Ford 7.3L Power Stroke (1999-2003) :: F350 Cut Off After Sitting For 6 Years?
I bought this truck from a family member 03 7.3, it's been a park not garaged sense 09 when my cousin the original owner died. Was strong running when park. I started it yesterday after changing solenoid, hot battery, and I put some fuel stabilizer and 5 gallons of diesel in it. But I cut it off maybe two minutes after because I didn't want to break anything before I found out what's a few tips of things to do before I put her onda road because this is my first go round buying a diesel truck
View 9 RepliesFord - Explorer :: 1991 - Rusty Water In Radiator And Recovery Tank After Sitting For Three Years
After sitting on a steep driveway for three years, no starting done all that time,I filled all tanks, started it up, drove it on and off 8 times for 50 miles, air in top radiator tank along with rusty water, dare we flush the system being 280k miles old with 40k on new radiator/ also is there a socklike screen over the fuelpump in the tank that may need cleaning to start quicker than two to three starter attempts?
View 4 RepliesRepair :: How To Start Engine After Sitting Years
I've an engine (Jasper 383 stroker) I haven't run in years; I was using synthetic oil. For a restart, should I pull the plugs and lube the cylinders--as not to break the rings--or just start the engine.
View 5 RepliesFord - Expedition :: 1997 - Misfiring / Stumbling While Sitting At A Stop Light
1997 expedition 4.6 .... Figured its the same motor. I bought it for cheap with a bad miss fire not sure what cylinders just did a tune up. I forget but I think they were motorcraft spark plugs I put in. But after that it ran grate so I thought. It would be intermiten but would all of a sudden while accelerating get a boost of power. That would last untell its next shift point and would always happen around 2-2500 rpm. Kinda like VTEC in a honda. Or it gained 2 cylinders. And would also start stumbling while sitting at a stop light for two long with it in gear and break on only after its warm. Never happens when cold. I hooked up tourqe and saw when it does it its misfiring on 5-6-7-8 randomly. Its missing on cylinder 4 all the time now which I believe is a plug, wire, or water-antifreez in plug hole.
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: Stumbling For The Last Two Years Intermittently / P1316 Code
I'm running a 2000 f250 7.3. The truck has been stumbling for the last two years intermittently. I did the 50 cent mod last fall to the uvch's. Changed CPS, idm, air flow sensor. This last week it finally threw the p1316 code so I have something to go off of. Trucks falling on its face so I parked it. Tore it down last night. Ohm tested all the injectors last night cold and all read around 3ohms. Tested the uvch's and continuity looks good on both sides. Tested them through the valve cover seal, tested fine. Tested them through the first harness and fine. All I have left to check is all the way to the idm. Still no luck finding the problem.
View 9 RepliesFord - Expedition :: 2003 - Stutter When Cruising Around 35 - 50 MPH And Not Giving Much Gas
My 2003 Expedition has begun to "stutter" when I am cruising around 35-50 MPH and not giving it much gas. If I am accelerating, or take it out of overdrive, it does much better. It is not an engine skip, more like a hesitation in the transmission. I recently had the transmission fluid changed.
View 4 RepliesFord F-150 - 1997-2003 :: 2000 Expedition - SES Light On
I'm chasing a SES light on my mothers expedition. It had bank 1/2 lean and the 4 o2 sensor codes. So I put a fuel pressure gauge on it. At idle it fluctuated between 31-35 (rose and fell with a rough idle) as engine rise/falls. Rev it up to 15-1700 an pressure falls to 29-30, unplug the regulator and it pegs at 40 no matter idle-2000 rpm... does those numbers sound right?
View 11 RepliesFord - Expedition :: (2003) Engine Quits For No Apparent Reason?
The engine on our Ford Expedition (2003) has started quitting for no reason. The engine light does not come on. We might be driving and it just stops or stopped at a light or turning into the driveway and it just turns off. Often it we simply turn it back on and it is fine but occasionally it is difficult to restart.
View 3 RepliesFord - Expedition :: 2003 - Door Ajar Switch Not Working?
Lubricating each door switch has not work to fix the "door ajar" issue on a 2003 Ford Expedition EB model. I have traced both front door wires to a single harness plug, but have not been able to find a pin-out description. Where on the wire harness each door ajar switch can be tested?
View 12 RepliesFord Expedition :: 2003 - A/C Quit Working - Compressor Cycling On And Off
My 03 Expedition A/C quit working, the compressor was cycling on and off so I took it in to be recharged thinking it was low. They said was completely out and it took 3.5lbs to recharge although they couldn't find any signs of leaking. When they recharged it they put more dye in to find the leak, the technician said he suspected a compressor since it was completely empty and had been working in the spring.
I was hoping it was a compressor as I have changed one before on my 97 Expedition and am pretty comfortable with it, however I can't see any thing leaking using a UV light. I have checked the compressor and every line I can see all the way back to the rear (it has rear air). When they recharged it worked very good for about 8 days on the 9th day it was working and went from blowing cold to hot instantly. Where or what to look for??
Ford - Gasoline - Expedition :: 2003 Dying While Driving, Will Restart Eventually
My wife has an '03 Ford Expedition with 110k miles on it. It began dying while driving. Sometimes while moving. Other times when stopping or idling. She would describe that sometimes when it began acting like it was going to die she could "give it gas" and it would revive, other times that wouldn't work. It would usually restart after one or two tries. Our local mechanic did a tune up and replaced a coil. During the trip she began hearing a sound of "metal shredding" and the car died and wouldn't restart. She had it towed to a ford dealer. They replaced the IAC valve.
After that the dying would continue but instead of dying right away it would "lose acceleration, and eventually die within a few seconds" Took it to another ford dealership and they replaced the fuel pump and relay. It would work fine for a few weeks and then start dying again. Another local mechanic noted the error code P0231 "Fuel Pump Secondary Circuit Low" He kept it for a few weeks and was able to get it to die for him once but not again. The dying continued. Sometimes it would work great for weeks, other times it would die continually on the same trip. Took it to a 3rd dealer and they couldn't find anything wrong.It dies in the cold and in the heat. Usually after driving at least 20 minutes into a trip. Once it dies once it will typically continue to do so until resting for a day or so. Sometimes with a full tank of gas, sometimes with a low tank.
Ford Wiring/Electrical :: 2003 Expedition 4.6L - Fuel Pump Relay Burnt
My vehicle would not turn over and we could tell it was fuel related. The fiel pump relay has burnt through the motherboard of the fusebox. It is my understanding that this cannot be fixedand another fusebox must be installed. I have been to many junkyards in my are looking for it to avoid the dealer prices..all of the expeditions that we have found locally have already had the fusebox pulled. Any other vehicles that this might be interchangable with? My friend has an 01 expedition..would this work?
View 1 RepliesFord - Expedition :: 2003 - Lights Get Bright Then Dim And Engine Will Die / Lose Power Steering And Brakes
My 2003 ford expedition with the 4.6 v8 engine is having an issue i cant seem to pin point. The lights will get bright and then dim and the engine will die and I will lose power steering and brakes, it will start back up when i put it in park. Also while I am driving randomly the rpms will shoot up to between 3 and 4,000 rpms and go back down. I have seen a video on youtube that says the fuse box in this model is very likely to short out and ruin the circuit board. Mainly looking for any experience any of you have with a issue like this. The check engine light is on, Showing two codes for running too lean and a code for Idle air control valve. Mileage is 239,000 ...
View 9 RepliesFord F-150 - 1997-2003 :: Running Hot When Sitting Still In Park
I have a 1998 ford f150 with a 4.6 v8 it has about 170,000 miles on it. The truck seems to run hot when sitting still in park. I have replaced the radiator, the thermostat. I am lost at what could be causing this issue. when I am going the truck will cool down however if you ever let it get hot it takes longer to cool it down as opposed to getting in it and just going and not sitting before going.
View 11 RepliesFord F-150 - 1997-2003 :: 1999 - Chattering When Shift Down Or Just Sitting In Neutral
My truck is making this chattering when I shift down or just sitting there in neutral it goes away when I press the clutch or if I push the shifter in the spot before the gear I was told it was a throw out baring but I'm not sure I herd this transmission will start to chatter before it goes out so what to do?
1999 f150 4.6 4x4 Romeo 5speed single cab...
Ford F-150 - 1997-2003 :: Truck Would Not Crank After Sitting For Few Days Without Being Started
I am having problems with my 97 F150 6cyl. A couple of months ago, I noticed the truck after sitting for a few days without being started would not crank. After some trial and error, I found that turning the ignition switch on and off several times did the trick and the truck would crank right up. I was thinking this might be a fuel pump or fuel filter issue but, I'm not sure.
A couple of days ago I was going to drive the truck and did the ignition switch deal as usual and the truck cranked up but, there shortly after while just idling the motor died. I have tried and tried to crank it and it want start back. After thinking on it, I don't know if this is a fuel problem or not, or maybe even the ignition box.
Ford F-150 - 1997-2003 :: 1998 Truck Not Starting After Sitting Overnight?
I have a 98 F150. The motor was replaced three months ago and have had no problems until now. The truck had trouble starting so i put an alternator on it. Fixed for a while and then it started blowing fuel relay fuses. I replaced fuel pump and filter. Truck has trouble starting after sitting overnight. When I am driving and floor it, once it hits about 4,000 rpms, the truck bucks like its the transmission but the rpms drop and then pick back up. Fuel pressure is right where its supposed to be.
View 1 RepliesExpedition :: 2003 - Spraying Fuel Out Of Fill Tube When Filling Tank?
My 2003 Expedition has started spraying fuel out of the fill tube whenever I fill the tank. It started 6-8 months ago. At first, I thought that maybe it was a fluke. It kept happening. I am so tired of getting fuel all over myself and my car. Not to mention the environmental impact of the fuel spill. This isn't just a little fuel dripping out of the tank and spilling on the ground. It's a full on projectile expulsion of fuel from the tank. What's happening and what I can do to fix the problem?
View 4 RepliesFord F-150 - 1997-2003 :: Rear Air Bags Have Been Deflating When Truck Is Sitting Idle
I have 97 F250 light duty equipped with factory rear air suspension. Truck has 180K miles. Both rear air bags were replaced about 100K miles ago under warranty (I didnt do it myself!). Both sensors and compressor are new within the last 18 months which I replaced myself. Recently, rear air bags have been deflating when truck is sitting idle. Compressor reinflates air bags as expected when struck is started but recently cannot maintain. Sprayed soapy water today on air bags and airlines and witnessed leak (due to air bubbles) at lower side of air bags on both sides. My conclusion is that air bags are culprit. Seems coincidence that both are leaking??
View 14 Replies