Ford F-150 - 1997-2003 :: 2001 - Tailgate Cable Pop Off / Bolt Is Gone
My wifes 01 Supercrew had the tailgate cable pop off the other day- it came unscrewed from the tailgate. I went to screw it back in, but there is nothing to screw it into. Whatever was there to accept the bolt is gone. There seems to be an access panel on the tailgate (appx. 48 x 8) that I cant seem to get off- it like its being held in place from inside but I cant see how. I slightly bent up the panel trying to remove it, then lightly tapped it back in place- now I have a ding on the outside finish. So, what was in there to hold the bolt, can I just use a regular nut with a washer if I can get my fingers in there, and whats with the access door ?
View 2 RepliesFord Ranger / B-Series :: Locking Tailgate Handle?
Last week I had to replace my tailgate handle while in the middle of moving. It was nice that it was easy, but it was a major hassle in the middle of a move! In light of having to do this, I was wondering if there are locking handles available, and if so what might you recommend?
View 4 RepliesTouareg :: How To Keep The Tailgate From Auto Locking
I have set the system up in the center info display (by checking the tailgate) to unlock the tailgate (and all doors) with the key remote. Once the tailgate is unlocked and opened you can't close it without it relocking, forcing you to hit the key again or opening the drivers door and activating the remote there. I know this issue seems minor, but its kind of a hassle when you have gear, groceries and a toddler...
View 7 RepliesGolf IV R32 :: Boot / Tailgate Not Opening With Central Locking
I'm having some problems with my tailgate (boot) handle. At the moment the boot 'intermittently' works with the central locking. If it doesn't unlock then I have to use the keyfob to open/close a few times before the handle opens the boot. Fortunately it works every time with the key. I must stress that I've never used the key in the boot. The boot lock is set to work with the opening/closing of the central locking. So this problem is NOT user error.
I have posted some pictures of the problem I've now seen with the mechanism. Ok so in the above picture, you can see that I've put a black arrow pointing at the 'latch' in it's correct position.
When you operate the central locking via the keyfob (or inside the car), it pushes the electrical popper (to the left) which rotates the mechanism CLOCKWISE, and in doing so, it pushes the LATCH across so that it can connect with the boot handle
In the following picture, you can see how the 'LATCH' isn't moving across to the position in the first pic. This is why my boot can't open with the central locking.
I must make clear that the electric popper is doing the job as it should. There is nothing wrong with it's function. The problem is the latch is not rotating (clockwise) into it's correct position. It can be moved by hand easily.
The problem could be solved by attaching a spring to the latch, so it pulls downwards. But I cannot understand why or what has stopped it from working as it should. The latch moves fine if you use the key in the lock, so at the moment, the only way to make it open is either open/close the central locking 10times, or use the car key.......
Ford F-150 - 1997-2003 :: 4x4 Only Locking In When Rolling Not From A Stop
My 4x4 only locks in when i lock it in and then go drive around, and i know its locked in when it gets hard to turn on the road. So i stop and play with it in 4x4 to see if it will go into 4 hi and it does but then after about 5-10 minutes it disengages again. I've checked the top portion of my vacuum lines, replaced my actuator on the front diff and I've made shore that my selonoids are working, and they are. I'm lost.
View 4 RepliesFord F-150 - 1997-2003 :: Front Right Brake Caliper Locking Up
My buddy has been having a strange problem with his 275,000 mile 2003 F150 2wd. The right side caliper will lock up out of the blue and will not release for anything. We put 3 news calipers on it within a 4 week period thinking that we had a defective one but no change. I am thinking either a bad brake line or, more likely, the front abs block...
View 1 RepliesFord F-150 - 1997-2003 :: 2001 - Automatic Locking Hubs
Last weekend I was cutting wood and put my 2001 F150 into four wheel drive for the first time in a long time. I did it "just in case". Anyway, now my fuel mileage really took a nosedive. Is it possible one of the hubs did not unlock? If so, how can I test? Common problem?? 215,000 and going strong!!!
View 8 RepliesFord F-150 - 1997-2003 :: Rear Drum Brakes Locking Up
I'm having a problem with my rear drum brakes locking up when I press the brake pedal. I've had this problem before, but ignored it because it wasn't too bad. It would just release after taking my foot off the brake pedal.
1998 F-150 XLT supercab 4x4 front discs, rear drums 4.6L v8 175k miles
I cleaned my master cylinder and bled all brake lines so they have fresh fluid. Now that my brakes work way better, my rears just lock up. I put new brake cylinders on, still locking up. I went to a junkyard today and replaced the proportional check valve, brakes still locking up.
Could I maybe have did something wrong when cleaning the master cylinder? I'm sure I put it back together correctly. Anything else i should look at? bad lines maybe?
Ford F-150 - 1997-2003 :: Door Locking Mechanism Not Working Right
I just bought a 2001 f150 supercrew. I was told that the locking mechanism didn't work right so I took off the door panel. I can tell when using the power locks that the actuator is weak and probably needs replacing. I also noticed that there is not cable or rod going to the actual door lock, that is to say where you put the key in the door to unlock or lock the door. Need a picture of what this locking system should look like? I assume that for some reason I am missing the rod that goes from the actuator to the door lock. And I can't just look at the passenger side because it is the same way.
View 3 RepliesFord F-150 - 1997-2003 :: 1999 - Front Right Caliper Locking Up Completely
I have a 1999 F150 Supercab, 2wd. I just replaced the front rotors, calipers, and pads. Before I did this, the front right caliper was locking up completely. Now, after the new stuff is installed, the truck pulls very hard to the left when braking. The harder you brake, the harder it pulls left. What should I look at next?
View 2 RepliesFord F-150 - 1997-2003 :: 2001 - Poor MPG - Automatic Hubs Won't Locking?
last weekend I was cutting wood and put my 2001 F150 into four wheel drive for the first time in a long time. I did it "just in case". Anyway, now my fuel mileage really took a nosedive. Is it possible one of the hubs did not unlock? If so, how can I test? Common problem?? 215,000 and going strong
View 9 RepliesFord F-150 - 1997-2003 :: Door Locks Will Unlock But Not Locking Again And 4x4 Will Not Work
I have a 2003 ford f150 supercrew. The problems that I am having is first, my door locks will unlock just fine on the key fob and on the door switch inside the cab but they will not lock at all. I've checked the fuses and everything and cant find the problem. it did this one other time then one day there was a pop from in the dash and they started working.
The second issue that I am having is my 4x4 doesn't work all the time. i turn the switch on the dash and the 4x4 light comes on and i can hear a click but then i have nothing so I took it to my mechanic and he said it was probably the shift fork but he wouldn't know til he took it apart. so i decided to hold off then the 4x4 worked fine for a couple weeks if it was my shift fork would my 4x4 still work sometimes? could these problems be related?
Ford F-150 - 1997-2003 :: Door Locks Not Auto-locking When Driving Off
2003 supercrew. Could this be because of a switch, fuse, etc?
View 3 RepliesFord F-150 - 1997-2003 :: Starter Won't Click - Power Door Locking / Unlocking When Trying To Start
My mom has a 2001 f150 with a 5.0. Had never had any problems with it till this week. She says it wont click or anything. When she tries to start it, the power door locks go to locking & unlocking. She said the battery is good. I figured probably the starter. She lives about 2 1/2 hours from me. I figured I would go down there and take the starter off and have it checked or rebuilt. Anybody ever had their power locks to go to moving when you try to start the truck. Also, when she turns the key on, her dash lights come on just like normal. Just won't turn over or click or anything.
View 3 RepliesFord F-150 - 1997-2003 :: 2001 - 4x4 Not Locking / Front Axle Is Not Pulling In When Switch The Selector On Dash
I have a 2001 f150 4x4 with the 4.6 Triton motor, the front axle is not pulling in when I switch the selector on the dash, I know the transfer case is switching so that part is ok. I know there are 2 solenoids on the fire wall, my question is which one is which ? every store I call says one has the nub at 9 o' clock and one at 6 o' clock which one of these does the front axle, don't want to order the wrong one ? I checked the vacuum and the blue line going to the axle always has vacuum and as I read the diagram the blue line is 2 wd and the red line is 4 wd so is the 2wd solenoid stuck and preventing the 4wd one from pulling in or is the 4wd one bad ?
View 4 RepliesCaravan/Voyager :: 1998 Dodge - Putting A New Tailgate On Car
I'm about to put a new tailgate on a 98 Dodge Caravan. I got hit in the back and I bought a new back door at the junk yard. It looks pretty easy, but I thought I would touch base here and there are a couple of potentially tricky parts...
Does that wire bundle have a block somewhere that you can plug, or am I going to be splicing them one by one? (I don't have power locks. I have windshield wiper, back door inside light, license plate light, heat wires in the glass.) The other tricky part..changing the lock.
I think that's all.. the bolts and star screws look pretty straightforward. I got it used with 48k miles a couple years ago and I only have 75k now. It was a government car.
Ford F-150 - 1997-2003 :: 1998 - 4WD Won't Engaging?
I am having a problem with my 1998 F150 4x4. The 4WD is not engaging. It is a manual shift. I have checked the transfer case by turning the drive shaft in 2WD it is free. When I shift into 4WD it is does not spin freely. So I believe that is OK. I have checked the vaccum diaphram. It will move the piston when I attach a hose and pull vacuum on the inboard hose barb. So I believe the diaphram it self is OK. I am not sure if the hoses and selenoids are OK. They look fine. However there is a constant vacuum on the inboard hose line (red/pink color) wether I am in 4WD or not. Is this OK? How can I check the selenoids. If all this is OK, the next thing I believ it could be is the shift fork in the differential. Is that a difficult job? Do you need to pull the whole axle out to replace it?
View 14 RepliesFord F-150 - 1997-2003 :: 1998 - 4.6L Won't Rev Anymore?
Just bough a '98 F150, 4.6L; drove it home and it ran great, lots of impressive power etc... Parked it my shop and getting it ready for safety check so I can register it. All I did was change the oil, oil filter and air filter.
Couple weeks have gone by, I went to start it and it does start & idles beautiful but it will not rev. I give it gas and it's like it's choking / wants to die. The signal lights are flashing super fast which I don't recall doing before. Battery wasn't holding charge so I installed a new one tonight; no difference. Alternator is good.
I have not checked the plugs yet because I don't think that would be the cause of an overnight change from running excellent to what it is now but I will check them.
Ford F-150 - 1997-2003 :: 1998 - 4wd Won't Engage?
I have a 98 f150 4wd with manual shift on floor (msof) and the 4wd will not engage. I've done research and I've learned quite a bit but still have an issue. In All the research I've done I have learned about
View 3 Replies