Ford Ranger / B-Series :: 1987 - Transmission Leak / Fluid Puking Out Inspection Plate Area
Dad gave me an 87 Ford ranger a couple weeks ago. I love it. Everything works except I'm having transmission leak issues when I drive her more than 30 miles or so.the symptom is fluid puking out inspection plate area. I checked coolant lines today and unfortunately they are working great. I've had a couple suggestions recommending replacement of the front seal our front pump seal (is there a difference?)
View 7 RepliesFord Excursion :: Coolant Puking And Overflow Tank Smells Like Exhaust
I have owned my 2005 v10 ex since 60000 miles. Have had many dependable family road trips and love my truck.
Recently it has started puking coolant and the overflow tank smells like exhaust. The oil cap has some coolant sludge on it. But there is no coolant mixed with the oil. Or oil in the coolant.
I am pretty certain these are the signs of failing head gaskets. The truck has 193000 miles on it now.
Want to keep it on course. But keep it reliable. So do I buy new engine or do I just replace head gaskets?
Ford Transmission :: 1999 - No Forward Or Reverse Gears / Black Trans Fluid
My 1999 7.3l Disel 4x4 transmission quit on me the other day. No forward or reverse. Got towed to my regular repair shop, and they are treating the transmission as a black box and recommending total replacement. The diagnostics they performed were to make sure it was shifting, and that indeed it wasn't going forward or reverse. They drained the fluid and said "it's pitch black" and said it had to be completely replaced.
Fluid level was OK, and it wasn't hot. I was driving along, and merging onto the highway. It downshifted, shuddred, and nadda. Free rev. I coasted to the next exit and into a parking lot. Verified that it was shifting, checked Rev and all forwards. It wouldn't shift into 4W, and 1-2 also wouldn't move.
I'm trying to figure out what might have happened... and if it's worth trying to have the truck towed to a transmission shop and have them diagnose and rebuild, vs just getting a remanufactured transmission. None of the local wreckers have any used transmissions, and the cost between a reman and a used is pretty negligible...
Not sure what the symptoms points to for exact failure mode, be it the torque converter, pump, input shaft, etc... I've never had an automatic transmission apart before, but built plenty of motors and am a machinist by trade. My preference is to try and root cause the failure...
Ford Excursion :: 2000 - Transmission Fluid Leak?
My new/used 2000 4x4 excursion with 214000 miles on it has a transmission fluid leak.
It could be a rear portion of pan gasket but it seems to be coming out of the area where the transmission bolts to the extension housing.
I just put a transfer case in it. Thought all the fluid all over was due to exploded T case.
It seems the output shaft seal may be bad. I cannot seem to find an OEM part number for this seal.
What is part number for this seal, if one exists? Maybe the seal is in the extension housing and it's just the gasket between Trans and housing.
Ford Excursion :: 2000 - Transmission Fluid Leaking?
2000 EXCURSION 7.3 Powerstroke
Automatic Transmission My son was trying to back up my empty 12' flat bed trailer up a hill (approximately a 25 degree hill). Why'll I was at work, my wife said he was having alot of trouble, and it was taking him awhile. She said she saw transmission fluid on the ground and stopped him immediately,and he turned off the engine. There is a trail of fluid on the driveway about 100' long and a 1/2" wide. This transmission has allways been solid, and only leaked a few drops on the driveway in almost 300,000 miles. what probably happened, and what I will need to do to fix it. I have allways worked on all my vehicles. But I know better than to get very deep into a transmission.
Ford Excursion :: Correct Way To Check Transmission Fluid Level?
Feel stupid for asking but what is the correct way to check transmission fluid level?
Do I put the words on the end of the stick right side up, if so I need to add fluid BUT if I flip it upside down I don't need fluid
About to go on my first tow away from home trip and want to be sure
Ford Excursion :: Radiator Work To Cool The Transmission Fluid?
If my coolant temp runs around 185, how does the the radiator to cool the transmission fluid if it goes to the radiator after the tranny cooler?
View 10 RepliesFord Excursion :: 2000 V10 - Transmission Whine After Fluid And Filter Change
Just changed transmission fluid and filter at 175,000 on my 2000 V-10 and now I have a whinnying sound and shifting that does not feel sure footed. It worked fine before the change. Fluid is synthetic and filter is Ford Motorcraft. Did it just go?
View 14 RepliesFord Transmission :: 2000 Excursion Overheated And Leaking Trans Fluid
2000 Excursion 7.3 unk transmission
Quick run down on the situation. It has been terribly hot here bumping 105 degrees. I was told by a man he could see fluid leaking and it was trans fluid. I checked it and filled it up and got it to the shop.
Next day they said it was not leaking and that it probably overheated. They recommended an after market trans cooler. They put it in and off I went. 60 miles later I got fluid all over the rear of the truck. I filled it up again and got it home. Shop says I need a new trans.
Ford Excursion :: Transmission Leak / Hard Time When Try To Reverse
I've seen this talked about before and it's happened to me before as well but now the tranny is leaking onto my Ypipe a couple times per week and it's giving me a hard time when I try to reverse. revs drop and it stalls if I don't give it enough gas.
So I know I have to change the seal but Ford is telling me the torque converter will need to be replaced but another transmission shop told me once the seal is changed and fluid level set appropriately I shouldn't have the reversing problem anymore?
Is this something I could attempt myself... looks almost like I'd have to move the exhaust to drop the tranny...
Ford Excursion :: 2003 - Transmission Fluid Leak Near The Front Passenger Side Of Truck
2003 Limited 6.0 130K. Just took a 1000 mile trip for spring break. While away, I noticed a small leak near the front passenger side of the truck. It is red so I assumed it was transmission fluid. It is leaking from, the best I can describe, a small housing that looks like it might be a filter near the tire (it looks like the old style canister oil filter housings). All the hoses are clean and where the hoses go into the radiator are clean. Is this an easy fix? I am a bit worried about trying to get the thing off without damaging the hoses.
View 3 RepliesFord Excursion :: Low Power - Poor Mileage - Transmission Delay Going Into Reverse
For the past two years I've noticed a decrease in fuel economy and recently noticed that the truck did not "feel" as if it had the same power especially when towing. Checking all the usual suspects with the engine turned up nothing and the transmission wasn't showing any signs of problems other than an occasional delay going into reverse. But it had been doing that for years and so I just ignored it.
Recently the torque converter started acting up and had some other occasional shifting delays and so decided to put the vehicle in the shop. The electronics all checked out and so a HD rebuild kit was ordered. The truck was finished this morning. Just barely pressing the accelerator makes the vehicle instantly start forward with noticeable zip. Plenty of power at all speeds, the engine now feels like new.
I suspect the main culprit was the torque converter. It wasn't enough to notice in excessive rpms nor heat (at least according to the instrument gauge) but the loss is noticeable in hindsight when compared to the repaired system. Over the next few weeks I'll get some mileage numbers and will know for sure whether I've found the sole cause of my power problems but I am sure that I've made a fairly large step in solving them.
Ford Excursion :: Use Speed Control While Towing?
We just got back from our first big trip with the EX since we have owned it. We towed our (new to us) 25' TT up to northern Michigan (Elk Rapids area). This was my first time pulling a camper this far. We have been on smaller weekend trips with it.
My question is regarding the speed control. I tried using it but when it was going up a slight incline it would not kick back down. I would have to turn off the speed control in order for the RPM's to drop back. Do you guys use your speed control while towing? What about over-drive? Should I have it on or off?
By the way, we had a great time and so glad we have the EX!!! Kids had plenty of room. Got about 8 MPG! That's how we roll!
Ford Excursion :: 2002 - Trans Gets Hot While Towing
I have a 02 excursion 7.3 with 120000 miles. Went camping and towed my 28ft travel trailer weighs about 9000 lbs loaded . The trans got super hot dumped fluid in the past this time same thing but the front seal went had it replaced and the trans pump rebuilt on the way home it got super hot a few times what I need to do now. The trans guy said the trans had been rebuilt in the past don't know when cuz I bought the truck used 1.5 yr ago..... The truck has tow package coolers its set up for towing how the hell do I keep the temp down...
View 14 RepliesFord Excursion :: V10 - Sounds Like Something Rattling Around When Towing
I had a flow master 50 sieries on my v10 and it sounds like something rattling around when towing. Guess i will have to find something different later on.
View 13 RepliesFord Excursion :: 5R110 Running Hot - No Warning And Not Towing
2005 Excursion 6.0 104,000 miles
I have a scanguage2. Normal driving yesterday morning. Not towing. Temp got up to 200 deg.....then later to 240!! Never an issue with the tranny !!
Yesterday I checked:
-the fluid level and it's fine.
-There was some crud on the dipstick though.
-temps for EOT and EWT are fine.
-a distinctive hot rubber smell too when it got to that temp.
Today I checked:
- the coolant for traces of transmission fluid...there was none.
-looked under the truck for fluid that may have blown out the vent....none
-no leaks anywhere
The truck is parked and will be towed to the shop so i don't incurr any more damage. So what could the prob be??
Ford Excursion :: After Towing No 4 Way Flasher / Turn Signal?
I towed my friends car hauler yesterday for a short distance for him. I had no turn signals or 4 way flasher while towing. After dropping off the trailer still no signals or 4way flasher. I parked and checked fuses all were good and signals started to work. But still no 4ways. Any thoughts on what to look for. Never had this before. I have blown a fuse before and always been able to find and fix.
View 13 RepliesFord Excursion :: How Much To Increase Tire Pressure While Towing
How much do any of you increase your tire pressure while towing?
View 7 RepliesFord Excursion :: Towing Mirror Lens Replacement
I have a new set of towing mirrors for my beast and also a set of the LED smoked signals. It appears that the old ones just "pop" off but I would like to know for sure.
View 3 Replies