Ford F-150 - 1997-2003 :: 2000 - Heater Won't Getting Hot?
My hubby is working on a 2000 F150. The heater does not get hot. He has checked the blend door and it is functioning correctly. Is there a valve on the back of the engine that shuts the water off going to the heater core?
View 5 RepliesFord F-150 - 1997-2003 :: Bypass Heater Core On The Fly
My commute into the office was more difficult than usual because of the fumes pouring out of the vents. I have a 1997 F-150 5.4 V8. should I remove both in and out hoses from the firewall and connect them with a plastic fitting not to risk breaking the aluminum fittings on the motor?(There is an advanced a mile away) OR is it possible for me to remove the in hose from the firewall and remove the out hose from the motor, and run the in hose directly into the motor. Are the fittings the same and can I do that with limited time and tools?
View 8 RepliesFord F-150 - 1997-2003 :: Heater Blows Cool Air
I took the dive into a new heater core, as the heater was not getting hot. These are the things I did while on my adventure.
1. Before reinstalling the hoses, I blew thru them to make sure of no clogs...water flew out the other hose..no problem..no clog.
2. inspected mix door not cracked or broken...no problem
3.actuator opens and closes ok, I assume, I can hear the motor run and the door thump closed...no problem
4. water and anti freeze level good....no problem
Start vehicle,let warm up, turn on heat.....No Heat...
5. check hoses at core, one is hot ,the other is not....Problem...
1997 f150 4x4 ...
Ford F-150 - 1997-2003 :: High Fan Speed Only For AC Heater
I have a 2000 f-150 4x4 that has only high fan speed for a/c heater. Speeds 1-2-3- no longer exist. Is it a switch or a control module? Also, the door code for the rear differential is 19; is that limited slip?
View 8 RepliesFord F-150 - 1997-2003 :: Hooking Up Heater Hoses
I've replaced my heater core and blend door in my 2000 and getting ready to button things up. Can I hook up the heater hoses after the plenum top is screwed on to keep the core from moving when pushing on hose connections?
View 1 RepliesFord F-150 - 1997-2003 :: 2001 2WD - Heater And AC Not Working
I have a 2001 F150, 2WD, 5.4L. Neither the heat nor the air conditioning works. The blower works fine on all settings, and the air blows out of the correct ducts in accordance with the switch settings. The problem is the heat does not blow hot, and the AC does not blow cold. Everything is just the temperature of outside air.
If I jumper power to the compressor at the relay socket in the fuse box, I can make the compressor run and it provides cold air. The relay does not seem to be the issue because replacing the relay does not work. The heater core is hooked up, just no hot air.
I was thinking maybe the problem is in the temperature level switch in the dash panel. Does that sound like the best possibility? Do you think these problems are connected, or am I looking at two different issues.
Ford F-150 - 1997-2003 :: 2000 - No Air Blowing Through Heater
My 00 f-150 is not blowing air through the heater I replaced heater core and the temp door I had same problem before work done I did not see an issue when apart but no vacuum or electric to test when apart. The only thing that changes when I move selector for vent floor and defrost I do get a little better flow when on vent. My feet get cold and defrost is not working well if I put hand on defrost I feel warm air but 3-4" away when on floor; I feel nothing anything at all fan seems fine.
View 3 RepliesFord F-150 - 1997-2003 :: Heater And AC Control Switch Works When It Wants To
Got an 01 f150 excab with the 5.4 as of lately sometimes when i turn the 1-4 blower control know it wont do anything on heat or ac than other times it will work like it supposes to?
View 2 RepliesFord F-150 - 1997-2003 :: 1998 - Heater Blows Cold?
1998 F150 step side, 4.6 V-8 automatic, 176,000 miles -
Heater begins to blow heat as the engine warms up - heat gauge moves up to normal level - running at speed, suddenly the heater blows all cold, the heat gauge pegs to total hot - the oil light comes on, the engine begins to miss - stop the truck, shut off the motor, wait 10 seconds, start back up and all is normal and away I go. Heater working just fine. Gauges are just fine. Have checked the hoses when it pegged to hot, and they are just warm just as if everything is normal.
Problem is intermittent.
Have changed radiator reservoir cap, thermostat, made sure fluid level and mixture is correct - what else to check? Computer issue?
Ford F-150 - 1997-2003 :: 1998 - Heater Hose Blowing Off
98 F150 2wd 5.4 -even though VIN says its "W" 4.6; it has a 5.4 with 4.6 timing setup-found. But that's a whole other story...
So, Replaced heater core. did the blend door too.
A week later it overheated and blew a heater hose off the core at the firewall (several times). Temp was up and down, forced me into cylinder head protect mode, so i called my mechanic.
Mechanic used a sniffer (blue liquid turns yellow) in my overflow tank and there was exhaust gas in it... so we replaced head gaskets, intake, timing, water pump, radiator and the rotted out rad support.
Got it done and back on the road, but a few weeks later and the heater hose quick disconnect blew off again, spewing coolant all over (again). This was what we thought was part of the original problem- head gasket allowing cylinder compression into the coolant passages. the little rubber hose that comes from the back of the intake and goes up into the heater core builds enough pressure to pop the disconnect right off and I dont know why. Like I said- I thought it was the head gasket blowing pressure into it but that's all been replaced. Why the pressure would be so high at that point, and how do I correct this?
This is my daily driver, so for now I've bypassed the heater core, but I'm afraid that pressure is gonna burst a hose and/or fitting again.
Ford F-150 - 1997-2003 :: 1998 - Heater Core Replacement?
How to replace the heater core?
View 13 RepliesFord F-150 - 1997-2003 :: 1999 - Replacing The Heater Core
Friend of mine has a 99 Ford F150 with the 5.4L. He thinks the heater core has gone on it as it blows a mist through the top vents when he turns the heater on. He can also smell antifreeze. Up here in Canada, its, well quite cold, nuff said about that. He has had estimates of anywhre from $800-$1000 to change it whereas the cost of the core is below $100. Is there anywhere that he can get a diagram.... of how to change it, all he knows was that he was told to remove the entire dash to gat at it.. Is that true ?
View 14 RepliesFord F-150 - 1997-2003 :: No Heat / Both Heater Hoses Are Cold
Ok I have a 97 f150 4.6L. My radiator has been bad for a while. With brown rust color. I replaced my radiator, thermostat, new upper and lower hoses. Everything runs great but I have no heat. I flushed everything including the heater core. Core is not leaking into cab, and both heater hoses are cold. FYI heat worked great until 5 days ago.
View 7 RepliesFord F-150 - 1997-2003 :: 2001 - Heater Core Replacement
I have a 2001 F150 with a 4.6L.. Do I need discharge the AC lines when replacing the heater core? How difficult is it to replace the heater core?
View 5 RepliesFord F-150 - 1997-2003 :: 1998 - Heater Core Has A Leak
My heater core has a leak in it, but I can not get it replaced so I want to bypass it. How do I do that? Is there a video somewhere? Or tutorial with pictures? F-150 1998 ....
View 8 RepliesFord F-150 - 1997-2003 :: 1998 - Can A Heater Core Slowly Go Bad
I have 1998 F-150 and the heater core was replaced 18 months ago. All was going well until about 2 weeks ago I noticed under heavy acceleration I would smell antifreeze. The smell would clear up and would not re appear for a day or so. Finally the other day when it was 8 outside I got in the truck and got about 5 miles from the house started up a hill and it was like a fog machine was mounted behind my dash the windows fogged up almost immediately so I figured great the core went bad again. Now the temperature has warmed up the last couple of days and there is nothing no fog in the cab the heater works fine just an occasional slight smell of antifreeze. Before I go through the trouble of tearing out the dash is there anything I should check I already checked the connections on the firewall and they were fine.
View 5 RepliesFord F-150 - 1997-2003 :: AC Compressor Clutch Engaging While Heater Is On
soo a friends 03 f-150 w/ the 4.6 has noticed the a/c compressor clutch engaging while heater is on. clutch engages for about 3 seconds or so and kicks back out consistently but only w/ the heater on. a/c dose function property when using a/c functions... Is this normal or does something need serviced???
View 3 RepliesFord F-150 - 1997-2003 :: Bypass Heater Core Now A/C Not Working?
I have a 2003 f150. I had to bypass the heater core and now my A/C isn't working. The A/C compressor don't even come ON.
View 5 RepliesFord F-150 - 1997-2003 :: 2001 - Heater Will Only Blow Through Cold Air
So the heater on my 2001 f150 will only blow through cold air. I thought that I may have a heater core clog so I back flushed it with water until it was coming through clean and unrestricted but that didn't solve the problem.
Now, some things to note are a potential coolant leak. I can't seem to find one but I filled up the antifreeze about two months ago and when I checked it the other day it was more or less empty. I've filled it up again and I will monitor it for the next couple of days.
Another thing to mention is that no matter what setting I have the heater on (ie 'panel' or 'defrost') I get cold air blowing at the passenger side's feet. Is this indicative of a hose leak or something?
Also worth noting is that the intake hose to the heater core gets hot after driving but the outtake stays cool. This is why I originally thought I had a core clog.
Should I be checking my blend door? If so how to I access it?