blows Hot Then Cold / Moisture Coming Out Tail Pipe But No Coolant In It
I have a 2003 Ford f150 5.4. Heater blows hot, then cold, then hot then cold. When it start blowing cold it pukes out the degas bottle. I have burped it, did the combustion test to make sure not a blown head gasket, the oil clean, there is moisture coming out tail pipe but it has no coolant in it. flushed heater core, pulled water pump off and checked it, its good. Changed thermostat 2 times, put front on ramps to get any air out. I am at a total loss now.
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: Persistent Coolant Leak At The Thermostat Outlet
The truck has been a dream for several months and I had a coolant leak at the thermostat outlet. Changed the fitting and thermostat and sealed with lots of blue monkey snot. It's been perfect for a couple months but a week ago it started leaking again. Exactly the same as last time. I cleaned the mating surface of the water pump with a plastic scraper to remove the old sealer and then finished it with fine scotch brite. I looked at several parts breakdowns and none of them showed a gasket.......
View 14 RepliesFord F-150 - 1997-2003 :: Changing Filter - Cannot Get Outlet Side Off?
I tried to change my filter today and I couldn't get the outlet side off after removing the clip, is there a trick to it.
View 8 RepliesFord 6.0L Power Stroke Diesel :: 2003 - Coolant Pouring Out The Tail Pipe After BPD Oil Cooler Installation?
My buddy install a BPD air/oil oil cooler in his 2003 F250 last week and now there is coolant pouring out the tail pipe. I haven't seen it but he tells me there is quite a bit coming out. It wasn't doing this before we installed the BPD oil cooler. Normally I would say bad EGR cooler but his EGR is deleted. This is the 3rd BPD cooler I've put in and this is the first time I've had any issues after the install. The install went smooth other than we broke the radiator and had to install a new one. I feel bad cause I'm hoping it wasn't something I caused but I just can't think of anything I did during this install that would cause coolant to be getting into the exhaust. He just had it towed to the local Ford dealership.
View 3 RepliesFord F-150 - 1997-2003 :: Blue Smoke From Tail Pipe
After tooling around town and a complete warm up cycle for the engine I encountered a problem. The situation is this.... Had to go around a slow poke....waited until traffic had cleared and nailed it. My truck belched out a boat-load of blue smoke from the tail pipe. Could not duplicate this on the return trip to the stealer (Dealer). Needles to say, I am worried about the health of the engine....(no codes popped, or anything else as I had a code reader hooked up) My truck did the blue cloud again with a rev up in park after a cool down but wouldn't do it again, but there was a strong smell of unburned fuel at the tail pipe.
4.6L, 2WD, Sport Package....
Ford - Explorer :: 2004 - Torque Value For Water Outlet Bolts?
What is the torque value for the 2 bolts on the upper radiator hose water outlet on an '04 4.6L?
View 1 RepliesLeSabre :: 1997 Buick - Small Drip Of Coolant On Driveway Under Water Pump
Lately I have been noticing a very small drip of coolant on the driveway under the water pump. Most would assume this to be coming from the water pump, right? Problem I have, is I can drive the car say 10-15 miles, return the car to it's parking area on the drive (previous spot cleaned and dried) and monitor thru out the day, some 10-12 hours, NO DRIP! I can forget about it, return the following morning only to see it has dripped overnight! I have visually inspected the coolant elbows at the tensioner and dry as a bone. I see no damp areas near the water pump pulley area. You might ask if the upper and LIM work has ever been done and the answer is yes, the local Buick dealership did that a few years back.
The coolant levels rise and lower normally depending on engine temp and it's hard to see any loss of coolant when looking at the reservoir when cold. I have read there is a small weep hole near the output shaft of the water pump which allows a release of coolant to protect the bearings of the water pump. Could this be where the coolant is coming from? I wouldn't mind replacing the water pump and even the coolant elbows while I have every thing apart, but I would hate to do that only to find it was something else, maybe an easier fix!
Ford 7.3L Power Stroke (1999-2003) :: ELC Coolant And Water Mixed In Trans Fluid - Bad Radiator?
I've got a 7.3 tranny that has had ELC Coolant and water mixed in with tranny fluid because of a bad radiator. I drained the fluid from the tranny a week ago and when I pulled off the pan today there is still junk in there. I'm planning on putting in a new filter, gasket and Mercon V but how do I clean the old stuff out of there? Picture.....
View 14 RepliesFord F-150 - 1997-2003 :: Water In 4WD Vacuum Actuator
I have a 2003 F150 supercrew 4x4 and I'm on my 3rd - 4wd vacuum actuator this winter so far. Somehow water is getting into the actuator itself mounted on the axle and then when it gets cold enough it freezes up and won't work until the heat from the engine thaws it out and then the 4x4 will engage.
Every time I've changed it I have found the part to have about a quarter cup of water in it. and can't figure out where the water may be entering these things. There also was no moisture in the vacuum lines when I blew them out.
I've been using the Dorman brand replacements from O'Reilly, they have a lifetime quarantee but I'm sick of swapping them out every month...
Ford F-150 - 1997-2003 :: Steam And Water Coming Out Of Intake
My truck over heated and I now have a looks like a pin hole leak next to the front injector on the left side looking at it. I have used sealers and it does not work. Water pools around the injector. Does this sound like a cracked intake housing? I have done many repairs but this is something I'm not sure I want to do. I can get a new intake setup for 160.00 on rock auto but ford would be in the 300 or more just for the part.
View 6 RepliesFord F-150 - 1997-2003 :: Water In Spark Plug Recess
1997 f-150, 4.6, 147K miles. This morning I started the truck and the engine light was on. Felt a miss in the engine. Drove 1 mile and back then checked the wires. Found one not firing. Traced it back to the plug. When I pulled the plug boot off I noticed water in the recess, surrounding the plug. Once I blow out the water, I'll checjk the plug but I would like to know if this is a natural occurrence. I thought the boot would prevent water from filling the recess and sitting there. Or does the water just evaporate when the engine gets hot?
View 14 RepliesFord F-150 - 1997-2003 :: Water Pump Pulley Shims
Is it common to have to shim the water pump pulley? I don't know why but mine seems to have moved back a fraction of an inch. I loosen the belt tension and slide the belt back and as soon as I start the motor, the belt slides forward again. And as I rev the motor, the belt moves even further out onto the edge of the water pump pulley and starts to squeal. All other pulleys are aligned and the belt spins fine on them. I thought about buying a shim kit, but I ordered a new Motorcraft water pump since I have 154k miles on my truck.
View 7 RepliesFord F-150 - 1997-2003 :: Water Leaking Through Top Of Rear Window
I have unfortunately discovered that rain is coming through the rear window of my truck. If it was a big job to fix it. The caulking appears to be rotten and I'm wondering if some goop will seal it up. I'm just not sure how to get the trim off!!
View 14 RepliesFord F-150 - 1997-2003 :: Adding Water Pump Lube?
Is there any benefit to adding water pump lube to a 4.6L engine? There's smelly, old looking coolant in my friend's "new" 1997 F-150 so a flush is in the immediate future. I'm going to suggest using G-05 coolant over conventional green due to its longer life. Should water pump lube be added?
View 10 RepliesFord F-150 - 1997-2003 :: Coolant In Oil Pan
I discovered coolant in my oil pan on my 97 f150 4.2. Im replacing my intake manifold gasket which had coolant on the bolts and the timing cover gasket. Should I do the head gasket while its tore down that far?
View 1 RepliesFord F-150 - 1997-2003 :: CEL With Code P0161 - Exhaust Leaking Water?
Light did not come on for a while then it finally did. I replaced all plugs & that did nothing, almost made it worse. Put a scanner on it & it reads bank one lean, misfire. i unplugged all the coils one at a time on the drivers side & didn't notice any drop in rpms. On a side note, the exhaust leaks a bit of water out of the tailpipes a bit at idle.
View 3 RepliesFord F-150 - 1997-2003 :: Water Leak At Entry Assist Handle
I have had my 2001 F150 Supercrew for about six months. After yesterday's rain, I noticed there is now water dripping inside from around the passenger side entry assist hand. I opened the sunroof/moonroof but didn't see anything obvious there.
View 14 Replies