Ford Super Duty (1999-2016) :: 1997 F250 - Cold Engine - Heater Would Blow Either Cold Or Slightly Warm
I can't seem to get the engine temp to middle range on the marker, but yet my heater blows "to me" hot air. Even while sitting in idle for extended amounts of time I cannot get it to "operating" temperature. I would think if my thermostat was stuck open my heater would blow either cold or slightly warm air. I have the 5.4L engine with knn air filter and no cats.
View 14 RepliesFord F-150 - 1997-2003 :: 2001 4.6L Will Not Turn Over Or Start - Engine Rocks Slightly
I have a 2001 F150 step side 4.6L that just stopped turning over to start. The engine rocks slightly when you turn the key, then nothing but a little electrical smell. Was starting fine up to this past week. Battery is strong and good and upper battery connections clean, has original starter solenoid. I am a weekend mechanic, my son's work truck, trying to do this myself.
View 1 RepliesFord F-150 - 1997-2003 :: Exhaust Manifold Studs Missing - Engine Noise?
I was looking at my exhaust manifold..and I found a couple of studs missing...so if I want to replace both of them , is it better if I replace all of them on both sides of the engine ?
By the way..my exhaust manifold is good I don't think none of the studs are broken.. but I have been having this engine knocking noise on my engine, do yall think a couple of studs could be the problem of why my engine is knocking?
Ford F-150 - 1997-2003 :: Have To Rev Engine To Put In Reverse When Its Cold Outside
Problem I am having with my 2000 4.6L truck. When the outside temps fall below about 40deg F, I have to rev the engine a little (approx 2100 rpm) in order to get the transmission to shift from park into reverse. If I don't do this, it bogs the engine down and the motor dies.
Once I am in gear, everything works normally. I have no codes or lights. I have tried a new IAC valve, checked and replaced the trans fluid and filter. This is a very strange issue to be having. It SEEMS like it might have something to do with fluid flow? Like maybe the transmission cooler is plugged partially?
Ford F-150 - 1997-2003 :: 4x4 Slightly Trying To Engage?
Ok, have a 2003 fx4 auto trans with manual 4x4 ...I notice more and more that say at intersections, when I start out either turning left or right it feels like the 4x4 is slightly trying to engage, or a chuttering feeling..best that I can describe it. any thoughts, I have 106 K and do need to change out the diffential oils etc.
View 9 RepliesFord F-150 - 1997-2003 :: Engine Will Surge Up And Down 2 - 300 RPMs For About 10 Seconds When Cold
I have a 2002 F150 5.4 2 valve. only when the engine is cold, everyone once in a while the engine will surge up and down about 2-300 RPMs for about 10 seconds. also right when I put it in drive it will surge. I was thinking about pulling off the trottle body and cleaning it.
View 3 RepliesFord F-150 - 1997-2003 :: New Leaf Springs Have Slightly Different Arch?
I bought some new leaf springs for my 2000 F150XL and noticed one is different only slightly, it being in the arch one is 7 15/16 which is correct, but the other is 8 1/8. how much variable do they allow, will it make that big of a difference or will i be able to notice it after there on. I am happy with them but don't want to put them on and then the truck set uneven??? the reason for replacing the ones still on the truck is they are twisted and apparently broke they are 2/1 springs and having the new ones i can tell the #2 spring on the truck now are shorter like the ends are broke off and the clips moved around allowing for them to twist, so i really needed new ones.should i put the taller arch on a particular side or should i just put them on....
View 2 RepliesFord F-150 - 1997-2003 :: Missing When At Idle
it's missing at an idle and it acts like it dont wanna take gas but once you get it going on the road it does good. the motor is a remanufacture motor it's only got 6,000 miles, new coils, plugs and wires, cam sensor, crank sensor, idle air control, mass air flow,and temp switch.
View 9 RepliesFord F-150 - 1997-2003 :: AC Compressor Is Missing
So today, I planned on switching the belt, idler pulley and tensioner since at least two of them are making noises. After taking all of the stuff off, belt, idler pulley and tensioner... and since I always compare parts I buy to parts that were in, making sure they are identical and I didn't order the wrong one. So first up I checked my tensioner and the position of them or angles are different, completely different.
So Google it to view a few diagrams and bang! it hits me... the one I took out from my F150 is for a non-AC... so back into the truck and I'm looking. Didn't have to go far when I realized that my AC compressor is missing!!!!
I keep looking around and I see that yes, I did have AC in it before I got it; because the guts are there but sliced! Great, so the job went from easy and easy I mean buy compressor and install; but now since the guts were cut, the PO sliced the thing out simply put.
1.) What are the bolt sizes that hold the compressor in place?
2.) Is there a wire connector on the compressor? or no?
Ford F-150 - 1997-2003 :: Cruise Control - No Coasting When Put On Brakes Slightly To Slow Down
All, i have an issue ( or at least i think its an issue) with my 99 f150 5.4. When i use my cruise control, i notice when i put on the brakes slightly to slow down, it feels like its not coasting because you can feel the engine still engaged and wont coast. I think this happens even without the cruise on. What this could be? I have the latest update on the cruise control harness. I believe that was for power always to it even in off, causing fires.
View 3 RepliesFord F-150 - 1997-2003 :: Engine Ticking Noise / Slight Clatter For 2 - 3 Seconds Upon Cold Startup
I've got a 2003 f150 with the 5.4 and 128,000 miles with an engine tick. Its not an exhaust leak I know that for sure. It has came up in the last 20,000 miles. I've used motorcraft 5 20 w/ motorcraft filter. I've tried a kreen engine treatment with no change. Heres the description/syptoms:
-Slight clatter for 2-3 seconds upon cold startup (happens very rarely)
-top end ticking that is loudest and most noticable when warm (quieter when motors cold)
-not timing chains/tensioners etc because the noise is coming from the top end and most noticeable on the passenger side.
-at idle the tick is present-when you rev at idle, the noise goes away.
-Driving (or having the engine under any load for that matter) the noise gets louder.
-Anytime I accelerate, tow/haul, go up an incline the noise gets worse
-Sounds like a "whirring" sound from within the dash.
With all that said I am thinking the lash adjusters are getting noisy. I had a certified gm tech that has 40 yrs mechanic experience under his belt and builds prostreet muscle cars on the side look at it. He listened to it to it and that was his diagnosis as well as its not that bad so just live with it. The noise at idle doesn't bother me, its when im driving with the windows down. The noise drives me crazy and is a little annoying to me.
Heres a link to a video of the sound and keep in mind it is much louder now : Triton engine noise/tick - YouTube
Ford F-150 - 1997-2003 :: 1998 - Coolant Reservoir Smells Like Gas And Truck Smokes Slightly
I have a 98 f150 2wd 4.6 the truck began showing signs that it needed a head gasket about 2k miles ago, my coolant reservoir smells like gas and the coolant is a rusty brown color the truck smokes slightly and the oil cap has chocolate moose like substance from the oil mixing with water. I dont care to keep the truck to much longer however i need it to last me to the end of year. I purchased some k-seal and new oil/coolant etc but after thinking about it all of that chocolate moose up in the valve covers will still be in my motor after i perform the oil change and coolant flush. How should I go about attempting to clean the motor out ? seafoam scares me because i do not know if my rings are already damaged from driving while needing the head gasket, Or should i just keep doing oil changes until it looks clean?
View 3 RepliesFord F-150 - 1997-2003 :: Transmission Slightly Slip Out Of Gear When Accelerating From A Stop Light
I just bought a 98 f150 about a month ago from someone. The guy i bought it from said the tranny had been rebuilt about 4 months prior and i have the invoice proving it. I have lately noticed a hard shift from first to second gear, all other gears shift perfectly, but on my way from work toady the tranny seemed to slightly slip out of gear(in other words the rpms didn't shoot up, just loss of power) when accelerating from a stop light, and then it seemed to catch and started shifting ok. my question is given these symptoms is it possible that i can make this tranny last a little while longer or is it about to quit? any possible causes?
View 4 RepliesFord F-150 - 1997-2003 :: 2002 - Slight Missing At Idle
I have 2002 f150, fx4, ext cab, 110000miles 5.4 automatic truck, i just replaced my spark plugs, it still have a little miss, thought spark plugs will resolve but its the same, im wondering if i should change O2 sensors? clean EGR Valve? IAC valve? i am not getting good gas mileage and maybe its this missfire or something, its runs good without any problems, just this slight miss makes me think if its the cause to bad MPG.
I tried to find threads with pictures of how to change O2, how to clean EGR, and IAC, i remember seeing these threads but cant find em. And you think these three things will resolve my MPG and the slight miss?
Ford F-150 - 1997-2003 :: 4.2L - Suddenly Started Missing Under Load
My 4.2 liter F150 suddenly started missing under load. A little background: It is a late 2003 and has 75k miles. It has been in my family since new, and I have had it for the last 4 years. This truck is as stock as they come, and has been well maintained.
On my way to work yesterday, it began missing. Not bad at first, but got worse. It misses while under load and under acceleration. The "check engine light" never came on. I have not put fuel in in several days, and it ran fine until now, so I doubt it is bad fuel. I started the engine after dark and looked for arcing. None visible, and I even sprayed the wires with a mist of water. I pulled the plugs and they all look normal. The gaps were all way too large, so I regapped the plugs to .054". I pulled the coil pack and it checks within range with my VOM. Can the coil pack be the problem even though it checks out on the bench? Can the large plug gaps have contributed to a coil pack failure?
Where to start. I HATE just throwing parts at this thing, and I don't like wasting money... If I let one of the auto parts stores run a scan, will it show a code even though I have no check engine light? I used to think of myself as a pretty good diagnostician, but then again, when I used to spend a lot of time under the hood, those cars had points, condensers and carburetors...
Ford F-150 - 1997-2003 :: 2002 Sometimes Missing Upon Acceleration But Not All The Time
I have a 2002 f-150 4.6 that sometimes has a miss upon acceleration but not all the time.the truck is a 4.6 with a manual trans.has no engine codes and scanner never show a misfires but sometimes it does , have replaced all spark plugs and coil boots twice.
View 4 RepliesFord Fuel System :: 1997 - Missing When Engine Warms Up
I got a new ipr an looking in the oil pump end there's a small spring with a screw n the middle. Is this a pressure adjustment for the valve or what any body no. I have a 97 power stroke that when i start it cold idles fine as engine warms it starts to miss . I have changed everything i mean everything but ipr and map sensor.
View 1 RepliesFord F-150 - 1997-2003 :: P0401 Code / Occasionally Missing Under Load
Have a p0401 code which I need to diagnose and solve. However, I don't believe the symptoms are indicative of the EGR system. Its a 1999 4.6L auto approximately 200k miles. Truck runs fine until it warms up, and then occasionally it begins to act like its missing under load. steady state on the freeway it may have an occasional miss, but put a load on the motor and the miss becomes real bad. This doesn't seem to me to be symptomatic of a P0401 code, but I don't really understand the EGR system enough to be sure. Searching on the forums for other p0401 codes doesn't seem to have the same symptoms.
View 10 RepliesFord F-150 - 1997-2003 :: Missing / Died On The Side Of Road And Have No Spark?
I recently purchased a 1997 F150 4.2 Liter. On the way home it started missing. Within the next few days it died on the side of the road. After towing home I found no spark. A few days later I t started but only for a few minuites and died. No spark, coil pack is new so I replaced the CKP and it started up. Drove it about 1/2 Mile and died again, No spark again. Not getting power to coil pack when I am turning it over. So in short, new coil pack and CKP sensor and no spark. If it sits for a few days it may start or it may not. But if it does it only runs for a short period and then no spark again.
View 3 Replies