Ford F-150 - 1997-2003 :: Crank All Day But No Start
So she will crank all day but no start. Theft light is going nuts like I am trying to steal my own truck!! I've read it could be a PATS issue.
However after I unplugged my pos batt cable and hook it right back up she starts like nothing ever happened.
its only happening every once in awhile. but it does get old. I have been just leaving my pos cable off whenever I shut the truck off.
Ford F-150 - 1997-2003 :: Won't Start And Crank?
Took my dad's snailblazer (trailblazer) since the 4.2 i6 in it gets better mpg than the old worn 5.4 in the f150. Well I didn't leave much gas in the 30 gallon tank about 1/4 tank or 7 1/2 gallons. My dad took it to the gas station on Friday and filled it to 3/4 of a tank. Got back in the truck and attempted to turn it over and got nothing.
Battery cable was a bit loose from what he told me, so he tighten it up. Nothing. I know the fuel pump is still going cause when you turn the key forward you can hear it whine. Starter is only a few years old maybe 6 or so. Not sure if that went bad or something else.
Last time something similar happened the A/C compressor seized up and wouldn't allow the engine to turn over. Well we eliminated the compressor around '09 and bolted a pulley in its place. Off the top of my head I can't think of anything that would have seized up causing this.
Ford F-150 - 1997-2003 :: 1999 V8 - No Crank / Would Not Start
I have a '99 F-150 with 4.6L V-8. The truck has run perfectly since I bought it a year ago. My grandson took it a short distance to a neighborhood store, and when he got back he parked on the neighbor's lawn.
IMMEDIATELY after turning it off, I told him to move it, and it would not start. Wouldn't even turn over. I did a little research, and replaced the most likely culprit, the starter....no change in condition. When keyed to start, the dash lights up, but that's it! I did get under the truck and there IS voltage getting to the large power lead.
The starter has it's own solenoid, however there is another one mounted to the firewall. Does this have anything to do with the starter?
Ford F-150 - 1997-2003 :: No Crank / Start After Tune Up
My 1999 F-150 is having an issue after a tune up; changed coil pack, plugs and wires. It started and ran fine before, but after the tune up it doesn't even crank, just clicks and clunks. I hear a whine from the alternator, but last I checked (a couple days ago), it tested fine so I dunno if it went bad.
I thought it was PATS, but the theft light turns off when the key is in the on position and the fuel pump primes. I dunno if it's the battery, but it tests out OK with my voltage tester (12v+) But it may not have the amps required.
If the coil pack isn't grounded right, like if the platform it's on is corroded, would that cause this issue?
Ford F-150 - 1997-2003 :: 1990 - No Start / Would Not Crank
I left my F150 to sit over the winter parked near my house. Battery was bad when I went to start it a few weeks ago. Got a new battery, threw it in, but still no start. It wouldn't crank.
Went to work on it today and the battery was totally dead, took it to schucks and they said it was bad. So I got it replaced with a fresh one and I'm still getting the same thing.
Turn the key on and accessories come on, turn it all the way and nothing happens, except for the aftermarket radio turns off. I replaced the ignition switch last year. I tore apart the dash to see if that went out again but it looks fine.
What should my next step be?
Ford F-150 - 1997-2003 :: 1999 V6 Getting Power But No Crank / Start
I am having problems with my truck not sure where to start. It was my everyday truck until one day I got ready to leave for work and the truck wouldn't say anything. It was getting power but no crank no start. Called tow truck he checked battery said that it was good. I got home tried to start truck and it started. I drove to the store and it did the same thing no crank no start. It has 110,000 Sigle cab manual windows...
View 2 RepliesFord F-150 - 1997-2003 :: 2002 - Crank But No Start Or Spark
I have a 2002 F150 5.4L (VIN-L) that has been sitting in the driveway since February. I have been a mechanic for 30 years for large commercial trucks, and my own truck has me stumped. I'm sure I've forgotten something but I'll try to list everything I have tried so far. It started with crank no start, no check engine light, checked for trouble codes got a trouble code for the CHT(cylinder head temperature) sensor.
- Replaced the CHT sensor. Cleared codes.
- Dash lights up fine, shows mileage, and anti-theft is not flashing while cranking.
- Fuel Pump does not seem make any sounds. Hit the tank with a hammer. Nothing.
- A little fuel comes out of the schrader valve on the fuel rail when I push on it. I have not checked it with a pressure gauge.
- Attempted to start with ether, nothing, so I'm assuming no spark.
- Fuel pump inertia switch isn't triggered.
- Checked several ground connections to the frame and checked ground connections in the PCM harness. All have less than 5 ohm resistance.
- Unplugged and plugged back in cam shaft sensor.
- Checked voltage on the TPS(throttle position sensor) I'm unsure about the results, if the TPS was bad wouldn't it just idle funny and/or stall?
Fuel Pump and PCM relays in the underhood fuse block appear to be good. All other fuses and relays appear to be good. I have been swapping the relays with one I think is good, although. Searched all over for additional relays, and found 3 inside the cab behind the passenger air-bag. Can't seem to find anything in the Haynes/Chilton manual that lists what they do. They are about half the size of the fuel pump relay.
Manually grounded the fuel pump relay, relay clicks but I don't hear a buzz from the fuel pump. Id like to run 12V to the fuel pump directly to see if that's my issue, but I'm not sure where to connect it without frying something important.
I bought the alldata.com DIY guide for my truck and it hasn't worked much. I have read extensively about others with similar problems and I just don't know what to do next. My main question here is, if the fuel pump is bad, would that stop the spark plugs from working? I'd rather not replace the fuel pump without being absolutely sure.
Ford F-150 - 1997-2003 :: Truck Won't Crank Or Start After Warmed Up
I have a 97 f150 with a 4.9..... I drove it less than a half a mile and shut it off. when I got back in it to start it up it wouldn't do anything like the battery was dead but all the electrical worked but it would not turn over. after about 4 hours when I returned, it started just fine. drove it straight home and shut it off and immediately tried to start it again and had the same issue. What the culprit may be ?
View 1 RepliesFord F-150 - 1997-2003 :: No Start Just Crank - Theft Light Blinking
i have a 99 f150 with a 4.6 that will not start. it has sat for a while now. when i go to turn the key to turn it on it cranks and cranks and cranks but wont start. the theft light blinks like crazy and the odometer reads dashes. There is also a relay which i do believe is the pcm relay that clicks like crazy. when the relay clicks and the key is first turned to the on position the fuel pump will turn on and off as the relay clicks.
We tried putting a scan tool to it to try to pull a code and the scan tool wont connect. I do believe its the pats system kicking, but i also think its related to this relay clicking like a mother, maybe a bad connection in the junction or something. But I am not really sure how to try to start and find the problem. i have also tried replacing the relay that clicks and the new relay does the same thing.
Ford F-150 - 1997-2003 :: Remote Start Will Crank The Engine Over But Not Fire
I just picked up an 02 Supercrew. It came with a “Ford” remote starter. I imagine it was a dealer install for the previous owner. Anyways when I try to use the remote starter, it will crank the engine over but not fire. If I manually start the truck it fires up immediately. How come the remote start wont fire?
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: 1997 - Crank But Won't Start?
I have a 1997 F350 7.3 with standard xmission. Have not messed with it since Oct of last year. Then it would crank but no start. Now when I turn the key there is no wts or nothing the gauges move, and tach moves when cranking, but nothing else.
The cam and crank pos sensors have been changed. The high pressure sensors changed. Now when I hook it to the AE it says cannot connect to truck. Where I need to start? Have checked all fuses that I know about.
Ford F-150 - 1997-2003 :: 1998 - Turn Key But Won't Crank / Start - If Started Then No Radio?
I have a 1998 F150, had this truck for just shy of 200,000 miles, never a major problem and now she's killing me. Turn the key, no crank,no start, the same time this started the radio also quit working. I can start her with a screw driver at the soleniod (new by the way) runs perfect after that. By the way it's a 2 wheel drive with the 4.6 v-8
View 1 RepliesFord F-150 - 1997-2003 :: No Crank / No Start - Relay In The Fuse Box In Dash Clicking
I have a 98 f150 Lariat 4wd Automatic with a 2000 4.6. When i turn the key the only thing that happens is i hear a relay in the fusebox in the dash clicking. I can cross the starter relay on the firewall with a screwdriver and itll start right up. Heres what ive done troubleshooting wise.
1. Checked battery terminals. Fine, it will start with jumping the relay so it seems good with that regard.
2. Tested the relay per the manual. Good.
3.Ohms Tested the white ignition switch box under the dash per manual. Good
4. Voltage tested the Trans Range Sensor per manual. Good.
5. Checked over all fuses, none blown.
6. No theft lights come on.
I figure since it will start jumping the relay that the battery, starter, and starter solenoid are all good. Only thing i cant seem to find is the Starter Interrupt Relay, or any sign of fusible links on the main battery cables. I am really at a loss here i figured one of the components ive tested would be it.
Ford F-150 - 1997-2003 :: 1998 5.4L Engine Won't Start / Starter And Crank Pulley Turns
I just got a 1998 F150 5.4l 4x4 autotragic. Was sold to me as needing trans, wouldn't start. Tossed in a new starter and solenoid, now I can hear the the starter turn crank pulley turns maybe a quarter inch and when I let off the starter it goes back to the same spot.
Fear is motor is locked, but question (i don't know automatics) is there any way that a bad trans could keep a motor from turning over? Truck rolls in neutral or drive, pulled the drain plug no water just oil. Tempted to just buy a running 5.4 with trans but if I can avoid that I'd prefer to.
Ford F-150 - 1997-2003 :: Crank But Not Fire Or Start / Read Codes By Malfunction Indicator Lamp
Have a 2000 F-150, 5.4L. Once recently in a parking lot, it would crank but not fire or start. Wife called me to come get her. By the time I got there, she said it started "after she loosened the gas cap & re-closed it." But, it started fine for next several weeks. Yesterday it didn't. I read a bunch of threads here on possibilities. Many troubleshoot items I checked out or had done.
Chilton manual says you can get limited error codes from the light on dash flashing - MIL - Malfunction Indicator Lamp Method.
For now, I'm trying to find the 2nd, separate, one-wire lead "near or with the (main) Diagnostic Connector." They call the single wire / connector the "Self-Test Input connector" (STI). You're supposed to use a jumper between that STI & the upper, right connector of the main diagnostic connector. Then you (may) get flashes corresponding to codes via the key on, engine off method.
I see no such single wire lead or connector anywhere near there. Not up under the dash either - stuck my head under there & used mirror. There's a separate connector (not in use) clipped on the L side of the main diagnostic connector, but it has 5 pins inside. I took pics, but forum says I "may not post attachments." Been a member for yrs. That extra 5 pin connector faces toward firewall.
There's an "empty hole" - 1/4 in. (facing forward) in the bracket that holds the main diagnostic connector. Just above the main connector. Not sure if something was ever there
If no one knows how / if the Malfunction Indicator Lamp Method works or where the jumper goes, I'll be forced to buy a code reader w/o researching which are decent or crap (around $200 or less). I maybe? could wait to order one online (if knew which one). Also have AutoZone, O'Reilly, Advance, NAPA, PepBoys & others locally.
* The truck shows a check engine soon light, so should be a code already. * Yes, I tried her loosen / tighten gas cap trick.
* Also put a slow charger on for a while & even used the fast start setting on charger. No go, but engine turns really fast.
* Crawled under the gas tank & listened for fuel pump to activate when key is turned to Run.
* Fuel pump made a small noise - more like a relay or "clicking" - not a whine or whir.
* Checked most fuses - under dash & hi voltage box - that have anything to do w/ fuel pump, PCM & several others - mentioned in similar threads here.
Can't really check relays & don't want to just start replacing parts. I don't have a code reader & reluctant to buy one from local store w/o some reasonable research. (I don't mind buying one, but...). If I could drive it to the auto store, I wouldn't be asking this. Chilton's doesn't say if this malfunction indicator lamp method will work if a vehicle won't start. But, a code is already thrown.
Ford F-150 - 1997-2003 :: 1999 XLT - Crank No Start / Theft Light Flashes A Code Of 1 Then 4 / PCM Not Power Up
I have an intermittent security system issue. I sometimes get a dotted line in odometer and rapidly flashing theft light.
Crank no start. After a time, the theft light flashes a code of 1 then 4. Research gives me the result that PCM did not power up.
Have pulled gauges. Fixed known cold solder joint issue. Checked all connectors and reinstalled. Truck starts fine about 7/10 tries.
I have replaced battery terminals. Removed cleaned and replaced all firewall grounds. Checked harness connection blocks and PCM connector. Made sure all under hood fuses and relays working.
Currently sitting in a parking lot waiting for it to decide to start again. Only one chipped key. Where to look next? 1999 F150 xlt 6 cylinder.
Ford - F150 :: 1997 Truck Won't Crank Or Start
I left the keys in the ignition last night. I didn't think it was left on, but apparently it was. This morning when I tried to crank the truck, it wouldn't start. The dash lights came on, but it didn't make any sound. I tried to jump it off, and it still won't turn over. What it could be??
The truck that wouldn't start was a 97 Ford F150, the car I was trying to jump it with was a 96 Honda Civic. Someone told me that might be the problem, that the small car wouldn't give enough power to a truck...
Ford - Explorer :: 1997 - Just Crank / No Start Unless Hold The Gas Pedal To Floor
I'm working on a 1997 4.0 ohv and it has a hard start condition on first start up. any after that it will just be a crank no start condition unless you hold the gas pedal to the floor. Replaced the camshaft actuator, plenum gaskets, coolant temp sender and thermostat, fuel pressure is normal.
View 5 RepliesFord - Escape :: 2003 - Engine Crank But Won't Start
Car not started for 5 months. 50k actual miles. Battery dead and replaced. Engine cranks but will not start. One squirt of starter fluid into air intake and it started immediately. Stopped and started several times (without starter fluid). Drove around block. Stopped and restarted with no problems. Let set for 1 hr. Started but ran only a couple of seconds and died. Will not restart but sounds like it is trying. Did not try more starter fluid again. Checked computer codes and none found. Can hear fuel pump run a few seconds when key turned on. Gas tank almost full but no gas added since last time it ran. Sounds like it is not getting gas?
View 9 Replies