Ford 6.0L Power Stroke Diesel :: Loss Of Power And Lots Of Black Smoke
Today I was riding along and all of a sudden I noticed a loss of power. I look in the rear view mirror and get into the pedal and a lot of black smoke. When I get to where I'm going and stop I noticed the idol was a little loopy. I never saw a check engine light. I have the Edge insight. I had two codes. P1000 OBD System readiness test not complete. P2290 ICP TO LOW.
When I would reset the codes the P1000 came back instantly every time. I parked the truck for about an hour. When I started it back up everything was normal. The power was back and no smoke. This happened two more times throughout the day. I have heard people describe a sticking EGR Valve causing these symptoms. Is that where I should start looking or is the ICP the culprit or something else?
Ford Fuel System :: 1987 - Loss Of Power / Black Smoke And Also Dying When Stop
So my 1987 Econoline Van was running fine until recently we noticed loss of power going up the slightest of hills and it will only hit 55 max with gas to the floor. Its shooting out black smoke and also dying when we stop. We are getting very poor fuel economy as well.
We got a tuneup, oil change, new air filter, etc. We also had a few electrical issues due to a short we thought we had fixed completely... So I'm wondering if it could be the timing? Cause it'll idle low, then high, then bog down and lose power...
Also was thinking maybe bad fuel pressure regulator or fuel pump....but how would I check this? And since we did experience a short, could we have blown a sensor too?
Passat (B6) :: Loss Of Power / Jerking And Black Smoke
Vehicle details : PASSAT 2.0 TDI 170 BHP DSG - 2007 ... 160KM
Problem:-
>>RPM doesn't climb as it should and esp in the run up to 3 gear and the DSG up shifts too quickly 4th and 5th
>>Loss of power. Pressing the gas pedal during all this leads to lots of black smoke and jerking but eventually the car picks up rpm and speed. Am I stuck in limp-home mode here?
>> No CEL light (yet)
The problem becomes very prominent when the engine warms up fully. Its drivable before that. Driving it in Sports mode is the only saving grace. Note that the car it is nothing like how it should be in sports mode, but feels better. I can hear the turbo whistle only when the engine is cold.
Initially, the Engine mounts were thought to be the culprit (for jerking and then ECU reducing power) and then later the EGR value unit (jerking/pinking and power loss).
Work done so far :
1. Original VW Timing Belk Kit (incl water pump) - September 2012
2. Engine Mounts changed - - September 2012
3. Has been plugged into VAG Diagnostic software and an intermittent error was detected for EGR.So, EGR valve control unit was changed - late December 2012
4. Engine Oil (5W-30, fully Synth) and filter changed three time in space of last 10K KMs after I bought the car in September 2012. This is something I wanted to get done anyway to flush the engine
5. Used injector cleaning additives couple of times -December 2012
6. ECU (error-code) reset procedure, just a couple of days ago. This actually seemed to remove some of the jerking and loss of power, but it appears to be coming back now.
7. Transmission reset - yesterday . Did this anyway although the DSG seems to be fine, no problems with the gear shifts
Santa FE SM (2001-06) :: Black Smoke And Loss Of Power When Driving
I have a Santa fe 2002 crd 2.0 4x4 and recently had a lot of black smoke and a loss of power when driving, it starts fine but when revving it blows black smoke from exhaust and has no power to pull away, been told its possible turbo problem or fuel problem.
View 1 RepliesSanta FE SM (2001-06) :: Loss Of Power And Black Smoke Out Of Exhaust
Initially I used to get cutting out of the engine randomly whilst driving which everyone believes is linked to an ECU issue i believe...I added some reddex fuel cleaner and that seemed to clear the problem up for myself which is a diesel 2.2 ...
However I was beginning to have starting issues where i would need to pump the gas to get the car started...I changed the battery and the glow plugs and yet i was still having issues. I had the air intake and filter looked a diagnostic test run both showing no issues and then one day I was driving and suddenly i got a huge loss of power and black smoke out of the exhaust....Seriously i had no grunt and i was a hazard to cars behind me....!!!! It was weird how first thing in the morning it seemed fine but later in the day i was getting this problem over and over again and eventually the car wouldnt start without a jump from another vehicle..
Any how i took it to various garages but in the end i took it to Rockar Hyundai at Dartford (i cannot recommend enough) but simply all they did was look at the fuel filter and saw that one of the injectors were faulty...After changing this the problem still occurred but again only when the car was warm...They then looked at the pipes leading to the injector that was faulty and then found that there was a crack/split in it and obviously when cold it was sealed but when warm was opening and i believe letting in air.... Anyhow they have changed that and the car feels great and no issues...
Ford 6.0L Power Stroke Diesel :: 2003 Excursion Putting Out Black Smoke / No Tuner
I have a 2003 Ford Excursion with the 6.0 diesel. Just driving the truck today and it was putting out black smoke. What could be causing it? No tuner on my truck, just a 4 inch straight pipe and a k&n air intake (bullet proofed, but thats not for performance) ....
2003 ford excursion 6.9, black smoke, why? - YouTube ....
Ford Super Duty (1999-2016) :: Loss Of Boost And Black Exhaust Smoke
I have a serious issue with my 2004 F250 6.0. Pulling a trailer something under the hood sounded like an explosion and lost power and boost. The truck started blowing black smoke from the tail pipe. I could see no psychical damage to anything under the hood. There was absolutely no power but managed to cripple home. What happen.
View 14 RepliesFord Excursion :: V10 Blowing Black Smoke / RPM Goes Up And Down
My v10 Ex blowing black smoke, RPM goes up and down, when put it in gear stalls and dead, engine is shaking and all this happened after one small 80mi trip, it was perfectly running until I turn off the engine .for almost 2 minutes. So what to do ?? And there is no code .
View 6 RepliesFord Excursion :: Lots Of Hesitation On Takeoff And Large Cloud Of Black Smoke
I recently had the Blue Spring installed on my 04 X. After having it installed I still noticed a lot of hesitation on take off, and after a few seconds of trying to take off it kicks out a large cloud of black smoke and away she goes. The problem is very noticed when at the bottoms of hills it seems powerless and makes a wierd noise from the drive side of the engine bay, until I press the pedal enough to make it downshift then comes the large cloud of black smoke and she climbs up. All I know is I'm getting worse fuel economy then I should get and something just doesn't feel right when driving the X. The truck doesn't feel like it missing at all so I don't think it would be injectors especially as They are all brand new and less than 6 months old.
View 12 RepliesFord Excursion :: Coolant Loss And White Smoke From Tailpipe
I was having an issue with coolant loss and white smoke from tailpipe. Was told it was likely intake leak vs headgaskets. Changed intake gaskets, fixed the issue for a day then it started just dumping coolant from every available place in the exhaust system. Was draining a full collant bottle in about 2 minutes. Was also checking for exhaust in the coolant with the tube and blue liquid which it stayed blue. Had previously done a degas pressure test and it passed. The only test I hadn't performed was compression test which all the cylinders output was lowest 160 to the highest about 185. Did not perform a wet compression test as I was mainly looking for base compression and consistency.
Not sure what healthy is on these vehicles but considering they were all running pretty close I call it good. Also it idles just as smooth. Pulled intake a 2nd time and rechecked my previous work. Everything looked fine so I put it back together. Ran smoke free for about 50 miles now I'm back to smoke after it sits a bit but it clears up after a short drive. What am I missing? I will note that I had a small coolant leak from drivers side rear of engine that I noticed while it was parked in the shop. I'm assuming that would be the oil cooler? But oil is clean so it's not mixing. What other avenues on these engines can coolant make it into the exhaust? Drives perfect with no power loss.
Ford 6.0L Power Stroke Diesel :: 2003 - Black Smoke - Lack Of Power
I have a 2003 with 150k miles. My 6.0 has black smoke and can barely crawl up a hill. Dealership is 30 days out for an appt. Air filter, oil change, alternator, and batteries are new. I removed the EGR valve and cleaned, but the valve seat is not perfect. I can see 20 to 30 mil gap around half of the seat. Is this ok or will that little gap cause this?
Hoses all look good. No alarm lights. I have no diagnostic tool but I can use a meter well. It did have an airbag light but I found the fuse missing and replaced it. The air filter alarm switch fell apart but I bypassed it till I get new part. No alarm lights now.
Ford 6.0L Power Stroke Diesel :: Low Power And Bad Shaking / Black And White Smoke When Revved Up
I went out to the store today all was fine came back out and started driving got 2 miles down the road to a red light and the truck about stalled no power it doesn't smoke at idle but revved up it blows black and some white and the truck shakes. I am thinking its stiction or bad FICM????
View 13 RepliesFord 6.0L Power Stroke Diesel :: No Power When Takeoff From A Stop / Black Smoke Blown
So I am not sure exactly what is going on with my truck. It is a 2004 F250 has a 6.0 L. Sometimes when I take off from a stop the truck has no power and blows some black smoke. Then the turbo kicks in and all is fine. It comes and goes when it pleases no matter the temperature. What started happening is when I drive it a steady pace on the highway sometimes the turbo gets quieter and louder and quieter and louder sometimes when it gets quieter I see a little bit of black coming out of the tailpipe. Sometimes it doesn't do it at all. Also sometimes when I let off the gas the truck sounds like it's trying to laugh at me like a wastegate is fluttering.
View 10 RepliesFord 6.0L Power Stroke Diesel :: 2005 - Rough Idle - No Power - Black Smoke?
05 6.0 deleted and studded. 170k fresh filters and oil, no CEL or codes.
This has happened 3x in months, so it intermittent. Truck will start fine cold, except for this last episode ....
Truck starts right up, idles correctly, speed bumps up if its cold enough to trigger the high idle. About mid way through its warm up, at approx 130-140 idle falls off, barely runs. Almost knocking. Black smoke if you give it throttle. Has no power when its doing this. Truck will not move and almost dies in gear. Give it til 185ish degrees then pooof! All good.
However 2 days ago it wouldn't start. Cranks but won't catch. Stumbles and dies. Finally got it to start after setting the charger on it. I killed it. But this time when it started it was straight into its rough idle, no power...until about 180. I switched it off, restarted it and it was totally fine
Ficm is 47-47.5. Every now and then I see a 46.5 for a split sec
Hpop is 700-800cold cranking.
Not sure what else to look at.
Moto craft filters.
Amsoil 5w-40
Archoil in the fuel and oil
Twc3 at every fill up.
Ford 7.3L Power Stroke (1999-2003) :: Black Smoke - Little Power - No Boost Until 2500 Rpm?
Short version is that I just did the EBPV delete with new pedestal and turbo exhaust outlet and put a new turbo middle cartridge in as mine had blown a seal and possibly broken the shaft. Once I got it all put together, I took it for a test drive and it was building 20PSI like it used to but I didn't have the accumulator and turbo mated up fully so I had a leak there.
I corrected that and now don't get any boost until I get to about 2500RPM and then it only builds to about 10PSI. I've double and triple checked all my connections, boots, etc. and everything is tight on the intake, intercooler, up-pipes and collector, exhaust and the spider, I can't see or feel any problems there. I tried disconnecting the MAP sensor and it might be a little better but not even close to normal.
Tried disconnecting the red line from the wastegate and plugging it with no difference. I'm stuck, and frustrated. I do have AE, watching the MGP looks like the MAP sensor is working. I feel like I'm overlooking something simple but I just can't figure out what it is...
Ford 7.3L Power Stroke (1999-2003) :: Intermittent Rough Motor / Black Smoke And Low Power
I have an Excursion with 220k miles. I've owned the truck for 6+ years and had very few problems. I change my own oil and fuel filters, but beyond that I know next to nothing about the diesel motor. I do run a DP Tuner with the standard 80 hp program. And a 4" exhaust. Everything else is stock. I do keep it plugged it for the oil heater and the battery tender just about all the time now.
This latest issue started yesterday morning when my wife jumped in a cool truck to take the kids to the dentist (not warmed up but still 55 degrees ambient). A few miles down the road (35 mph max) the motor began stumbling and rocking and black smoke coming from the exhaust with reduced power. She pulled off and kept it running (very rough and rocking) and put it in park for a minute. When she put back in drive, it shifted heavily but the power was normal so she went on her way without any problems. The only report I got sounded like the motor was just cold and rough, so I thought nothing more of it.
Yesterday evening we drove it about 70 miles on the highway (72 mph max) with no issue at all, but when we continued on surface streets toward our destination (50 mph max) it did the same thing, but would not settle back down. I kid you not that it went through gallons of fuel the last 12 miles or so, just dumping black smoke out the exhaust. It felt to me like we were running 1/2 the motor, like the plugs weren't lit. Very rough and rocking and very little power (comparatively, at least). I had to switch to manually shifting the trans to get going and the shifts were much rougher than usual. Idle was low and rough but it never stalled. Behind me there was a huge smoke screen this entire time.
We made it to our destination and parked it. Did our thing and after 5 hours went out with finger crossed. Started right up and ran perfectly the entire 91 miles home. No motor or trans issues at all. Currently running 10/40 synthetic oil that I just changed about 2000 miles ago. Oil level is perfect. 3/4 tank of fuel with standard level of Diesel Kleen added. Fuel filter is less than 10k miles old. Temps yesterday were 65-70 on the drive down and 50-55 on the way back.
I jiggled all sorts of connectors this morning and didn't find anything loose.
Ford 6.0L Power Stroke Diesel :: Black Smoke All Of A Sudden
Started with lots of black smoke all of a sudden. Not under any significant load at that time. Reached destination (barely) and started the search. Have taken off blue connectors on CAC passenger side. Top is marginal but see no holes. Pulled the MAP hose and see nothing unusual. Have not checked the driver side CAC or the BPV sensor. Have a ScanII device that shows no codes. Got my other scanner and it too shows no codes.
Had it towed home over 100 miles 'cause now it just barely runs. Idles fine but have a engine noise change (deep and hollow) every once and a while at idle. EGR leak? Doesn't blow black smoke anymore. More of a white/blue. Exhaust smells odd. Absolutely no turbo activity. When shutting hear no whine down of the turbo. No boost evident on the dash or on the scan II. I am at a loss at this point. Will check fittings again.
Ford 7.3L Power Stroke (1999-2003) :: More Black Smoke When Towing?
Normally I run around sea level at home but Iam on road trip in Wyoming at over 5000' elevation I am noticing alot more black smoke when towing. I run a DP tuner with 40 and 60hp tow mode. I also notice alot more black smoke in 60HP Econo Mode when not towing? Would this be typical due to the higher elevation?
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: Low Boost / Black Smoke
Bought the x in feb, put in the billeted wheel, modified the turbo pedestal, put in dorman uppies, put my boost leak detector on it and had no leaks then. Also put on the walker btm and gauges at that point. Took my chip to a local to get tunes. I was pleased enough with the power, and can hit 24 psi. However, it smokes like a freight train if I give it much pedal. I don't drive it a ton, but in the last week I did a 400 mile trip to pick up a trailer, then 800 miles on vacation in Colorado. The fender flare by the exhaust is now black.
It has to be pulling a trailer or going up a decent hill while cruising at 70 to show any boost at all on the gauge. If I give it gas, it belches out the smoke, unless I get on it and get the boost to 10 or more. Most of the time while cruising along I don't need to speed up that much so it just smokes and doesn't build more than 2 psi boost.
My f350 by comparison usually runs 4-6 psi boost running down the road at 65, and slight movements of the accelerator can affect that number immediately.
I don't have my leak detector with me so I can't verify that I have no leaks right now, but I can still hit 24 psi... Last night I used oven cleaner and got the whole area around the turbo pretty clean. Drove it 60 miles today, and don't see any soot around anything, maybe it's to soon to tell? Is there anything else I should check, or is it as simple as getting new tunes?