Ford Excursion :: Door Lock Rod Clip Broke?
So was replacing the actuator on a few of the doors today. I broke the clip on the passenger side rear door that attaches the exterior door handle to the locking mechanism. It's the clip that sandwiches the rod threads in place. I discovered the front and the rear doors are different in these clips.
What is the part # or diagram with description to find this part? I've found the replacement for the front door, but it doesn't fit the rear. Here is a pic of the front door one.
Dorman Products - 703-240
The difference in the part that connects the the locking mechanism. On the front its a round plug with tabs on it. For the rear it is rectangular and slides in and then rotate 90 degrees to lock in place. Cant for the life of me locate a replacement. Been researching for hours without success.
Ford - Windstar :: 2002 - Jack Hammer Noise Under The Hood At Standstill After Braking
After 3 months of complaining my wife finally got me in the van to do some errands. We came to a stop at a stop light and I hear this jack hammer noise start, lasts about 3 seconds and trails off. I am looking around the intersection, which is under construction, looking for a jack hammer and my wife says that's the noise that I have been talking about. This noise only occurs when the car is at a standstill after braking and recently happened twice when my wife stopped, released the brake and applied it again. The problem is getting progressively worse.Our mechanic's opinion is that is is a rpm sensor on one of the wheels which is sending a false signal to the ABS system to activate. Another opinion is that the master cylinder has moisture in it and needs to be flushed.This car has about 125m miles. What so I try first?
View 7 RepliesFord Excursion :: 2002 - Re-Program All Door Locks?
I have an '02 X. I have re-programmed the seat belt alarm setting per the owners manual and set the "lights on after ignition off" to suit my needs.
The one thing that is driving me nuts though is that when I turn the ignition off and get out only the driver's door is unlocked. I want ALL locks to unlock. I haven't seen anything in the manual about this. How to re-program the locks so that they all unlock when the ignition is switched off?
I've put put about 2000 miles on the X now, towing my 5000lb trailer, mild offroading and running around town. It sure puts a smile on my face!
Ford Excursion :: Fuel Pump Access Hatch?
Have any of you tried to cut an access hatch in the rear of your truck to get to the fuel pump without dropping the tank? Am I way off? can it even be done? My fuel pump took a dump with about a quarter of a tank. I'm trying to find a work around.
View 14 RepliesFord Excursion :: 2002 - Passenger Door Lock Would Not Unlock
This afternoon the Passenger door lock would not unlock, with switch, key fob or door pad,you can hear it and the lock rod moves a little but will not unlock. Now it won't lock or unlock, you can hear the actuator and see the lock rod move a little but it just won't get there. Should I get a part in hand before I tear into it or could it be a easy fix with no parts. 2002 Ex XLT 4X4
View 3 RepliesFord Excursion :: 2002 - Door Locks Quit Working?
I have a 2002 excursion xlt 4x4 v10
The door locks quit working. The previous owner did the tin foil repair... I replaced the four door actuators today. Now all of the doors lock and unlock on the manual buttons. The fob doesn't work on any door.. when i try and use the door code pad, the locks go into a cycle.. the keep trying to operate by themselves. I had to disconnect the battery to get it to stop. I can't find the door lock relays. I have most of the dash out. Where these are?
Ford Excursion :: 2002 - Keyless Keypad On Base Door
A few weeks ago I purchased front doors to go on my 02 X. I never gave the keypad a thought.....
These are new Super Duty take offs, not southern rust-free...so I paid a pretty penny for them and really want to use them...not go on the hunt again...
Having just noticed that the left door doesn't have the cut out for the keypad..Like I can still use the doors and have the keypad???
Ford Excursion :: 2002 - Power Door Locks Don't Work
After lurking here on FTE for the past several months, I finally had the opportunity yesterday to pick up a new to me 2002 Excursion Limited w/ 7.3 diesel engine. The kids (5yo twins) absolutely love it and even the wife is growing very attached
I think I bought it for a very fair price and it's in just about pristine condition with 110k on it. The previous owner took very good care of it and had just about a full maintenance history for the vehicle. The ball joints and tie rods were replaced at 90k and it still has the original tranny-it does shift very deliberately and solidly though. My first true mod will be to add the 6.0 cooler and a tranny filter to hopefully put off what seems to be the inevitable with the 4R100 transmissions. I'm not thrilled with the wheels/tires and plan on swapping them out asap along with the headlights/taillights.
If there is one particular issue so far, it's that the power door locks don't work. When the buttons are pushed (inside and out), there's absolutely no reaction - not even clicking to indicate that the actuators are bad/stuck. I've pulled the #19 fuse and it's fine - reinserting it doesn't reset anything. I'm wondering if the vehicle security module may be bd? How can I narrow it down to make sure it is indeed the problem before dropping the coin for it plus reset?
Ford Excursion :: 2002 - Door Locks Continuously Locking
Had the two batteries disconnected on the 2002 Excursion (7.3). Once reconnected, the door actuators all repeatedly lock. They all click every 5 - 10 seconds. Sometimes they click every second for about 5 seconds.
I can't actuate ANY of the door locks on the truck, the switches seem dead. Also, the "door open" LED in the dash is lit. The "THEFT" light is blinking fast as well.
I've disconnected the batteries again several times to see if I can reset whatever is going on. I am keeping a spare key in my pocket because I will get locked out otherwise.
Ford Excursion :: How To Remove Dash Bezel To Access Radio
Installed an aftermarket stereo but having problems with the steering wheel controls adapter I purchased and need to remove the radio to access the settings on the adapter. The kit I used to install the radio states that once the radio is snapped in place with the kit, the dash bezel must be removed to access the radio. I googled and I cannot find instructions on how this piece come off.
View 11 RepliesFord Excursion :: 2002 - Dash Light For Door Ajar Stays On
I own a 2002 excursion and my dash light for door ajar stays on, I pulled all of the contacts off the rear doors and hatch and found that there are no electric hook up to what I thought would be the contacts i needed to be looking at. So what relays the signal to my dash that the doors are in fact closed?
View 14 RepliesFord Excursion :: 2002 XLT - Passenger Rear Door Handle Is Broken
I have a 2002 xlt excursion. My passenger rear door handle is broken. It is the plastic clip that hold the linkage rod to the assembly (slotted) inside the door. I can't find a diagram to get a part number. Just not very technical looking things up... looking for a parts diagram or a part#?
View 2 RepliesFord Excursion :: 2002 V10 - Constant Door Ajar Warning / No Dome Light On
Bought a '02 V10 gas 4wd Ex a week ago pretty cheap, and looking to fix a multitude of little issues.
I have been reading about the door ajar warning light issue, and mine alike has door ajar light always on. However, my dome/interior lights do not react to the opening of any doors/rear door hatch.
It's not out of the question that the last owner might have disconnected what he needed to to avoid fixing the problem and still use the truck. Where to start given I can't troubleshoot down to one particular door ajar sensor?
Ford Excursion :: Tail Pipe Broke?
The tail pipe broke right in front of the muffler.
Y pipe Mod is installed. Headers are not in my immediate future as much as I would like to.
Thinking about having it straight piped, concerned about noise.
Ford - Explorer :: How To Access Wiring Bundle Connecting Door And Car Body
I've had a problem with non-operational power windows on my 03 Explorer and in fiddling around I've found that there is something up with the wiring bundle between the drivers door and the car body. If I wiggle the bundle of wires I can get the windows operational again temporarily so there is some sort of short happening.
I'm not sure of the best way to access the wiring bundle though - they're surrounded in a rubber casing and the only way I can see to get access would be to cut the rubber casing to either open up a section or completely remove it. Trying to pull the casing back from either end just doesn't give enough access to the wires.
Is that my only option - cut the rubber casing?
Ford Excursion :: V10 - Coil Bolt Broke Off And Stuck
Looks like if it was broken off but they tried to jb weld it in place and now I cannot get it out.
View 13 RepliesFord Excursion :: Snapped Front Spring Broke?
Just had a front spring snap on my front drivers side on a road trip to the cottage. Found a place one hour away that can do new replacement front springs. The question that I have is that he can get F450 equivalent springs a lot cheaper than F350 springs. I do plan on adding an aftermarket bumper at some point in the future. What should I order?
View 14 RepliesFord Excursion :: 2003 - Broke Front ABS Sensor Off?
I was attempting to replace the front abs sensor on my '03 Excursion 4x4 when it broke off inside the hole. I tried grabbing the plastic surrounding the magnet, but it just kept breaking off. How I can get it out?
View 5 RepliesFord Excursion :: 2000 V10 - Transfer Case Broke In Half
Having problems. Transfer case broke in half, I think it is because of the auto free wheeling hubs. Is it possible to manual hubs on it?
View 11 Replies