Ford - Explorer :: 2002 - Transmission Fluid Leak
How I could take my ford explorer 2002 in to the shop to replace the radiator and come out with transmission fluid leaking. The mechanic said it is some kind of hose but it wasn't leaking before and after I drive I can see it dripping out. I'm just not sure if they messed up something. Unfortunately my husband is overseas and cannot check it.
View 3 RepliesFord - Explorer :: 1996 - Rear Differential Was Leaky / Loud Whine Noise In Rear
Well i picked up a 96 4x4 with the 4.0 a few weeks ago and been fixing stuff weekly that i find wrong. One thing i noticed was the rear diff was leaky but couldn't get the fill plug out so left if for now. Last night my wife was on interstate and it just started making a loud noise so she pulls over calls me. I get there and drive it and it makes a woowoowoo noise and it got louder as speed increased. She was 3 miles from the exit so i drove it about 15-20 to get it off interstate than another 2 miles to her sisters. We let it sit for a few hours and found a flatbed to haul it home, and when we finally got home i drove it off the flat bed and now it was making a loud clunky noise. Parked it in drive till today. Cracked open the rear and no fluid came out.
Inspecting all the gears looked good no metal in bottom so i went and got a new rear cover and 3 qt. of fluid. Put it back together and the woowoowoo was still there but seemed to slowly go away as i drove it around the block. So what else could be going on here or do i need to drive it and warm up the fluid so it circulates? I also noticed a sheeee sound like metal on metal when braking but i changed all 4 rotors and both pads last week but i noticed the brakes in the rear that look like drum brakes was bare but i assume that is only for the ebrake so didn't bother changing them yet. Could those be hitting the inside of the rotor and making the metal to metal noise?
Ford - Explorer :: 2002 XLT - Front Differential Diagram?
I am looking for 2002 explorer XLT front differential diagram.
View 1 RepliesFord - Explorer :: 2004 - Rear Differential To Change Brakes?
It may sound silly, but can I lift my 04 explorer by the rear differential to change brakes etc? I have NOT had a Independant suspension vehicle prior to this and dont want to mess up anything. If I cannot use that point to lift it, where is a point to lift it using a floor jack so I can service the rear of the vehicle after I place it on jack stands?
View 7 RepliesFord Excursion :: Faint Odor Of Differential Fluid From Driver Side Front And Rear Wheels
I've only had the Ex for a few months so I'm still learning... After a trip to Orlando this weekend, I noticed a very faint odor of differential fluid from the driver's side front and rear wheels.
Nothing on the passenger's side. I've inspected the pinions and axles and found no wet areas at all, so I'm a little perplexed. The wheels and axle housings were pretty cool considering a 5 hour round trip.
I was also wondering if what I am smelling is due to the axle vent hoses?
Ford Super Duty (1999-2016) :: 2001 F250 - Rear End Differential Fluid Change
I have a quick question. I am gonna change the fluid in my 01 f250 rear end. it has 410 gears and a limited slip diff. if i use full synthetic gear oil do i have to add the limited slip additive or just the 75w-140 full synthetic gear oil.
View 14 RepliesLexus GS 2006-11 :: Rear End Differential Fluid Change
Is there a gasket to replace?
View 1 RepliesFord F-150 (2009-2014) :: Rear Differential Leak From Pinion Seal
New issue this week - truck developed a leak from the pinion seal. I'm not sure how much has leaked out, so I would like to top it off before limping to the dealership.
From the manual: "Motorcraft SAE 75W-140 Rear Synthetic Axle Lubricant" There is also a footnote for friction modifier required for a Trans-Loc rear diff. Assuming that footnote refers to an LSD and NOT the E-Locker, should be able to top off with just the fluid, correct?
I am a die hard for Truck fan but am really disappointed with the overall quality of the truck. I bought it new and now with 30k, I've had it in twice to have rotors turned, once for transmission getting stuck in 5th and needed a new molded leadframe assembly, and now the pinion leak. All fixed under warranty, however really unacceptable for a truck with this low of miles and an easy life.
Ford F-150 (2004-2008) :: Rear Differential Leak - Torque Rating On Bolt?
I am getting a little frustrated with a leak on my rear differential. The leak is on the front of differential rear-end just behind the four bolts you take off to remove the driveshaft. When you take the driveshaft out, there is a single bolt and the seal behind that is leaking. Here is my dilemma, I called my local ford dealership to find out what the torque rating on that bolt is so when I replace the seal I don't over-tighten. He told me there is no torque rating on it because I have to tighten, measure, tighten, measure the bolt. I was lost, I didn't have a clue what he was talking about.
View 6 RepliesFord - Explorer :: Leak Fluid Out Of The Thermostat Housing
My explorer with 4.0 sohc is starting to leak fluid out of the thermostat housing. How hard is this to do and what can I expect in cost to do it myself. I dont drive this explorer but about 2 miles each way to work as I live on a military post. I have been putting it off ( just keep adding coolant and water) every couple of days. I have noticed that the engine temp doesnt not get up to half way like it use too. Maybe 1/4 of the way on the gauge now. I have always flushed coolant system very two years. It is starting to get some rush in the overflow bottle now too. Other then that she runs good and no other engine issues. She does have a 136k on her.
View 7 RepliesHonda - Pilot :: 2011 - Code B1236 / Change Fluid In Rear Differential
I have a Honda PIlot 2011 which I took to my local Shell service shop . The code the car showed was B1236. One of the many things they did was to change the differential fluid. After I picked up the car from the shop, I noticed a slight sound from the rear wheels when I would make a right turn. I took it back to the shop and had them look at it. We did a few sharp right and left turns and we heard nothing. I drove the car away and a few days later noticed the sound to be more noticeable. At this time, I took it to my Honda Dealer. They noticed that the fluid in the rear differential did not seem to be right one and the sound was because of that . Can a wrong fluid damage the rear differential? They are also recommending that we change the rear differential which off course is extremely pricy.
View 7 RepliesPassat (B6) :: Small Leak In Rear Differential?
My 2007 3.6L 4Motion wagon was in for the 40k service. Everything was fine with the service, but they noticed that there was a small leak in the rear differential.
It's covered under warranty, but the troubling thing is that they can't figure out how to stop the leak. They are calling VW tech.
Subaru - Outback :: 1996 - No AWD Suddenly / Leak In Rear Differential
I have a 96 outback which all of a sudden has no awd. The rear differential looks as though it has leaked some. I don't know if it has a bad axle, or if this loss of fluid is the culprit..... Where to start?
View 4 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - Cleaning Rear Differential?
...when changing the fluid and RTV'ing the rear differential cover?
Usual suspects: Brake cleaner, Simple Green, soap and water, gasoline, etc.
I've never serviced one, but figure it is like this:
1. Drain
2. Remove cover
3. Spray, clean, rinse, whatever all the innards
4. Wipe and dry
5. Inspect. For what, I have no idea
6. Black RTV cover back on, replace drain plug, remove fill plug
7. Refill with 75w-140w Mobil 1 Synthetic (not sure what it is, but I looked it up here some time ago and bought enough)
8. Fill to within a finger tip's dip in the fill hole
I've had the RTV and oil for a while, but it's supposed to hit 59F here on Saturday with no rain!!! Time to crawl on the floor and get it done.
I didn't see any problems with my cover, so going to forgo the new aluminum finned cover this time
Guess the biggest question is what should I use to clean/flush the rear end?
This is 2002 Excursion WITH LSD rear differential. 4WD.
Ford 7.3L Power Stroke (1999-2003) :: 2002 F350 - Leaking Rear Differential
I'm trying to figure out what axle I have on a 2002 f350 single wheel 4x4 so I can order a replacement seal. So this morning I got to work and noticed that am oily guild was dripping from the front of my rear differential where the drive shaft hooks into it. I figure it the seal, so when I went to look up the repair kit they list several different axle options because of gearing, what axle I have as there wasn't a in owners manual with the truck. Who can I find out what axle I have so I can buy the repair kit for it...
View 5 RepliesLexus RX 2010-15 :: RX350 AWD - Rear Differential Seal Leak (Passenger Side)
Our 2010 AWD RX350 developed a rear differential oil leak (passenger side) at the drive shaft lip seal. Has 80,000.
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - Vibrates When Throttle - Rear Differential Rebuild
My truck (02 7.3L cc) started making a grilled ding type of vibration when I would let if the throttle. I felt the axle going into the rear differential was a bit loose, so I took the cover plate off. The pictures below show where the pinion I think is hitting, sort of like the bearing is allowing front to Rear differential scaring from movement. Rear movement.
How difficult is a rebuild, and is there anything I should be careful of?
Ford - Explorer :: 2002 - Transmission Goes Into Almost Neutral State When Go Up A Hill - Leaking Fluid
I had an 02 Explorer for years now and absolutely love it. It has almost 170,000 miles on it and is definitely showing its age. There's alot of rust underneath and ive been replacing things as they break. For about a year now I've been dealing with the transmission leaking fluid. This vehicle doesn't have a transmission dipstick and has to be filled from underneath. When I have the transmission full of fluid it works perfectly until recently. Now, when I go up a hill the transmission goes into an almost neutral state.
The R.P.M's will go up past 4000 and I'll have to stop. It doesn't misfire or bog down, just acts as if the tranny is in neutral. Sometimes I just sit there for a minute and its fine, other times I haven't been as lucky. In one instance I had to sit there for about 20 minutes, in another I disconnected the battery to reset everything, and on another instance it would stall out the moment I put it in gear. I know it's a little low on fluid and will be getting it filled again soon. I plan on possibly getting a new transmission this winter, but gotta keep it going till then.
Ford F-150 (2004-2008) :: Fluid Leak On The Ground In The Rear Of Truck
I have an 04 F150 5.4. Anyway drove truck about 200 miles this weekend. When I got back home, unloaded truck, noticed a fluid leak on the ground in the rear of truck. Upon further inspection, appears to be leaking from where the driveshaft meets the rear axle...looks like there's a gasket or yoke in the rear of the U joint? a little fluid dripped down and ran down to the lower portion of the "pumpkin" and made a quarter size oil patch in front of my house.
I would have definitely noticed such a stain before, since I park in the same spot at home and work every day. I drove to work today (14 miles) and looked under the truck for 15 minutes after I parked, don't see any drip, but do see remnants of a leak all over the front part of the rear axle. No way has any fluid leaked on the ground before, I 100% would have noticed a stain.
Thoughts on a fix for this? I had the clutch packs redone about 3 years ago under warranty, truck has 88k miles. No shudder when I drive from the rear axle, I'm assuming there is fluid in the rear gears, as a substantial leak I for sure would have seen on the ground. leak is 100% NOT coming from the seal on the rear axle, but in front of it where the shaft meets the axle. Possible that driving on the highway at 75MPH for 2 hours straight caused this leak, as my drive to work is mostly stop and go, both ways.