Ford 6.0L Power Stroke Diesel :: 2006 Truck Died On Highway / No Start
My truck died a few weeks ago on the highway had the hpop ipr valve and screen replace ran awesome for 2 weeks, shut it off ran into the store and it wouldn't start gave it a couple hours finally fired, started good the next 5 times go to start it the other day no start again, tried again 30 seconds later and starts trucks a 2006 with 226000km throwing no codes, I'm ready to go trade it off on a new one, where to start?
View 9 RepliesFord Super Duty (1999-2016) :: Battery Light Came On - Truck Died On Highway
Driving down the highway, battery gauge read fine power, but battery light came on. In a remote Alaska situation so I couldn't diagnose, plus truck is new to me. Kept driving towards civilization. All gauge dropped. Then lights dimmed, then truck died. This was over about 15 miles. At night with lights on. Truck has a plow with plow lights, aftermarket cranking stereo which I was using, heater on (Alaska). It sits 70 miles up the highway from where I'm at getting ready to go back and work on it. So...
Of course first thought it is the alternator, not providing enough power for all this. Looked inside, it is a newer looking reman. Belt is fine. My question is, if not this, what else could it be? I'm hoping to haul the alternator and whatever else out there and get it going without having to drive back and forth for more stuff I need. I can always return stuff I don't use. Probably I'll throw a new battery in it as well. But after that, anything else I should be thinking/ready for?
Ford 7.3L Power Stroke (1999-2003) :: Lost Fuel Pressure Going Down The Highway And Truck Died
Last night when i left work I noticed my fuel pressure was running about 77 psi, it normally runs about 68psi. today I took my daughter to practice and it was around 83psi, on the way home it was up to 95psi, so I parked it and took another truck to work.
About a week and a half ago I lost fuel pressure going down the highway and the truck died, finally decided my pick-up foot must have come off and had my sister in law bring me some diesel and it has drove fine ever since. (it was right at a quarter tank).
I have the FRX from riffraff and am thinking some pieces of that foot have got into the fuel bowl and plugging up the return. Things to check? Could it be a problem with the fuel gauge or wiring, and how to test them. It is an autometer gauge from riffraff.
It will probably be a few weeks before I can do much more than clean out the fuel bowl. I don't have anywhere inside to work on it and it's been rain/sleet/freezing rain/snow for the last 10 days. I have most of the stuff to do the hutch mod and its next on the list but was hoping to put it off till spring.
Ford Excursion :: Truck Died On A Hard Right Turn?
So making a hard turn this AM truck died. It started right up and didn't see anything else unusual. May be I should start by looking at I.A.C?
View 13 RepliesFord Excursion :: 2003 Truck Stopped Running And Died On The Side Of Road
I have a 2003 Ex 6.0 psd, 155k miles, and was on my way to work to a site 40 miles from nowhere. I was about 10 miles from my destination cruising around 65 when the Ex started losing power. I would say within a couple of miles power was gone and i had no choice but to pull over. I popped the hood, got out had a look around and saw no leaks or anything out of the ordinary. Let it sit for a few minutes and tried to restart it to no avail. There was no check eng light or any signs something was wrong.
I just so happened to have my OBD scanner with me and plugged it in and read for any extra codes. Three popped up on the screen: P0232, P0263, and P0278.
P0232 Fuel Pump Secondary (Feedback) Circuit High Voltage,
P0263 is described as a cylinder number 1 contribution/balance. In essence, this code is stating that the number one cylinder in the firing order is experiencing a fuel-related problem.
P0278 same as above for cyl 6.
Right away i thought the fuel/lift pump took a dump on me and was causing the fuel issues in the two cylinders.
Ford Excursion :: 2000 - Truck Starts To Shudder With The Cruise Control On?
I just recently bought a 2000 excursion 7.3 diesel. I'm new to diesel but learning. So far I've installed a new drop in filter in my airbox. Cut out the plastic behind the grill for cold ram air into the intake. I've done the FPR mod and cleaned out the exhaust back pressure tube. And last but not least I installed an Edge Evolution 2 programmer running stage 3 with timing advanced 2 degrees. Nothing else to the custom settings other than what stage 3 provided. Here is my problem. On the freeway at 65-75mph cruising with the cruise control on, the truck starts to shudder. I suspect my TC lockup is going out but not sure. So I wanted to test it buy installing a manual lockup switch. So I installed the switch running a wire from the plug going into the transmission on the purple with yellow wire using a saddle tap to a switch to part of the dash frame under the dash. Went to test out the switch and nothing happened.
As y'all and other forum's have described I should feel something and the od light should start flashing. I get nothing. Tried testing the switch and my ground source and everything tests out fine. Tested the saddle tap. Its fine. Tested with the switch on and using a meter to check ohms at the tap to the frame of the truck I'm getting 8ohms. I would think there shouldn't be any resistance because its a dead short but that's what I'm getting. Am I connected to the right spot on the transmission or should I move the tap to the plug under the brake master cylinder. Could my TC lockup solenoid be going out and that's what's causing the shudder and why the manual switch doesn't work.
Ford - F150 :: 1994 - CEL Came On For Around A Minute When Cruising Down Highway
I got a funny shifting issues that happens infrequently that I can no figure out. It happens after driving the car for a while on the highway, but not every time, and not just on the highway.
Here is my problem... when cruising down the highway the check engine light will come on stay on for a around a minute, the the check engine light will turn off, then of which my truck will lose power, not accelerate no matter how much I stomp on the gas, until my speed drops to under 55mph.
Once I get down to 55mph the truck will drop 2 gears into 3rd gear and then I can accelerate back up to speed. This will repeat every few miles. The computer will not store the check engine code, so no codes are pulled.
Ford Ranger / B-Series :: 3.0 Engine Stumble When Cruising On Highway
OK,it's a Taurus but it's the 3.0 Vulcan.On the highway crusing easy,now and then I'll get a stumble.It's like the key is turned off and back on.The tach stays steady but the car stumbles like the key was cycled quickly.I had to put a fuel pump in it a few weeks ago and now it is starting every time but this stumble has me stumped.
View 5 RepliesFord F-150 - 1997-2003 :: 2002 - Slight Vibration In Rear End When Cruising Down The Highway
Noticed my 2002 F150 had a very slight vibration in the seat / steering wheel when cruising down the highway at 60 MPH.. Very slight, but was not there 2 weeks ago.. It seem to get a little worst as the 2 weeks progressed. Got all 4 tires balanced and rotated... no luck...Took both rear wheels off-- no problems with tires -- checked bearing clearance-- pushed and twisted on driveshaft yolk to check pinion bearing... nothing found......... last resort was drop back end of driveshaft and check U-joint.. It was tight and dry. Put drive shaft in 12 ton press and pushed out the u-joint bearings. Very dry and joint pins were starting to spall....... I mention this because I had checked " clearance" and "slop" and had "no noise" before removal... Truck has 139K miles on original u-joints .......... Something to keep in mind. Eventually it would have worn to the point that it was obvious, but in the first stages of failure, you just get small symptoms.
View 7 RepliesBuick - Century :: Without Warning Car Abruptly Died While Cruising
Only two weeks ago I had the crankshaft sensor and the ignition module replaced in my 1992 Buick Century (3.3L V6). Without any warning, the car abruptly died while cruising. Are there any things outside of the ignition module or cranshaft sensor that can cause these things to fail? Was the mechanic supposed to disconnect the battery before replacing these items? Can a short-circuited spark plug cause the ignition module to fail? Can a mis-alignment of the sensor cause any damage? Could there be a hidden frayed wire that short-circuited?
View 8 RepliesGolf VI R :: Lurch During Slow Highway Cruising?
Experience a lurch during slowish highway cruising? If I am just putting along with my foot barely on the gas sometimes the car will give a jerk or a lurch like it's trying to decide whether or not to go fast or stall. Just a really quick bit of feeback that makes me think...what was that? Here are some common elements:
-Only happens when cruising at relatively gentle speeds (100km/hr or 55mph)
-Seems to happen more often if it's windy? Has happened a few times when passing by semi trailers
-Seems to happen more frequently when there is snow on the road or blowing snow?
Could it be some sort of sensor or air filter problem? No codes have been thrown.
Touareg :: Tranny Slipping Even When Cruising On The Highway
I'm experiencing a serious problem with the tranny on my V10 TDI: When the engine's warmed up it sometimes starts slipping and generally keeps on slipping, even when cruising on the highway, until the engine is cooled off again. In thread [URL] .... I read something about a "faulty solenoid valve inside the tranny". Could this be the cause?
View 12 RepliesPassat (B5) :: 2004 - Power Cut Out When Cruising At About 65 Mph On Highway
So I've owned my 04 Passat for almost 3-4 months now, I have a 1.8T 4Motion w/ 5speed, and love it. It will certainly be nice in the winter time with the snow and cold here in North Dakota.
I was driving on one of the state highways, and was cruising at about 65mph, when the power cut out, and giving gas didn't do anything and I eventually came to a stop. I let the car sit for a minute, tried starting and could tell that the engine was trying to turn over but wouldn't. This has happened before with my jetta, and its always been because of water in the fuel lines during a heavy rain, so I had my roommate come give me some more gas to see if we could just run the water out of the system since it had been raining pretty heavily here lately. Still no joy on getting started, occasionally the engine would turn over, RPM's would get up to about 1100-1200, and then instead of stabilizing at idle, the engine would just cut out again right away.
Got a tow from my insurance company to a local auto service shop who took a look at it and got a code saying the speed sensor wasn't working. They allegedly took it apart last night and fixed the speed sensor, had a loose wire, but it still won't start up. They've narrowed it down to the crankshaft sensor, or the entire ECU module being shot. I'll know by tomorrow if the crankshaft sensor is in fact the case.
If it isn't the crankshaft sensor, then is it definitely an issue with the ECU? Would it be worth to get an ECU pre-chipped(APR seems to be the way to go), and have that installed instead of a stock unit? Is it even possible to get a chip from these guys that comes already chipped, or would I need to get a new ECU first and then get it modded.
Golf VI R :: 2013 Shut Off When Driving On Highway At About 60 Just Cruising
I have a 2013 Golf R Apr stage 2+ with about 74k on the odo. I have been stage 2 for about 5k and was stage 1 for about 20k before going stage 2. Changed my plugs and coils at stage 2 as well. So was driving on the highway at about 60 just cruising when all of a sudden there was a minor hiccup in the car and then pushed the gas pedal and nothing, RPMs started falling and then car shut off, put the clutch in and coasted to the side of the road. Tried to restart and it would not.
I have power and car tries to start but won't catch and turn over. Towed it back to a buddies shop and let it sit overnight, still won't start. started poking around. Checked Hpfp and everything seems fine, cam follower and cam are good. Noticed that when I open my drivers door now I don't hear the other fuel pump prime like it usually does and after putting hpfp back on and opening drivers door a couple times we checked the Schrader valve on the hpfp and no fuel came out like it usually would. Have it narrowed down to most likely culprits; Faulty in tank fuel pump, faulty fuel pump control module, faulty fuel pump relay.
Btw just thought of this, no check engine light ever came on, also don't have a way to pull codes.
Santa FE SM (2001-06) :: Engine Suddenly Cut Out When Cruising Down The Highway
Cruising down the highway, my 2001 Santa Fe engine suddenly cut out. Would crank, but not fire. Not hearing a sound from the back when I flipped on the key, suspected the fuel pump, which I replaced. No go.
I'd pressed the fuel pump reset switch under the hood - checked it again. Should the switch, when it's pressed, stay in a locked position, like when you do a reset on a GFCI electrical outlet? Or is it normal for it to have the up/down 'play' in it?
Also noticed a strange buzzing on the other side of the engine compartment -- was the unit (don't know what it's called) that the throttle cable feeds into - hooks onto a pulley. The buzzing was intermittent and inconsistent, but it was happening with just the power switch on.
Oh, and did replace the fuel pump fuse, too. While it's at 280.000 miles, not quite ready to give up on 'er yet!
Santa Fe (CM - 2007-12) :: Vibration Comes And Go While Cruising At A Constant Speed On Highway
Our FWD Santa Fe Limited had a very noticeable vibration that started around 60mph. Oddly, the vibration will sometimes come and go while cruising at a constant speed on the highway. We went about 30k miles before we had time to get it into the shop.
I asked them to rotate and balance the tires and the vibration was noticeably reduced...initially. Now it's back!
The car has ~65k miles. All 4 Kumho tires match and I believe are original from the factory. I have kept all tires inflated properly.
Our car has the optional 18" wheels. Is it common for these to bend? What else could be the cause here?
Golf IV / Jetta IV :: Timing Belt Busted When Cruising Down The Highway
2.0L 8v ....So what's my chances the valves stayed clear of the pistons?
Driving 70mph 5the gear and cruise control set. Motor just died and I pulled off.
Cars back home in the garage. Iv ordered the ecs tuning timing belt kit.
This was a belt I installed 50k miles ago, shouldn't have gotten a auto parts store belt, or maybe it was my install, but I deff didn't think the belt was going to fail that early. Is there much of a difference between different brand belts and OEM?
Camry :: 2002 - Low Grinding / Rattling Noise In 5th Gear When Cruising On Highway
I've got a 02 Camry with a manual. In 5th gear, cruising on highway, there's a low grinding/ rattling noise. it doesn't do it if you try to accelerate, or if you have no throttle input at all, meaning it only makes the noise when trying to keep one speed, typically around 2000-2500 rpm. If i grab the shifter and apply pressure in any direction, the noise goes away. I've owned the car for 3 years now and its always done it, and hasn't gotten any worse or changed at all. I'm experiencing no performance issues and just chalked this up to gear noise, but recently read someone else was having same issue, and everyone was clamoring on about needing new bearings.
View 14 RepliesLexus IS 2014+ :: Loud Thump Followed By Continuous Thumps When Cruising On Highway
On my way home from work tonight cruising on the highway, heard a loud thump followed by continuous thumps thereafter. Knowing this wasn't good pulled over to find a nice big nail in my passenger side front tire, great. thought I could make it home, I was about 6 exits away...one exit later nail flew out and tire was loosing air.
- luckily for me, I had a friend who lived nearby the exit the nail flew off and put on the spare.... now my question is I noticed some camber wear on the tire.. 15,200 miles to be exact on the stock oem bridgestones.
- I know these tires are complete crap but... is this camber wear normal? I've seen other posts about it but, is it the tires? or something to do with the car? I am pretty sure my alignment is fine. If I buy a new set of tires eventually will this end up happening again? Trying to gain some knowledge for the future.
Also is it true that with AWD cars, if you change one tire you have to change all 4? because it might mess up the drivetrain or something, at least that's what I was told.