Caravan/Voyager :: 2008 Grand SXT - Transmission Makes Tapping Noise When Shifts Or Downshifts
this has been an outstanding van, quite reliable. it has about 115,000 miles on it. Recently, I've noticed that the transmission makes a 'tapping' noise when it shifts or downshifts. every gear has that same slight 'tap'. the tranny shifts fine, smooth, but this sound worries me a bit. any chance this could be a u-joint issue?
View 1 RepliesFord Excursion :: Door Locks Makes Noise When Hit Lock / Unlock Button But Does Not Move
I am getting ready to tackle a few projects on the new X. First I would like to fix the door locks. passenger side front, it makes a noise when i hit the lock/unlock button, but doesn't move. Hoping it is the actuator but wanted to make sure first. Is the actuator the first culprit to fix? I guess, How do i know it is the actuator? Wanna order them from rockauto soon. I've researched on here door actuators, looks pretty simple.
View 2 RepliesFord - Taurus :: 2002 - Motor Makes Ticking Noise When Warmed Up
Three days ago, my 2002 Taurus ses, 144k, auto, 3.0 v6 motor, started "ticking" after I drove it to the local grocery. It is coming from the top of the motor, but does not make noise when it is first started, cold, only after it is warmed up. Oil & filter has 2500 miles on them, all other fluids are good.
View 1 RepliesFord - Escape :: 2002 - Hot Weather Steering Wheel Makes Noise?
If I drive my 2002 Ford Escape in hot weather, the steering wheel starts to make noises as if it's scraping something if I turn the wheel even a little bit. I don't notice the sounds when I drive around in average temperatures of 70 or below. It happens more frequently if it's a hot day. What's going on?
View 4 RepliesSubaru - Outback :: 2002 - Makes Roaring Noise When Gas Pressed?
2002 Outback, runs great EXCEPT for very annoying roaring, revving noise when gas pedal is pressed and going over 35mph. Sounds like car is running 60 mph in second gear. It is an automatic transmission. Don't think it's a transmission problem, gears change smooth (does about 2300 rpms at 65 mph). Sound will stop and runs normal if you let off gas. Noise is loud. Bearings, exhaust, etc.
View 10 RepliesAccent RB (2012+) :: Transmission Often Shifts At Very Low RPMs And CAI Makes Loud Burble
I installed the TurboKits CAI kit a few weeks ago. Installation went smoothly, and the latest kit has a modification to the box that fits our Accent's air snorkel. On cars with automatic transmissions, I had to cut out a notch from the bottom of the box to clear the transmission, but I doubt that this affects the air flow to the filter.
However, I have a big problem with the sound. The transmission often shifts at very low RPMs, and the CAI makes a very loud burble when this occurs. If I shift into a lower gear using the semi-manual mode, then the sound goes away. I realize that CAIs make a louder sound when you put your foot into it, but I find the sound a little over-the-top (especially considering that when the sound comes on, the engine is producing very little power at this part of the power band).
So, it's not really a problem with the CAI itself, more with the car's TCU. Unfortunately, it's too annoying for me, so I'll be reverting back to the original air intake system, and selling the TurboKits CAI.
Passat (B6) :: 2002 - Idles Roughly - Makes Grinding Noise When Backing
I have had this problem since day one. The idle seems to be very rough once you give it some gas and drive the car it runs smooth as silk. The dealer told me that is the wayit should be due to the narrow V6 with one head cylinder. I have had an 02 Passat V6 and I dont remember it having a rough idle.
My other issue is again since day one when I am moving very slow like when I am backing out of my drive way there is what I would describe as a grinding sound. It does it all the time forwards and back, all day not just the first thing in the morning. Again the dealer says it is normal.
I just had my first oil change about 2 weeks ago and was hoping these were just thing that would be addressed then but they dont seem to be better or worse always the same.
Lexus SC430 :: 2002 - Transmission Makes Clanking Noise When Shifting
So My 2002 only has 27k miles so I'm hoping it's nothing out of the ordinary. I understand that the transmission will make some noise in shifting but I'm noticed a pretty solid "clank" when I shift especially from Park to Drive or Park to Reverse. Just wondering if other drivers have a similar experience? I remember my last car had a sort of "ratchet" sound in shifting and I've grown accustomed to this "clank" now, but just wondering of others have the same clank? If not normal, what should I look into? Also before it's recommended, I know it's not the brake caliper clips as the "clank" occurs before actual vehicle movement.
View 5 RepliesFord Excursion :: 2003 V10 - Slight Slip When Transmission Shifts From 2nd To 3rd
I have a 03 ex with a V10. Just recently my trans has started giving me problems. Sometimes when it shifts from 2nd to 3rd I get what feels like a slight slip. Sometimes it doesn't happen at all. Feels almost like it is downshifting for a second. It also doesn't seem to make any difference whether I am hard on the gas or not.
View 4 RepliesFord Excursion :: 2004 - Shifts Hard Into 2nd Gear When Starting Off Slow
Got 2004 v10 and my truck shifts hard into 2nd gear when starting off slow. If I take off at a faster pace it does not do it.
View 2 RepliesFord Excursion :: O/D Light Flashes / Tranny Shifts Funny Then V10 Dies?
My tranny guy just did a full scan and the ONLY thing which indicated a problem was 'output speed sensor' which we were able to trace back to most likely being caused by a completely hosed driveshaft (I've noticed a driveline vibration). We're going to install a new driveshaft, replace the output speed sensor(s), check for any frayed/chaffed wiring going to the output speed sensor(s) and then see where that leads us (he said something about some computer module in the dash which he's had to replace on several Sooper Dooties).
View 7 RepliesFord Excursion :: Transmission Shifts Hard - Overdrive Off Light Flashing?
So while driving to work I start experiencing some weird behavior with the transmission. It would shift hard and seem like it wasn't pulling hard at all. I looked down and saw the overdrive off light flashing. Got to work, turned the car off then started back up and the light was off. Any thoughts?
View 14 RepliesFord - Explorer :: 2002 - Gas Gauge Fluctuates / Shifts Hard If Go Over 65 MPH
I have a few problems with my explorer. I was just wondering if there's any way I can fix them on my own instead of paying a mechanic. I
1. back passenger window wont roll down .. .
2. Gas gauge fluctuates can't get an accurate reading on it .. .
3. service engine light comes on for a couple days, then goes off .. .
4. shifts hard if i go over 65mph and then slow back down .. .
Ford - Explorer :: 2002 - Shudder In First Gear / Truck Shifts Into 4wd By Itself And Stays There After New TCM
Replaced the 2002 ford explorer 4x4 traction control module because of a shudder in first gear. With the new module the shudder disappeared but now the truck shifts into 4wd by itself and stays there. I am now on my 2nd new module because I returned the first one thinking it was defective.
If I cycle the 4x4 high switch and the 4x4 auto switch, the truck switches back int 2wd but on for a moment then goes back into 4wd. I don't get a 4x4high indicator light but I can hear and feel it is in 4wd. Almost like it thinks the truck needs work with the traction. I have now disconnected the module completely and the trucks runs/shifts beautifully in 2wd. I know my transmission is good. BTW, I have no trouble codes.
Do I have a bad speed sensor somewhere? and How do I trouble shoot for it?
Ford - Explorer :: 2002 - Transmission Shifts After 3 Seconds - Won't Run Immediately After Shifting?
I've just bought a used 2002 Explorer Sport Trac (Automatic) 120k+ odo and what I've noticed whenever I shift from Park to Reverse or to Drive it takes about 3 seconds before I feel a slight jerk moving forward before I can step on the accelerator for the vehicle to move backwards or forwards but if I step on the accelerator right after shifting to any gear except Neutral it won't run immediately as if the clutch is disengaged and after about 3 seconds it will suddenly engage. Is this normal or is there something wrong with the transmission?
View 3 RepliesFord Super Duty (1999-2016) :: F350 - Trans Shifts Great Under Light RPMs But 2 - 3 Shifts Very Hard
I have 99 f350 v10 4x4 and trans shifts great under light rpms but 2-3 shifts very hard. At wide open from about 35 mph it will shift down and take off like a bullet but wont shift until I lift my foot and then it bangs hard from 2-3. All other gears are smooth. I did some searching and have found some threads saying it could be an accumulator spring that is broken? Truck has 115,000 miles on it. love the truck but want to fix this before it does some damage.
View 1 RepliesPassat (B5) :: 2002 VW Revs Then Shifts Into Gear
So I sea foamed the passat vac/intake 2 days ago and car drove fine then did oil change 1 day ago 5/30 all I had with additive resline. Since then car revs then shifts into gear or stays in wrong gear until I rev the car. Never had problem shifting until now. Low oil pressure or electrical issue from sea foam vacuum leak.
2002 VW Passat 2.8 AWD
Elantra XD (2001-06) :: 2002 - Delayed RPM Drop Between Shifts
My nephew's car is a 2002 Hyundai Elantra GLS manual. His RPM's hang when he shifts and it is a pain to shift.
I took it to the dealer and had them do TSB#04-36-011 Delayed RPM drop between shifts. This TSB supersedes TSB 01-36-025. Here is a link for the newest TSB : [URL] ....
The TSB Basically tells them to erase ECM adaption values. Then, you update the ECM with new FUEL cut-off logic. When we drove off the dealers lot the delay was not better, just different.
After driving it for a day or two we saw improvement. Now when you push in the clutch the RPM's go up slightly for a second to burn off the gas then the RPM's drop faster than before.
Intrepid :: 2002 Transmission Hard Shifts / Engine Hesitation
Our intrepid 3.5L with 135000 miles has been acting up a bit. Its had a couple hard shifts over the last few days/week that almost seemed like an engine hesitation, and this morning when slowing down from highway speed into a small town, it abruptly shifted down to 2nd and stayed there like its in "limp mode" ??.
Pulled over and checked fluid. Level looked good and smelled ok but has a brown tinge to the pink fluid.
Started to go again and it still wouldn't shift. Pulled over and shut car off. Checked codes P700 and P138.
Started car up and it shifted fine for the next 28 miles. Shut car off and parked it.