Ford F-150 - 1997-2003 :: 1998 - Intermittent Battery Light / Low RPMs
1998 F150 4.6 automatic.
Had problems with battery light. Was intermittent. Battery cables wouldn't stay tight, replaced them, light stayed off. Light back on now, constant. Battery reads 12.5ish off, 14.3ish running under load (lights, AC, etc.).
When truck is started, even cold, it doesn't rev up the RPM's and then die down to idle speed. It just goes straight to around 550rpm and surges slightly up and down between there and 650ish. Can these be related?
Ford F-150 - 1997-2003 :: Battery Light And CEL On With Key Off?
Not mine, but the guy claims his trucks battery light and CEL are on with the key off??? He's battery goes dead (it is new) and only 12.3 volts running with it revved up. My inclination would be alternator, but how can those 2 light in the dash be on with the key off? He did replace the ignition switch.... nothing ...same condition.
View 2 RepliesFord F-150 - 1997-2003 :: ABS And Battery Light Will Go On When AC Is On
I have a 2003 F150. When the temperature is hot outside and I have the air conditioner on the Gauge will sweep and the ABS light and battery light will go on. The battery gauge will go to high charge. When RPM is dropped (idle) or when the RPMs are increased to pass a vehicle, everything returns to normal. Power windows will not work but all other functions due. It will boil my battery if ran to long like this. I have changed the alternation and battery. Only happens in the summer?
View 1 RepliesFord F-150 - 1997-2003 :: Battery Light On Dash
This ID10T light came on last weekend, and I just started trying to fix this. I found this post [URL] ....., but this isn't my problem.
The alt is old, but tested good four times at Napa. Battery is three years old, and it's holding good charge. My scan gauge 2 is showing 11.4-11.6, and I'm guessing this is what's throwing the code, although there isn't an actual code.
I don't have the money to go just start replacing parts, and I need this truck for next weekend, 10/3/15, so I hope to find something by then.
At 2000rpm the SC2 is still showing 11.6 volts, so would it be the charging system? Volt reg? Something in there is clamping the voltage down. At 18 years old, and 250k miles I'm not afraid to put new parts into.
Ford F-150 - 1997-2003 :: 1999 - Low Battery Light On?
1999 F150
automatic, v8 4wd 430K miles Low Battery light is on.
Other than the usual things to check: battery cable connections, corrosion at contact points, checking with a voltmeter, having battery tested, having alternator tested for volts and amps... are there other known issues with this year model/setup?
Also, once the battery is changed, is there a way for the codes to be cleared out or reset without having to hook it up to a computer?
Ford F-150 - 1997-2003 :: Battery Light Won't Go Off Even After Replacing Alternator
I have a 1998 f150. Was driving down the road the other night and the truck loses all power. I have replaced the alternator and the battery loght stayed on. So, I took both old and new altrrnator to parts store and had them both tested and they bith passed. Is this a commomn issue?
View 7 RepliesFord F-150 - 1997-2003 :: Battery Light On - Alternator Or Regulator?
The other day the battery light came on. Of course the useless "gauge" still reads normal but that is another rant.
Checked voltages today:
Battery reads 12.0 volts key off, 11.83 key on, engine off, 11.65 engine running.
Obviously discharging and I am guessing it is the alternator. Do these trucks have an external regulator that may have failed or is it in the alternator? I'd hate to spend $150-200 for an alternator only to find out it doesn't solve the problem.
Ford F-150 - 1997-2003 :: Battery Light On And Kind Of Flashy
It all started......when I got onto the highway and glanced down at the gauge cluster and noticed my battery light was on and kind of flashy (clipping, so to speak)...and that I was in 2nd gear...whoops. (My tach's busted, else I probably would have noticed that sooner.)
Quick correction and things are right as rain. The next day I go out and make 3-4 stops with less than 10 minutes of drive time between each. I'm almost home (battery light's been on intermittently since last night) and the idle slows slightly and the windows no longer work. I make it home and the gauge cluster is dead by now, but leave the truck running, grab a socket wrench and pry off the positive battery lead. Truck dies.
I'm thinking alternator, so I pull the battery and charge it inside, then pull the alternator the next day and have it tested. Tests fine (putting out 1430 (is that mA?) per O'Reilley's). Crap. Cleaned all connections (including taking off the negative terminal grounded to the starter and shining it up a little, then pulling the connections off the firewall and sanding them lightly), checked 20A inline blade fuse, both 175A fusible links, but it's still not charging. If I want to go anywhere, I have to pull the battery and charge it inside.
I was thinking it might be the voltage regulator, but I just called O'Reilley's and they told me that the test on the alternator included the regulator. I just confirmed that the belt on the pulley is okay. What did I most likely fry that caused my battery light to come on? (97 4.6L)....
Ford F-150 - 1997-2003 :: Battery Light On Intermittently - Ground Location?
F250 LD 99. Battery light flashing from time to time. When it happen voltage gauge in dash go up (but not in red zone so far). All other light are blinking too but not on and of like battery warning light then like stronger - weaker. So far at Internet is said should be ground. I saw one ground at firewall close to negative post of battery but where is other ground? Can it be voltage regulator (alternator)? Did clean battery posts, didn’t work. 4,6 engine. Voltage at battery posts with engine on is 14,7 - 15,1 V. With engine off 12,3 V.
Didn't managed to check voltage when is battery light flashing as it only happen when I drive not at idle.
Ford F-150 - 1997-2003 :: Blown Intake Manifold Gasket / Battery Light Comes On
just got finished putting her back together from a blown intake manifold gasket and run for a few miles to get rid of any cob webs and then my battery light comes on. just replaced the battery last week. and I tested the alternator and it charging at 14.5 volts bat reads when disconnected 12.9 volts so I am not sure why my battery light will come on.
View 14 RepliesFord F-150 - 1997-2003 :: Battery Indicator Light On Dash Started Blinking Intermittently
Just bought my first F150. 1998 XLT 4.6l automatic. 126K miles, looks like it was mostly garage kept. All power, A/C, etc.
Picked it up this evening, drove it home after dark. About a 30 mile mostly highway speed drive. Everything went fine, no problems, no hiccups......Until I turned on my last street, about a half mile from home. The battery indicator light on the dash started blinking intermittently. I didn't notice anything else, just the red battery shaped light blinking.
What would cause this, what should I check? I don't want a big problem when I haven't even transferred the title yet!
Ford F-150 - 1997-2003 :: Gauge On Dash Is Running High And Battery Light Flickering
Over the past weekend i noticed all the electronics having a slight "flicker", so I figured my alternator was on its way out. After replacing the alt with a reman, I still had the issue. Then, replaced it with a new new one and the issue still persists. I will be getting a meter to test later when my buddy gets off work. The gauge on the dash is running high and battery light is flickering. Is there something I am missing? I ran another ground to frame also.
2001 SCAB 5.4 144,000mi 4x4 ....
Ford F-150 - 1997-2003 :: 1998 - Battery Light Only Off Over 2400 Rpm - Humming Noise Form Background - Alternator?
Vehicle is 1998 F150 with 194k. The battery is 1 1/2 yrs old and belts and alternator are original.
Yesterday morning my VHF and dog tracking eqipment started humming with the truck running. The hum on the tracking eqpt. only happened when I pointed the antennae over the direction of the hood with truck running. When I shut truck off everything is normal. Later in the day the battery light came on. The battery light would go off if I kept it over 2400 rpm's. The charge on the dash was normal but as I got closr to home last night it dropped to almost nothing and the lights were very dim.
I am thinking alternator. What I am confused about is the humming noise in the background. The tracking eqpt. is completely separate from the truck while the VHF is direct to the battery with an iline fuse. Bad voltage regulator?
Ford F-150 - 1997-2003 :: AC Seems To Get Cooler At Higher RPMs
My ac seems to get cooler at higher rpms. I looked online and it appears to be the orifice tube...
View 3 RepliesFord F-150 - 1997-2003 :: RPMs Drop To 330 While Braking
Two weeks ago Sun, truck ran fine, however Mon morning all hell broke loose. Truck was running very sluggish and stalling while coming to a stop. My first thought was tune up. I replaced the plugs and wires. During this I found that i could not get a socket around the ever loved driver side rear plug so i was only able to replace 7 plugs however in that process i managed to break the metal coolant tube that runs to the heater core.
Aday later replaced the entire intake manifold,egr valve, egr tube, IAC valve, both coil packs, fuel filter, tranny fluid and filter. During the removal of the intake i looked at the rear spark plug and found that a screw had been wedged into the hole breaking the plug and got it changed now it is all back together and the truck runs amazing however did not solve the low rpms during stopping. ive replace the above and checked fuel pressure which is good.
I have a TPS sensor just haven't installed it yet not sure if it is related to the issue. Tranny guy says it may be a bad solenoid or TC however last night I reset the PCM and drove it it ran flawless. this morning the problem returned which leads me to believe its not the tranny. ok one last kicker that 6 experts have failed to answer when i manually put the truck into 2nd gear the engine dies! no studder no fighting just quits.
Truck is a 98 F150 4.6 V8 186,000 miles i have yet to
1) change TPS.
2) clean throttle body.
3) clean MAF sensor. n
Not sure if any of this has an effect on the issue. There is only a EGR insufficient Air flow code..
Ford F-150 - 1997-2003 :: Will Not Shift From 1st To 2nd / Revs Up To 3200 RPMs
I have a 98 F-150 that just went under a trans rebuild. It now will NOT shift from 1st to 2nd. It revs up to 3200rpm's, shifts to 2nd then chirps the tires as it immediately slams back to 1st. Is it possibly a solenoid issue? Looking for some useful info.
View 13 RepliesFord F-150 - 1997-2003 :: Rough Idle / Engine RPMs Go Up To 2k Before Dropping Down
1999 F250 LD with 5.4 w/ 225k miles... Was running perfect yesterday when I shut the engine off. Started back up about 20 minutes later and Idles was up and down and rough.( 400 - 900 rpms) Drove and ran fine except Idle. I know that those codes are for the o2 sensors but don't believe they're bad. I hear what sounds like a vacuum leak somewhere behind throttle body. Either IAC or EGR or it could be coming from the line that runs in beside the IAC valve to the air intake in front of the throttle body. Tried spraying water in those areas with no results. Could it be a bad EGR valve or a stuck IAC valve? I have also noticed that lately when I start the engine the engine rpms go up to 2k before dropping down. Would a bad IAC valve cause such rough idling along with the codes that I described?
View 7 RepliesFord F-150 - 1997-2003 :: 1998 - RPMs Speed Up After Shifts Into Drive?
I have a 98 F150 4x4. I had some trans trouble so I pulled it out and had it rebuilt. Now when it shifts into drive the rpms speed up right before it shifts. What is causing the trans to do this? It doesn't do it all the time, only if I take off faster the usual which is most of the time.
View 1 RepliesFord F-150 - 1997-2003 :: RPMs Drop / Surges Over Bumps Only - CEL Flashes On
So I know there has been lots of posts on surging issues and how to troubleshoot. My truck is a 97 f150 4x4 xlt 4.6l v8. I have noticing surging and dropping in my RPMs lately. No CEL. I have kept a journal when I notice when it happens. I only have issues when I am driving around 40-50 mph and if I go over bumps/pot holes/rough spots in roads or when I'm braking over bumps/pot holes/rough spots, my truck surges/RPMs drop CEL flashes on and off only during these instances. Makes me think something could be loose or something causing this. It has stalled at times when having to brake fast (yellow light, etc.). Where to look first? 1997 F150 4x4 4.6 V8...
View 1 Replies