Ford 7.3L Power Stroke (1999-2003) :: 2002 F250 Starts Then Dies - Shut Down While Driving
My truck is an 02 F250 7.3 with 280,000+ miles on it, so I wouldn't be surprised if I might have a number of things going wrong. It runs pretty good, but is still far from 100%, at least up to my standards. So the problem has been going on for the last two or three weeks and got worse today, and there were a few things leading up to it as well. I'll start off with the first thing that happened that I think might be related. It was about 6 months ago, my buddy and I were putting my new headlights in.
It was parked in his garage and we backed it out a little bit to try and adjust them. It was sitting there idling for a minute or two and just shut off or almost stalled out. Tried to restart it and it wouldn't start, tried multiple times to no avail. It acted similar to when I had glow plug troubles when I first got the truck, it would just crank and crank, but never actually kick over and start, along with putting white smoke out the exhaust. Ended up waiting about a half hour and then the truck fired right up with no problems after that, so I didn't think much of it.
Then fast forward to last week to when something similar happened. Started it up after sitting for a few days, started right up, idled for a few seconds and then just shut off. Started it back up ran for a second and died again. Tried a third time with the same result. Fourth time fired right up again and stayed running, let it run for a few minutes and was fine. Also along with this, there was a bad squeaking coming from the front of the truck, like what a belt would sound like. I have recently replaced the belt because it was squeaking and actually got chewed up and almost shredded completely apart.
So not sure why it is squeaking again, but not sure if this could be related or not. Then took it back to my dorm room to get my stuff, and then made it the hour or so drive home from school, without issue. Even went to a few stores before I went home, and shut the truck off and started it back up multiple times, again with no issues. When I drove back earlier this week it was fine until I got there and put it in park. It idled for few seconds and then cut out for a second, but then idled back up and continued to run fine. It has done that a few times as well. So it will do it on a cold start or after already fully warmed up.
Then it got worse today. Again had trouble starting it cold, same as what I explained early. Except second time cranking it wouldn't start at all, then on the third crank it started up and stayed running. But on the drive home is when it got worse. About 5 or 10 minutes into my drive, was just cruising doing at about 45 or 50, and truck just shut off, died/stalled out. It cut out and shut off for a second or two and then started itself back up and continued on like nothing happened. It scared the crap out of me the first time it happened, I was waiting for something like that to happen, but still wasn't quite ready for it.
The truck acted just like it would before you start it, with the key on, dash lights worked and the radio still worked. It did this 4 more times in similar ways, would die and then start back up, at various speeds and at roughly 5 or so minute intervals. I decided to just keep going as long as the truck would start and stay running, hoping to make it home. It did it a fifth time and this time the truck completely shut off and wouldn't restart itself. It was hard to see, as I was watching a few different things at one time, but I think it tried to restart, I noticed the tach bounce between 200-400 RPMS and then die. So I had to pull over and then restart it, fired up and drove fine. That was about half way home, and I made it the rest of the way home without any more problems.
So obviously I'm wondering what would be causing the truck to do this? I've done some reading and have a couple ideas, but not really for sure on anything. I was thinking maybe the CPS, I think it can cause a no start issue. Could ICP or the ICP sensor have something to do with it? I was also thinking maybe something fuel related, such as fuel pressure or a bad fuel pump. Any of those sound to be on the right track?
I have the torque pro app, but not exactly sure how to use it yet, and also just got access to my Uncle's Snap-on scanner, so I ran some tests and pulled some codes. How to more utilize these tools in diagnostics. I did get a few codes, but I'm not exactly sure how they might be related. The codes are pulled are:
P0470 Exhaust Pressure Sensor Circuit Fault. Just cleaned that out as well as the tube about a year ago, but I guess could be clogged again or has gone bad.
P1274 Cylinder 4 (E) High to Low Side Open. Did some reading and figured out that this could be UVCH related. At the same time, about a year ago, did new injector O-rings as well as all new Motorcraft UVCH's, so can't imagine that one is bad. Or that one could be loose, I would have guessed it would have happened more when I first did them, not a year later, but who knows.
Also pulled P1876 T-Case 2wd Solenoid Circuit Fault. Not sure if this is related at all, but also not sure what it means either. I read that it could be ESOF system related, which I do have, but I have manual lockout hubs, so maybe that's why it throws the code.
Also a few things that may or may not be related, but I think worth noting. Ever since I've had the truck the check engine light will pop on and off sometimes. It will do it on a cold start or, when I first start driving and its not fully warmed up yet. It does it most when the engine is still cold, and it almost never comes on once the truck is fully warmed up, but has came on and off more frequently lately. When driving, it will only stay on for a few seconds and more often when I'm lugging the engine or at lower rpms, and will commonly shut off if I let off the throttle.
I don't think it really comes on at higher rpms. I also have a slight oil leak in the valley of the engine, seems to maybe be coming from the front of the motor. Nothing too serious, leaves a small puddle where I park, loses enough to be at the add mark, a little before an oil change. Changed the oil about 1500 miles ago and have been able to notice a slight drop in oil level. Also I have changed the fuel filter in the last 500 miles.
Ford F-150 - 1997-2003 :: 2002 4.6L Dies While Driving Randomly
My 02 F150 4.6 4x2 shuts off while driving - usually when I am coasting, but also at varied speeds, even highway speeds. The motor dies, the gauges all go to 0, and the odometer shows ------ I have to shift to N and coast...if I try to re-start it just turns over and over...gauges still all at 0.
I have determined that if I reach behind the fuse panel and wiggle the wiring harness, my gauges will come back and I will be able to re-start it.
I noticed yesterday, that after it did this and I got it re-started, the red 'Theft' light was blinking rapidly. A clue, perhaps?
I have tightened the 10mm bolt that holds the two wire bundles into the back of the cabin fuse box (by driver's door).
Where to start? I have crawled under the dash, looking for loose, chaffed or otherwise odd looking wire, but so far no good.
Ford F-150 - 1997-2003 :: 2002 Truck Starts Jerking Once Get Up To About 50 Mph
Transmission problems 2002 f150 lariat... Once I get up to about 50 mph the truck starts jerking around..
View 2 RepliesGrand Prix :: 2002 Starts Then Dies - Idles At Around 1200 RPM
2002 Pontiac Grand Prix GT. It's got a NA SII 3800 3.8L engine. So far we have put $337 into trying to fix it. What happens is:
Go to start it.
Turn key to On.
Turn key to start.
It either cranks over a bunch of times and never starts or it starts and dies or it starts and is fine. Every time it wont start after cranking a bunch you give it GAS and it revs up real good and starts fine. Idles at around 1200 RPM. This poor car. There has never been anything wrong with it. Replaced the catalic convertor once and the battery once. We took it in and they replaced the Cam sensor and the Crank sensor to try and fix it because they said the fuel pump registered fine.
Accent LC (2000-05) :: 2002 Hyundai Dies Then Starts After 10 Minutes
So I have a 2002 Hyundai Accent 1.5L. My car will drive 1-2 miles then it dies. After I let it sit for about 10 minutes it starts up again. I am getting to the end of what I know to do. I have replaced the ECU, Main relay, most of the sensors, Fuel pump, and fuel filter. When I bring it in to get the codes for it all I get is sensor faults even though I have replaced them. I am going to let it run for a little while and see if I can feel any heat from any relays under the dash. I like this car but not sure what else I can do.
View 4 RepliesHonda - Cr-v :: 1997 Starts Fine Then Dies Only In Warm Weather
Our car starts, then dies. It starts fine, then dies. This only happens in warm weather, which we have finally been experiencing in Northern Illinois. It eventually gets to the point where we can drive it, but then might die at a stop sign, or it can go the rest of the day and not have any difficulties. I know later models have timing chains, not belts. Does our car have a timing belt problem or maybe fuel pump? And why only in warm weather?
View 7 RepliesSanta FE SM (2001-06) :: 2002 V6 Starts With Cranking Cycle Then Dies With Key In On Position
High mileage santa fe 190K+ miles. Will only start while cranking. Dies when key is in "on" position. Fuel pump runs/cycles normally when turned to "on" position. No obvious vacuum leaks. No intake obstructions. Vehicle will cont to run using starting fluid. Vehicle starts, idles and runs (somewhat poorly) with MAF unplugged. Fuses appear ok (although the fuse cover/fuse index is lost). Stranded at rural property with limited tools and average abilities.
View 3 RepliesChevrolet - Suburban :: 1997 Diesel Dies While Driving Then Starts Right Back Up
My diesel suburban dies while driving. It starts right back up. I have changed the fuel filter and checked for water in fuel.
View 2 RepliesDodge - Dakota :: 1997 Starts And Vehicle Will Move Then Engine Dies
'97 dodge dakota engine starts and vehicle will move and then engine dies. Just bought it and it ran fine. Coil was replaced by previous owner four months ago. At times it will run fine but is not reliable and wife will not drive in it. Had it towed to dodge dealer and they said it needed a new coil which they installed and still have the same problem and now think it might be the ecm which is mine even if it does not cure problem. Truck has 145k miles and otherwise is in good shape. When it does run, engine is strong, automatic shifts good and all accessories work. But, it won't keep running.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Truck Starts Then Dies / Cuts Out When Running
I have changed pickup filter in tank and cleaned 2 tube filters in tank i thought that would fix it.
View 3 RepliesFord 7.3L Power Stroke (1999-2003) :: Truck Starts Great And Dies When Hot - Codes P1283 And P1212
Truck starts great, and runs and idles fine until it warms up. This could be 15-20 minutes of driving or idling. Then it just dies. Like dead dies, lose power steering, everything (ac and lights still work, but no engine). It had died while idling, it has dies while cruising at 45mph. Then it will crank but no start. After about a 45min to an hour it will start like there was not issue, and pretty much drive the rest of the day (even after sitting) with no problem.
I installed the Adrenaline a few months ago, but the truck ran great for quite a while before this problem occurred. I did have it shipped with a rebuilt IPR. Tonight, I rebuilt the IPR with Guzzle's kit, and stripped it all the way down. Truck died again.
I have not had my AE hooked up when it died (stupid me today). But afterward I have been getting a few codes: P1283 (IPR Control Circuit) and P1212 (ICP lower than desired Engine crank or run).
When trying to start ICP duty cycle is about 64% and pressure is 185 to 190. If I unplug the ICP sensor pressure jumps to 2000ish, truck turns over faster and ICP Duty cycle goes to about 35%.
Ford F-150 - 1997-2003 :: 2000 Just Dies When Stopping
A year ago, I was driving down the highway ,gas low,and it just died. Half hour later stasrts right up. No problem since then until 2 months ago. It's died 4 times in last 2 months regardless of how much gas in tank. Just stops out of blue when coming to stop signs. Half hour or so will start right back up with no problem.
View 6 RepliesFord F-150 - 1997-2003 :: 1999 4.6L - Battery Dies Overnight
So i have had a problem with my battery lately and i have done all the steps to try to fix it. First we took out the alternator and battery and had them tested at orielys and the alternator tested positive and the battery tested positive so we had them charge it then put them back in. They told us it is probably a parasitic drain which means something is draining the battery so we detached all my aftermarket stuff like my air compressor train horn and led lights on my grille guard and it ran fine for 2 days without dying. Well this morning i went to start it and it was dead again....
View 9 RepliesFord F-150 - 1997-2003 :: 1998 4x4 With 4.2 Motor - Start Then Dies
I can cold start my 98 f150 with the 4.2 and it runs fine. After you drive it for a while and turn it off and try to restart it, it starts then dies, it will do this until you rev up the motor to keep it running. I have to drop in gear and get going down the road and then it smooths out and runs fine. I had a mech check the fuel pressure at the rail and it was 19 psi. The book says it is suppose to be 35psi. He said my fuel pump was bad. I installed a fuel pump and it is still doing the same thing yet. What to check now?
View 14 RepliesFord F-150 - 1997-2003 :: Truck Almost Dies When Touch Accelerator
I bought a 97 F150 4x4 from a guy who had left it to die after the tranny went out. I worked a good portion of the day getting the tranny out, but the truck has another issue. It was manufactured with a 4.6. PO blew her up and put in what he said was a used 5.4 with 88K miles on it. It idles really good and sounds great until you touch the accelerator. It nearly dies then rev's high. I put fluid in the tranny and it wouldn't move in forward but would in reverse. Same thing in gear. Touch the pedal and it nearly dies then revs high!
View 10 RepliesFord F-150 - 1997-2003 :: Rough Start Then Dies - Code P0171
97 F150 4.6 Vin 6, 5-Speed Trans, 200,000mi, Rebuilt recently. I was on my way to get my truck smogged, but she threw a code, P0171. I read somewhere to clean the throttle body elbow, which I did (needed to do it anyway). After I had everything put back together, I start her, and it's rough and immediately dies. If I keep the RPM's at about 1.5k for a minute, then let off, the truck will run fine for about 30-45 seconds, then die again. I just replaced my IAC and the problem persists.
View 8 RepliesFord F-150 - 1997-2003 :: Idle Rough / Nearly Dies / Surges Above 80 Degrees
'1999 F150, 5.4L, 85K miles ....
Fuel pump failed last year, had it replaced. Ran fine for a week or 2, then one day went into limp-home mode. Mech replace fuel pump relay, again ran fine for a month or so. Now when the ambient temp gets above 80F or so (yeah, it has already this year - I'm in Central TX), engine at full op temp, I'm experiencing some sort of heat-soak issue. Engine runs fine when cold, and at normal op temps on the road, but if it is parked for 15 - 20 minutes then restarted, the idle goes all funky - nearly dies, surges, etc. for a minute or 2, and then it seems ok.
I would go back to the same mech, but he had to close his shop due to health issues, so I'd like to see if I can resolve this. So, it is definitely heat-triggered, and "seems" like a fuel issue, but of course it could be some electrical contact having difficulty above a certain temp.
Ford F-150 - 1997-2003 :: Starts But Not Idle?
So, I don't use my F150 too much and an animal made a nest int the intake tract and the nest material (chewed up air filter) got sucked in the throttle body all the way to IAC valve. So I thought I cleaned everything out, even got a new IAC. It starts now but just dies. I didn't remove the throttle body, should I? Where else do you think I could I find this stuff?
View 11 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - Randomly Dies Will Not Restart
Ok, so my 2002 f250 died on me last Tuesday out of the blue, pulled it home and found fuse 23 I think ECU power was blown. I removed my Hydra, and put a new fuse in it and all seemed well, then Friday evening on my way to dinner was driving along and truck shuts off like someone turned the key off. I replace the Crank sensor, even though I had put a new one in after the first time it died, which was last Tuesday, still would not start.
Pulled it home, went out Saturday morning to look at it and hit the key and it fired right off. At this point I don't really know where to look, I wiggled every wire I could find while it was running Saturday and no change, but it does seem to have a miss in it while it is idling...... I am not sure where to start looking....