Ford Ranger / B-Series :: OBD-II Code 0401 Then 0402 - EGR Flow Insufficient / Excessive
I got an 0401 EGR Flow Insufficient last week. I cleared it and it showed up again after a couple of days. I replaced the EGR Valve and the 0401 reappeared. I replaced the DPFE and the code did not reappear. Great!
About a week later, I got an 0402 EGR Flow Excessive. New EGR Valve. New DPFE. The hoses to and from the DPFE to the tube look decent. They don't appear to have any build up inside. Code 0401 or 0402 to the tube?
My first instinct is to replace the EGR valve again, assuming the one AutoZone gave me is stuck open. Is there any servicing I can do to it first? Like maybe soak it in carburetor cleaner? Or spray it with WD-40?
Ford Fuel System :: Rough Idle In Park And Check Engine Light On - Code Read P0422
I recently purchased an 06 f150 fx4 5.4L with 60K miles. Just recently my check engine light came on and I've noticed a slight rough idle in park. I took it to autozone and the code read P0422 evap emission leak. Bought a new fuel cap but didn't work... EGR valve?
View 2 RepliesTrailBlazer :: 2008 - Secondary AIR System Switching Valve A Stuck Open (P2440 Code)
I have a P2440 code from warning light- Secondary AIR System Switching Valve A' Stuck Open. This started to appear when I took it into the dealer for other issue with transfer case whining when in 4x4. Can this code be associated with something the mechanic did , would they remove any sensors or wires, that may not have put back. Not happy. Are these trucks know for this code? Estimate cost?
View 4 RepliesFord - Explorer :: Check Engine Code P0420 - Catalyst System Efficiency Below Threshold
Book says "catalyst system efficiency below threshold (Bank 1)".. Is it just based on mileage or an actual bad O2 sensor or other bad system component?
View 14 RepliesFord - Explorer :: 1999 - Code P1451 EVAP System Canister Vent Solenoid Circuit Malfunction
I have a 1999 Ford Explorer with the V-6 SOHC that is stuttering and stalling when I try to accelerate. A very slight acceleration will get the vehicle moving, but anything coming close to normal gas pedal pressure causes immediate stuttering and/or stalling. Check Engine light came on when problem started yesterday.
Where is the EVAP System Canister Vent Solenoid? I bought a code reader after beating my head against the truck all afternoon and got code "P1451 EVAP System Canister Vent Solenoid Circuit Malfunction". My Haynes book says on the left side frame rail... can't find anything along there that looks like it (based on picture from Rock Auto for replacement part) and found some people online talking about it being in the engine compartment on the passenger side...
Just crawled all over the truck and I think I found the charcoal canister, but couldn't trace it back to the vent solenoid... There was something right next to the canister, but again, it looked nothing like the replacement part listed on Rock Auto...
Ford Fuel System :: How To Read Measurement On The White L Ruler
I am doing a model 2150 carburetor rebuild on a '78 Ford LTD with a 400. I need to understand how to read the measurement on the white "L" ruler.
Specs says 31/64" on dry float. Where is 31/64" on the short arm?
Ford 6.0L Power Stroke Diesel :: 2006 - Code P0405 - Oily Residual In The Port For EGR Valve
I have this problem code P0405. At fist it come up with a turbo under boost. I have replaced the Turbo and egr valve and I still have the P0405. I did notice a oily residual in the port for the egr valve I see no deference in coolant. She idles good I just have no power when I put it in gear to move.
View 3 RepliesFord Audio/Video System :: 2007 F150 - Nav Not Working - Cannot Read The DVD
The navigation in my 2007 F-150 is acting up, saying it cannot read the DVD, and that it might be dirty, remove and clean, etc. etc.
Also, and perhaps an equally concerning problem is that it won't spit the DVD out. It will get so I can barely see the disc through the mouth of the system, but not enough to grab it. I'm going to try and grab the disc as delicately as I can with a small set of grooveless needle nose pliers, but haven't had a chance to try that yet.
It was doing this a while ago, but seemed to fix itself and hasn't acted up for I'd say 2 months now.
For those that have had this happen before, is it as simple as cleaning the disc, or is this a sign of a larger (possible system failure) problem?? Also I should mention that I still have the original map DVD in the truck, and I think I've taken it out once in the year and a half I've had the truck, and that was just in learning how it came out.
Ford - Explorer :: 2006 - How To Locate 5 Digit Code SJB
How to locate the 5 digit code on the SJB on a 06 Explorer EB edition. 1st get a flashlight and a mechanics mirror. Then locate the SBJ above the parking/emergency brake. on the bottom of the SJB there is a cover. If you can remove the cover then do it. It is Stamped on the other side. Or put the seat back and flip upside down on the floor and look with your mirror and flashlight, it is the only 5 digit number STAMPED on it.
View 4 RepliesFord - Explorer :: 2006 XLT V6 - Code For Keyless Entry?
My brother just bought a 2006 Ford Explorer XLT 4x2 4.0 V6. Where to find the code for the keyless entry? I took a look under the dash "driver side" but didn't see anything....
View 4 RepliesSonata NF (2006-10) :: Got Engine Code P0022 - Oil Control Valve (Bank 2)
Got Engine Code P0022. Listed several things, Cam Position Indicator (replaced it) and CVVT Oil Control Valve Bank 2. Dealer calls them "front" and "rear". Is Bank 2 the rear (Black or gray also).
View 1 RepliesFord F-150 (2004-2008) :: Code P0308 Read Out Misfire On Cylinder 8
Started as I was warming up the truck,a slight vibration/shudder. First thing that came to mind was F150. Torqued words of wisdom that it might come back, I had a p0301 before. Had no CEL, so decided to drive it to see if it got worse. Turned onto the main road and on came the CEL. Pulled into my FORD dealer, told him about my problem. Code P0308 misfire on #8cylinder was the read out, COP was done and the plug. 40 min of labor. She's even quieter than when #1 got changed.
View 3 RepliesHonda - Accord :: 2009 - Audio System Does Not Read MP3 CDs
I have a Honda Accord 2009 sedan. The CD player reads audio CDs well; however, it does not read MP3 CDs that I burned using iTunes. I have tried multiple CDs but had no success. What should I do? Should I take it to dealer? I am just worried that they are gonna charge me for diagnosis.
View 9 RepliesFord F-150 (2009-2014) :: 2010 - CEL Going On And Off / Code Read Says Bank One Catalytic Converter
2010 f150 with 5.4 catalytic converter. Engine light has been going on and off for the past couple of months. Had the code read and its says bank one catalytic converter. Ford dealer said to replace the 02 sensors. Had that done but light still comes on and off with same code. Could there be something wrong with the sensor or should I just have the CC replaced also. I just don't understand why it would come on for a few days and then not come on for a few days if its the CC?
View 1 RepliesFord Super Duty (1999-2016) :: V10 - Scanner Won't Power Up And Read The Code
My 1999 super duty v10 has thrown a code but my scanner and a mechanics scanner won't power up and read the code, I also noticed that the cigarette lighter is dead. Which fuse controls both the plug and the lighter?
View 3 RepliesCamry 2012+ :: Text Message Read Out Over Car Speaker System?
My wife have a 14 Corolla LE Plus, no NAV and every time I get a text message it pop up on the screen and I can play the read out message over the car speaker system.
On my Camry it does not do this. I have NAV with the 7" screen. I try matching the setting of my Camry to the Corolla and it seen to be the same but still it does not ready out the message or even pop up when I get a text message.
My IPhone 5 is paired with the car that I know that for sure, all my phone book contacts and phone work just fine even play music from my phone. I can't find anything in the manual.
Prius (2010-12) :: Hybrid System Shut Down - No Codes Read Out
Bought a used Prius 2010 last december, Now the hybrid system is shut down and the assumption is that the hybrid battery is the culprit. No codes has been read out of the system but the car has passed 330 000 km so I guess that's very plausible. Have found a used battery from a 2009 prius who the local Toyota service facility says is compatible.
View 19 RepliesFord Fuel System :: Location Of Check Valve That Maintains Fuel Pressure On The System?
I have a '99 E-350 6.8L. Where is the check valve that maintains fuel pressure on the system?
I have been experiencing a starting issue when the engine is hot. Cold starts are usually fine. I've replaced the in-tank fuel pump (pump only, not the assembly) to no avail. I was out of town and didn't have access to a fuel pressure gauge when the problem started so I couldn't say what I had prior to replacing the pump. But now, with a new pump, when I check pressure, I get about 40 psi when I first cycle the key on, but it drops right back to zero as soon as the pump shuts off. If I cycle the key on a few times, sometimes I can get it to hold pressure at about 32 psi, and it starts fine. When I shut if off, it goes back to zero psi, sometimes gradually, like a bleed down, and sometimes immediately.
My conclusion from this was that the check valve was bad. I was told it was part of the in tank fuel pump assembly. Since I didn't replace the entire assembly, this made sense. So I just dropped the tank back down, but I don't see anything as part of the pump assembly that serves as a check valve. There is a rubber nipple on the end of the return line, but I don't see how that can hold any significant pressure.
So, before I go out and spend another couple hundred bucks on the complete fuel pump assembly, which apparently can't be purchased without the actual pump, I thought I'd ask. Where is the check valve that holds the pressure in the fuel system?
BTW, I also have replaced the fuel rail pressure regulator, but it made no difference (I went there first since that was much easier than dropping the fuel tank a second time).
Ford Super Duty (1999-2016) :: CEL Sporadic Only When Cold - Code Read P0355?
Here is my situation. A month or so ago when it got cold out consistently I got a rough idle after start up.. CEL. Code read P0355, cylinder 5 misfire. Removed plug to check it. All was good, I put everything back together (anti seize, dielectric greased) So I replaced coil. It went away. This week got very cold and Code P0355 and flashing CEL. Drove for a mile or so and it went away. So I'm thinking vacuum leak, Intake gasket, egr valve or warped intake manifold?
View 11 Replies