Ford Excursion :: 2002 - Battery Light Comes On And Off Randomly
So my dummy light came on the other day, I went ahead and pulled the alternator and had it tested at advanced. It tested bad so I replaced it not my battery light comes on and off randomly. I have a edge tuner on my truck and my voltage reading on there is different after each start up. Sometimes it runs 12.1-12.2 other times it reads in the 14's I have checked with a multimeter also and got the same readings +-.1 or 2.
My dummy light keeps coming back on randomly, I had to replace the alternator connector because I broke it by accident. I also traced the wires as far as I could to check for brakes in the wire and found none with out proper time to pull all the wire loom off. What is the cause I know I could probably use cables soon as my terminals look a bit rough but are clean. Seems to be some really weak flimsy metal. Which fuse to check as my 2002 ex 7.3 only has the inside fuse block and I can't find much online about it.
Ford Excursion :: 2000 V10 - Battery Light Flashes Randomly After Rebuild / Upgrade
So I have a 2000 6.8l V10 that I recently swapped the engine on (reman). While I was doing that, I decide to do some LED upgrades. I swapped out the turn signals, side marker lights, and headlights with LEDs. I added some LED fog lights, and I have a Rigid light bar.
I replaced pretty much everything on attached to the engine aside from the alternator (it didn't give me any problems, so I figured it was good).
When the truck is running with the lights off, there are 6 LED strips running as DRLs, when the lights are switched on, the side marker, turn signal and headlights turn on. When I switch to high beams, my fogs turn on. The light bar is on its own switch.
During the day with the headlights off, I dont notice the battery/charging system indicator light turn on at all. At night, when I flip the headlights on, I've noticed that it sporadically and randomly flash. The flashing indicator light does not appear to be associated with bumps or anything.
It does not seem to matter if I have just the DRL/low beams on, DRL/high beams+fogs, or DRL/high beams+fogs + light bar on. The indicator light comes and goes with the same random consistency regardless of how much power I am sucking from the alternator/battery. The RPM's of the engine also appear to have no effect on when/how often the indicator light comes on...
I drove for over an hour last night, and the voltage gauge never changed, so the battery does not *seem* to be draining (~1 year old Optima yellow). I added an extra ground wire going from the battery to the engine about a year ago (long before this LED upgrade) to ensure a good ground, so I dont *think* the wires are the issue. Is my alternator suddenly going bad? Any higher output ones I could replace it with? Is it a simple fix that does not require a new alternator?
Here are some pics of the lights:
(This was before the fog light install)
These lights only come on when the truck is in reverse:
Ford Excursion :: 2005 V10 - Headlights Cut In And Out Randomly
I have a 2005 Excursion, V10, 6.8 2WD w/ 177k. About 3 months ago, I started the engine and both headlights (low beams) did not turn on (it was dark out/automatic lights) The running lights were all running. Turned the switch on/off and no luck, however the brights (high beams and flash to pass) work while this is going on. About 30 seconds later, the low beams turn back on by themselves. Fast forward 3 months, the low beams will turn off for anywhere from 1 second to 30 seconds and turn back on. This happens while sitting in driveway, driving, sitting at a light etc. No changes other then an oil change. Happens when switch set to automatic and "on" as well. Brights always work, running lights etc, just the low beams turn on and off.
View 5 RepliesFord - Focus :: 2005 - Battery Light Has Been Come On Randomly
I have a a 2005 Focus, 199,000 miles. The battery light has been come on randomly. It doesn't seen to be related to any other event in the car. Things I've done to diagnose it...
I cleaned the battery cable connections before I started any diagnostics.
I have two code reader and no codes are being thrown.
I connected a multimeter to the battery while the car was idling in the driveway.
I got 13.8-14.1 volts as the car sat and ran. When the light came on no change on the meter.
I have a Scan Gauge that allows me to watch the voltage in real time. Four days and no change when the light came on. ~13.8-14.1 at idle and ~14.1-14.4 underway.
I have the Car Chip. I plugged it in drove for about 10 runs and the voltage trace was pretty flat on all runs, battery light on or off.
The only thing that is consistent is if the light is on and I rev the engine it goes out BUT they rpm when the light goes is inconsistent.
Ford Excursion :: 2002 - Shake When Pushing On Gas - Randomly Die?
Bought an Ex last year with 200k miles on it. Started having issues this summer. First off, it will shake when pushing on the gas. If I let off the vibrating stops. Secondly, if I tromp on it, the speedometer drops for a second then comes back up and the "ABS" light comes on for that split second too. Thirdly, it will randomly die on me. This morning dropping off the kids at school, it died 3 times while backing up. Starts right up, but will just kill, no sputtering.
The Check engine was on, so I took it into Advance for a reading. Computer said there was an issue at the rear output sensor. So, I replaced the Speed Sensor on the rear differential last night. Take it for a test drive, and the check engine light is still on, but the Overdrive light on the shifter is flashing randomly.
Now, I assume the shaking and dying is Fuel related. I am ruling out the spark plugs as it idles fine (maybe I'm wrong). I purchased a fuel filter to replace that and hopefully it works.
Ford Excursion :: Hard Jolting Miss For A Second Randomly
Installed the Riffraff gauge kit and the check engine light came on about 20 miles after install and the Ex now randomly has a hard jolting miss, just for a second then its gone. Took it about 4 or 5 times of the jolting miss then the check engine light came on.
Could something have been unplugged or could the manifold air intake heater delete be causing the light. Ran fine until the gauge install. I remember reading something about the ground for the manifold air intake heater being a issue if not care full. I could not get the dam thing off so tapped the end and left it. The ground post kept spinning not allowing the ground to come loose. This thing is becoming a pit I cant feed fast enough.
If I can figure this out before Monday that would be great. If not I am tired of dicking with it and am just going to take it in. Don't have a scanner that will read the codes so SOL there. Unless there is some way to get them off with a flashing light sequence. I would love to find out how to do that. I don't want to drive it anymore than I have to as if one more thing goes wrong with this dam thing........
Ford Wiring/Electrical :: Battery Goes Dead Randomly Overnight
Earlier this year had dead battery after sitting for a week. 5 year old battery so bought new one battery still goes dead randomly (overnight), instead of playing radio for a few minutes after key off, dash displays "system off to conserve power" ran it thru local repair place (ex ford dealer) nothing found. Voltage 14v at 1800 rpm, lights on". STILL goes dead randomly...
View 6 RepliesFord Escape / Hybrid :: 2002 XLT V6 - Battery Light Randomly Comes On
I have a 2002 Escape XLT V6 4X4. I searched the issue, but others' symptoms don't seem to be quite the same as what I'm seeing. Over the last few weeks, the battery light has randomly come on and off 3 separate times:
- 1st time, light came on at highway speed for about 30 sec and went out. Didn't come back on. Was during daytime, running DRL's, radio (no amp or subs or anything like that, and heater blower on low speed.
- 2nd time was two weeks later or so. Happened at night with just headlights on at around 55mph (RPMs about 2K or so). Again, stayed on for about 30 sec and went out.
- 3rd time was about a week/week and a half later, yesterday morning. Just running DRL's and radio. Light came on, flickered, came on, and then stayed on for a couple of minutes (all at highway speed). I noticed that if I disengaged the overdrive and got the RPMs up, the light would go out. I ran it out of overdrive for about 2 minutes like that, and the light stayed out. Speed limit dropped to 40mph, and the light came back on (lower RPMs at that speed, didn't run it in low gears). Light stayed on for 30 sec - 1 minute, and then went out on its own and has since stayed off.
I took it to Advance yesterday to have it tested, and the results were that it is charging at 13.9V under no load, and 13.87V under a load. The battery tested good, but the machine said it needed to be charged (it hasn't been acting low...car starts just fine).
I'm driving it to work today to see what it does next, and then getting it tested again on my way home. Has anyone here ever had similar symptoms as above? Does this sound like bad diodes in the alternator?
Ford Excursion :: 2004 - AC Control Unit Has Randomly Gone Dead Twice
I have a 2004 Eddie Bauer with 16k miles. The AC control unit has randomly gone dead twice. When I turn off the truck and let it sit for a while (20 min last time) it will come back on and work fine. I took it to the Ford dealer while it was dead so they would see it. They told me however, that if it works when I bring it back they wouldn't be able to work on it. What was the problem? I'm going to Parker AZ this weekend and Phoenix next weekend. I don't want it to be intermittent or crap out all together when I am there.
View 14 RepliesFord Excursion :: 2005 V10 - Front AC Blower Cutting Out Randomly
Have an 05 Limited Excursion v10 where the front blower motor will cut out randomly. The rear blower will work without issue even when the front is not working. When the front is working (98% of the time) all speeds seem to work and can adjust to all heating/cooling positions. After searching the forum I thought the likely culprit was the blower motor; which I replaced this pass weekend but coming home from work it cut off again, clearly the issue is not resolved. I know the ford resistor are known to be prone to issues but symptoms do not seem to point that direction. Also it is does not happen with any consistency, happens at idle just as frequently as the expressway. What else to check and how to check before I have to give in and take to dealership...
View 2 RepliesFord Excursion :: Check Engine Light Comes On Randomly - P0683 Code
I randomly started throwing a couple codes that have been causing my "check engine" light to come on ... came on on my way into work this morning) . I know that the P0683 code is the Glow Plug Ctrl Module to PCM Comm Circuit (from my code reader), but I am not sure what to do next ... I have the dealer service DVD from 2002 that I will look at this weekend....
View 7 RepliesFord Excursion :: Fuel Pump Died After Rough Running Randomly
I have been chasing down what was a perceived vacuum leak...
My Ex (V10, 4x4, 217K miles) started to have an intermittent rough running/no power situation very randomly. No codes on the scanner, and no real apparent cause or condition to pin it down. I noticed what sounded like a like throttle ping...figured it was a vacuum leak someplace in the spaghetti under the hood.
I began to run down the possibilities. I have recently had the entire suspension replaced and upgraded all 4 corners to Power Stop brakes. Figured it might be something related like the classic lines to the hubs.
Replaced the vacuum lines to the hubs - ran OK for a bit, then rough start/idle/no power.
Replaced the vacuum switch for the hubs - ran OK for a bit, then rough start/idle/no power.
Replaced fuel filter - ran OK for a bit, then rough start/idle/no power.
Ordered a new vacuum reservoir...
While waiting on that, changed all 10 plugs and coils. Not. Cheap. Ran OK for a bit, then rough start/idle/no power.
Replaced IAC - ran OK for a bit, then rough start/idle/no power.
As I was getting ready to install the vacuum res, it just croaked. it would turned over like it wanted to start, but wouldn't catch.
Of course.... So, now it had to be towed and yes, the fuel pump puked and that was that. I've never had one do anything but just quit suddenly before, so lesson learned. Evidently these pump can act up for a bit before they die.
Ford Excursion :: Brake Intermittent - Hard Pedal And Pulsing Feeling Randomly
I'm having an issue with my brakes. It was very intermittent, but seems to be happening a little more often lately. 99% of the time they work fine.
I'll try to describe. (vaguely) It will sometimes feel like the ABS is engaging, get a very hard pedal and some pulsing feeling. Sometimes just the pulsing without the hard pedal. It will happen at random times. Today it did it in the driveway going 5 MPH. No reason the ABS should think of kicking in.
I feel confident to rule out anything downstream at the wheels. I am leaning towards the master cylinder, but maybe that's wishful thinking. Afraid it also could be something sticking in the ABS which I assume is $$$.
Brake fluid is 18 months old with maybe 20k on it.
Ford 7.3L Power Stroke (1999-2003) :: F350 - Battery Light Flickers Randomly
I have a 99 f350 7.3l 4x4 and my battery light flickers randomly. I have checked the alternator and both battery's. All brand new and seems to be ok. They only are getting a charge when the battery light is flickering. I put both new batteries in on Thursday and on Sunday I needed a jump at the store.
View 7 RepliesFord F-150 (2004-2008) :: Truck Dying Out Randomly / Battery Light On Instrument Cluster
I recently had my alternator and battery replaced due to my truck dying out randomly on me, tested the alternator and failed, replaced battery, and still got the same results, battery gauge seems to drop quickly, what could be going on, I have been told to replace the fusible link that goes from the battery to the alternator....
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 Excursion Will Crank But Only Start Randomly
I have a 2001 Excursion 7.3 Diesel that is having a starting issue. Have replaced the batteries, has new glow plugs, common failing cam position sensor replaced once already. It runs great when it starts, no codes. It will crank, but not turn over at random times. Will do this for 3 or 4 tries...charge the batteries, go back later to start and it will on the second try. Turn it off, try again..and back to cranking, but not starting. Not fun having to worry about being stranded somewhere. Absolutely desperate at this point.
View 4 RepliesFord Super Duty (1999-2016) :: F350 - Randomly Clicking Relays And Battery Running Down
Bottom-line question: is there a way to tell if a GEM is fried?
'99 F350 with a known water leak (not where it leaks, but for sure that it does--glove box, floor mats, etc.).
Recently started running the battery down, and then noticed that under low-voltage conditions it would click the door-lock relay back and forth, etc.
Now, after several inches more rain, it's making clicking and other electrical havoc noises any time it's not running, key in or out, even when the battery is up enough to start the truck (V10). I charged the truck and started it, drove it around to let it charge some more, and when I got home and shut it off, it was clicking as bad as ever.
After reading on the forums a while, I went ahead and pulled the fuse panel and GEM. The two big fuse panel connectors were definitely wet inside, and there's a little corrosion on one or two of the bayonet connectors. The GEM itself doesn't seem wet, and it doesn't look/smell like I've let the smoke out of it.
What do I do at this point? Last time, after I charged it up, it seemed to hold a charge and didn't do any clicking. I thought at the time it was related to the door switches that had been on the fritz (and which I lubricated after reading about where they are). Now, I suspect it was just because it had been long enough since it was rained on that things had dried out.
Accent MC (2006-11) :: Car Battery Dying Randomly
Only electrical mod that was done was the fog light mod so I can turn them on when I want... Is it possible that even if the fog lights are off, that they are pulling some juice from the battery ? In the last 6 months my car has died 4 times, ever since the fog light mod.
View 20 RepliesElantra XD (2001-06) :: Battery Draining Randomly
I have replaced the alternator and battery has good clean connections and cables. I have pulled the fuses for the interior lights and radio and alarm and it still keeps dying. The battery will be dead randomly could be overnight could be a few days...
View 3 Replies