Ford F-150 - 1997-2003 :: 2001 - Won't Start / Only Get Solenoid On The Firewall Click Each Time Turn The Key
Ok so I was looking at my blend door actuator motor to see if it was working. Just took off the bottom vent cover, turned key on and moved the air mixture to see if the motor worked. (it didn't) Then I went to start the truck and all I get is the solenoid on the firewall click each time I turn the key. I put a meter on the opposite side of solenoid and I see 12v across the solenoid. I can't image i did anything while playing around by the blend door actuator motor. I guess I'm looking for confirmation that the next logical step is starter and starter solenoid. Is there anything else I could be missing? is there anything else in that circuit between the solenoid on the firewall and the starter? I also cleaned the battery terminals and the terminals down on the starter solenoid. I also tapped the starter a bunch and put a charger on battery and tried jumping the truck too. Everything else works.
View 10 RepliesFord - Explorer :: 1996 - Won't Start - Loud Click When Key Turned?
I have a 1996 4.0L Sport - 2 weeks ago, stranded wifey at food store, had it towed home, and replaced the starter solenoid - it started and ran for about 4 days, and then stalled once but started back up (it was cold out)
Another day, I went out to start it, and the same thing... loud click when you turn the key to start position, seems to be coming from solenoid again...
so, I thought, ok, the parts a week old, but sometimes they do fail...
So, I bought the best one around: standard "blue" which had brass on the back to best couple to ground, etc...
Put it in, and reconnected everything - and the SAME THING... clicks every time I turn the key. (single click for each time I try to start it....
questions is - how can I check these to see if I had 2 bad ones in a row, or would there be something else wrong?
Ford F-150 - 1997-2003 :: 4wd Not Engaging / 2wd Solenoid Always Activated
Found out the hard way that the 4wd does not work on this new stupid truck. I've been troubleshooting the solenoids and confirmed that the 2wd solenoid gets grounded and will read ~12V when switched to 4wd; however, the 2wd solenoid always remains grounded and will always read 12V across the plug no matter if it's in 2wd,4hi,4lo. What would cause this? It seems that I would have vacuum going to the front differential from both the 2wd and 4wd solenoids at the same time, thus not allowing it to go into 4wd. BTW, this is on a '98, 4.6, turn dial 4wd
View 14 RepliesFord F-150 - 1997-2003 :: 4WD Not Working / No Click On Vacuum Solenoid
1997 f150 electronic 4wd not working, lights on dash not working(they light up on start up) replaced transfer case motor still not working, checked all fuses, Do not feel or hear clicks on vacuum solenoid, Top vacuum lines on both have vacuum. Where do I go from here? What do I check next....
View 9 RepliesFord Ranger / B-Series :: 2003 XLT - Compressor Making A Loud Click Noise Engaging Even Though Not Using Heat Or AC
I have a 2003 ford ranger xlt 4.0L and here recently my ac compressor has been making a loud click noise engaging even though i am not using heat or AC, so when it engages the rpms drop and almost wants to stall and it does this in about 10-15 sec. intervals, but when I am driving it acts fine. What is going on here, I recently had a vacuum leak and i found it and fixed it, and now this issue just started.
View 2 RepliesLexus GX 2004-09 :: GX470 Won't Start - No Solenoid Click / No Starter Noise
Our 2004 GX has been a great car, but is suddenly doing a number of strange things - like not start. When I say it won't start, I mean you can turn the key, the dash lights up, the steering wheel adjusts, radio goes on, etc, but then NOTHING! No solenoid "click", no starter noise, NOTHING! Does not crank at all. The car just turned 60,000 miles, is in great shape, lives in the garage and has never been in an accident.
After the first couple of times it did this, had the battery replaced, as it was getting close. and then the car started again. Until the next day. No rhyme or reason as to when it would do this. It might start 10 times in a row, then NOT start for a while, then magically fire up instantly, even after several key turns. I wiggled the key, tried a different key, shifted to Neutral, wiggled the shifter to try to rule out security interlock, bad ignition switch and shift interlock. No dice.
Did some more research and thought it might be the starter relay - banged on it and it started, so replaced that part. Didn't solve the problem. It also began to randomly die while idling (in park, or in drive). Sometimes it would re-start, sometimes not. The times it has done this, it typically dies after running or 15-20 minutes, but NOT ALWAYS.... Sometimes it will die once, then be good for the rest of the day. Sometimes it re-starts immediately, after a few minutes, or more recently only after sitting for a few hours.. So basically we can't use the car.
Ford - Explorer :: 1997 - 4x4 Lights On Dash Flashing 5 - 6 Times / 4WD Engaging
I have 1997 ford explorer my 4x4 lights on dash flashing 5-6 times and four wheel drive kicks in and binds when I turn wheel left or right and engages while going straight . Happens on occasion put its happen more often. How to disconnect the 4-wheel drive from engaging.
View 1 RepliesDodge - Caliber :: 2007 - Click Happens Most Of The Time When Start Engaging The Clutch
I've got a Dodge Caliber '07 that has a weird Click that happens most of the time when I start engaging the clutch, it doesn't happen when starting out in first gear, but when shifting to 2nd, 3rd and now as it's aging sometimes 4th and very infrequently 5th. It happens when I pass the friction point on the clutch and can feel it in the pedal - as a note - I've found that if I gingerly/slowly release the pedal through the friction point it won't do it most of the time.
It is fairly loud at lower gears, as I can sometimes hear it with the window open bouncing off buildings or things. I'm just wondering what this is?
I have asked at the dealership several times already about this - but the mechanic always reported nothing found and that it's normal for a transmission with that many km (I'm in Canada). I bought the car with 50,000 km and it has done it the whole time - I've now got 128,000 km.
My first thought was something with a bearing or something - as it almost sounds like the gear isn't quite in place and when the torque starts being transferred it clicks into place... I'm not sure - which is why I'm here!
Ford - Explorer :: 1997 Won't Even Turn Over / Just Getting Click From Starter
Have a 97 Ford explorer. Over 270,000 miles on it. Recently had Crank sensor, Crank case vent tube, plugs wires replaced along with intake manifold gaskets. Also had fuel injectors cleaned out. Now i cant get it to turn over. Went to store, truck started fine, came out and click. Thought it might be the battery even though its also brand new but no, had the starter checked, it is also good. Put test light on all electrical having to do with starter and found all hot wires and good grounds. Finally bypassed the solenoid for starter and still nothing but a click. I also checked NSS to see if that might be it but after putting it in reverse, the reverse lights came on, and even jiggled shifter in park and neutral to see if that might work but still just a click. Not sure where to go from here short of buying all new parts but doesn't make much sense to do that if they all appear to be working properly. Don't have a volt meter to check voltage.
View 5 RepliesFord F-150 - 1997-2003 :: Loud Click From Under The Dash
I have a 97 F-150 v6 with 62K miles on it. I went out the other day to start it and all I got was a loud click from under the dash. I figured it was the battery. Late for work already, I just drove the wife's car. This morning I tried to jump it, nothing, just the same loud click. Headlights are good and bright. I'm no truck mechanic so I was maybe thinking solenoid or starter.
View 5 RepliesFord - Explorer :: 2002 V6 Won't Start / Fuel Pump Not Engaging
My parent's bought a 2002 Explorer 4.0 V6 very early, either late '01 or early '02 when it first came out. Besides the dash blackout (which I found a fix for, need to do) it's been plauged latley (since Nov/Dec 2010) with the intermittent issue of when... You turn the key on to start, you dont hear the fuel pump enguage, thus no start. Get towed, it works like a champ.
It's blown a fuse 1 or 2 times cause of this, had the fuel pump recently replaced (dec/jan this year) and just did it again. Our local Ford dealership figured the fuel pump went bad from sitting, the vehicle only has about 33k miles on it (dad dont drive much). What appears to be a bad fuel pump, only to have it get towed, or sit overnight and start like nothing ever happened?
Dad's ranting about not trusting the vehicle anymore, he's 80yrs old so I can't blame him for wanting to feel comfortable with knowing his vehicle should start, but it is a machine, they do break but we cant seem to get this fixed.
Ford F-150 - 1997-2003 :: 1999 Lariat Not Starting / Loud Click When Turn The Key
I have a 1999 F150 Lariat 5.4 that's been sitting for a few weeks waiting for a new MAF. Finally got a MAF from a junkyard (out of an 01 Expedition) and installed it.
Turned the key, cranks once, then I hear a loud click and then just continuous clicking. I did some research and people are saying this is just the starter solenoid and that the battery may be dead. I charged the battery a couple hours and waited until it showed 11.some volts, tried to start it again, didn't even turn over, just clicking. I also noticed the theft light blinking rapidly, but if it were the PATS acting up, wouldn't the motor at least turnover?
So I went back to charging the battery. Went out a couple hours later (at night), and when I opened the door, none of the lights came on. Then I hear a click, the lights come on, followed by another click, and the lights went off. This happens each time I open and close the door. So did I potentially pop a fuse? Or is my battery just fried? Would replacing the MAF with the newer one out of the expedition cause any weird issue? I doubt it, but anything is possible at this point I guess.
Ford - Explorer :: 1999 - Engine Will Click For A While Then Start When Cold
I have a 1999 Explorer with a 4.0 engine and when it gets cold it has trouble starting. It will click for a while and then start, but when it is warm I have no problem starting it.
View 3 RepliesFord F-150 - 1997-2003 :: Low Presser AC Switch Died / Start Solenoid Just Clicks Sometimes
On my 97, just had a new engine installed. Suddenly the Lo presser AC switch died. Now the Start Solenoid (I think) just clicks sometimes. Is this Solenoid on the Firewall the Start Solenoid?
View 6 RepliesFord Wiring/Electrical :: 1994 Explorer XLT - Occasional Click When Trying To Start
I have a 1994 Ford Explorer XLT. It just died the other night. I have dim dome light, nothing else. I had the battery and alternator tested, both are ok. I get an occasional click when trying to start it. I also get an occasional beeping, the key in the ignition sound. I've checked the fuses, and can't find a broken one.
View 3 RepliesFord Excursion :: 2001 - No Start / Loud Click But Starter Doesn't Turn Over
2001 6.8 Ex wouldn't start again today Get a loud click but starter doesn't turn over. Yesterday jumped it, took it to Advance where they checked battery and alternator; both checked out great. To start it this morning I ran my negative jumper from battery to engine block and it fired up It's about 12 degrees out and was same yesterday. Thinking dirty/bad ground somewhere ? Do I just start following the negative cable everywhere it goes or am I missing something here No garage and it is chilly.
View 3 RepliesFord 6.0L Power Stroke Diesel :: Intermittent Crank Now / Key Will Just Click The Solenoid
I just reinstalled the engine and got her running. I installed a new 6.4 starter (reman) and she spins perfect. I was experiencing this same issue prior to startup and thought it was weak batteries. The key will just click the solenoid and it turn the engine over.
Quick synopsis of what I've checked:
All grounds
All cables tight
Batteries are fully charged
Power at right fender pigtail leading to solenoid when key is engaged (tomorrow I'll ck voltage at work today)
Checked starter connections
Checked continuity on the 10g wire from the fender to the starter...all good even wiggled it hoping it might have broken internally...
To me it sounds like a bad connection but I did not mess with the harness (firewall) aside from bungeeing out of the way vertically. I can hook up a charger and she will crank with the key. I can disconnect the fender 10g and crank it from the battery with no issues.
I've quadruple checked for loose connections. Didn't have this issue before so not sure what happened. Relay sticking maybe?
Santa Fe (CM - 2007-12) :: Starter Or Solenoid Not Engaging
2012 Santa Fe all of a sudden won't engage starter. First thing in morning it usually cranks. But once I turn it off it won't crank again. When I turn the key I have full power so it's not the battery or terminals. There's no cracking or popping sound, just a whine like the starter's not engaging. Never had any problems with this car so far. I'm thinking maybe it's the starter solenoid.
View 5 RepliesChevrolet - Silverado :: Starter Solenoid Not Engaging Below Freezing Temp
1996 SILVERADO TRUCK. Starter solenoid doesn't engage when temperature is below freezing....
View 11 Replies